Full Answer
How to clean a golf cart muffler?
First spray the inside of the muffler using the chamber cleaner. After a few minutes, scrub inside the golf cart muffler with the help of a brush. Place a container under the muffler to keep the carbon particles that come out from the golf cart muffler.
Why is my Yamaha golf cart smoking?
A Yamaha golf cart may be smoking because the exhaust is plugged with burnt oil that causes back pressure. If it’s blowing the oil fill cap off, then oil is clogged up and causing pressure in the crankcase.
How do I Stop my G22 golf cart from smoking?
Replacing the fuel pump, fuel filter, spark plug and air filter of your cart can also fix smoking problems. If your G22’s oil is overfilled then it will smoke. Drain the old oil and clean out your airbox if there’s oil in it. Then fill in exactly one quart of oil to your G22. This should fix your smoking issue.
Why is there oil in the airbox of my Yamaha golf cart?
If that’s the case then you need to rebuild your engine to replace the rings and fix the problem. Why is there oil in the airbox of your Yamaha golf cart? There’s oil in your airbox because there’s too much oil in your engine. If there’s too much oil, it’s probably because of a mismarked dipstick in your engine.
How do you get rid of the smell of exhaust fumes?
2:335:16How to get rid of the exhaust smell in your Ford - YouTubeYouTubeStart of suggested clipEnd of suggested clipGet it replaced. That will take and put you at zero exhaust emissions at least that is my case nowMoreGet it replaced. That will take and put you at zero exhaust emissions at least that is my case now don't clamp it you have to weld it you want it air tight.
Why does my golf cart smell like gas?
Gas-powered golf carts run on traditional fuel and produce carbon monoxide emissions. They do have a “gas smell” especially in confined area like a garage or shed. A lot of the newer gas models do a better job of routing exhaust and minimizing the gas smell.
Why is my Yamaha golf cart smoking?
Why is your Yamaha golf cart smoking bad? A Yamaha golf cart may be smoking because the exhaust is plugged with burnt oil that causes back pressure. If it's blowing the oil fill cap off, then oil is clogged up and causing pressure in the crankcase.
Why is my Yamaha gas golf cart backfiring?
Engine backfiring occurs when there is an air leak within your golf cart or sometimes when there is too much fuel inside. This can cause the piston to slam against the cylinder head and cause a tapping sound. An essential component of any golf cart is the drive belt.
Why does my golf cart smell?
A Sulphur-Like Smell The cart can smell Sulphur-like due to overcharging of the batteries or insufficient water levels in the batteries. Switching off the engine rather than starting it again could avoid the smell for about 30 minutes, but using this process continuously could harm the battery's longevity.
Why does my gas golf cart smell like rotten eggs?
Well, this rotten egg-like smell is due to the discharge from the batteries in the golf cart. Golf carts can smell bad due to a gas being released when the golf cart batteries are being charged. The gas produced during charging has a sulfur-like odor which smells like rotten eggs.
How do I stop my gas golf cart from smoking?
Fill your engine with the correct amount of oil. If your carts muffler has oil in it, it will blow out smoke. If you've got this problem, run your cart hard on a long run to the oil out of the muffler. You can also just switch out your muffler with a new one to solve this problem.
How do I clean the exhaust on my golf cart?
0:566:41How To Clean Your Car Exhaust! FT. Golf R / Fiesta ST - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd yes you can see on screen that's just basically what I use auto Sol metal polish. I also justMoreAnd yes you can see on screen that's just basically what I use auto Sol metal polish. I also just used an old cloth to be honest I probably could use a newer one that that kind of does the trick.
Why is my electric golf cart sputtering?
If your cart seems to run fine for a few feet, and then it stutters, it is most likely the batteries. If it is not the battery, then check if it is the speed controller or the resistor. If it is the controller, then you will need a replacement. Otherwise, upgrading the resistor can also solve the problem.
How do you stop a Yamaha golf cart from backfiring?
One simple way to stop the golf cart from backfiring is to use good quality fuel. Once this is done, ensure that the throttle plate is closed by adjusting the accelerator cable at the plate.
Why does my golf cart backfire when I let off the gas?
In almost all cases, whether it is a 2 cycle or 4 cycle engine, golf cart backfiring is caused by the accelerator cable being out of adjustment at the throttle plate of the carburetor. This problem has a relatively simple cure.
How do you adjust the governor on a Yamaha golf cart?
0:005:15Yamaha G29 Drive Golf Cart Governor Adjustment - MORE SPEED!!YouTubeStart of suggested clipEnd of suggested clipItself by tightening this nut down you're putting more pressure on the spring. So that the governorMoreItself by tightening this nut down you're putting more pressure on the spring. So that the governor has to work harder to pull back on the throttle.
Why does my golf cart smell like sulfur?
Why does your golf cart smell like sulfur? A golf cart may smell like sulfur due to not having enough water in the golf cart battery. Overcharging batteries can also produce a sulfur smell in a golf cart.
Why does my golf cart smell like rotten eggs?
Why do golf carts smell like rotten eggs? Golf carts can smell like rotten eggs due to a sulfur gas being produced during the charging of the golf cart batteries. Gas carts can emit a multitude of smells if they are not functioning properly.
Why does my cart battery smell like burning plastic?
If the batteries have no water in it or electrolyte in it, it could give out a smell of burning plastic. It would help to get the electrolyte level checked in your cart battery. Sometimes, the wiring could also create an issue. Check if any of the wires are sparking up or burning, which could cause the smell.
What does a battery smell like?
The gas produced during charging has a sulfur-like odor which smells like rotten eggs. The smell is worse during the first few charges but tends to get better with time. The batteries have an algorithm for deep charging, specially designed to help charge faster and more efficiently.
Why does my cart smell like it's burning?
On the other hand, a loose connection between the battery wires or any other wires could also cause a burning smell. Thoroughly check all the wiring before you proceed to take out the cart and use it.
Why does my gas tank make a click sound?
You can listen for this ‘click’ sound to ensure that the cap is closed properly and gas doesn’t leak out . If the problem persists despite trying out all these, then there might be an issue with your gas tank or the mechanism.
Is it safe to ventilate a golf cart?
It is strongly advised to ventilate the golf cart well to ensure that the stench of the gas goes away. The gas is not particularly good for the lungs and people with lung or respiratory issues are advised to stay away until the cart is properly ventilated and any residual smell has been removed.
How to clean carbon buildup on golf cart muffler?
First spray the inside of the muffler using the chamber cleaner. After a few minutes, scrub inside the golf cart muffler with the help of a brush. Place a container under the muffler to keep the carbon particles that come out from the golf cart muffler. Repeat this step continuously until all the carbon buildup removes from the muffler.
How to control muffler speed on golf cart?
To control your golf cart muffler’s speed, check the controller and continuously variable transmission. Add a soundbar: To get rid of this issue, you can add a portable sound system. Make sure that the sound system you choose is capable of rugged. It should be waterproof.
Why is my golf cart muffler clogged?
The causes of a clogged golf cart muffler are bad cable adjustments, using a poor fuel mixture and the buildup of carbon on the pistons and valves . 1. Bad cable adjustments: You should check the throttle cable that may slide from its position. Because of the loosening nut or screw, the golf cart muffler may be clogged.
Why does my golf cart rattle?
A golf cart muffler rattles due to bad engine issues, transmission problem, battery problem & ignition problem. To fix this issue, you can try yourself out; otherwise, you can visit a servicing center.
How to tell if your golf cart is clogged?
A clogged golf cart’s common symptoms are poor acceleration, leaking gas, bad combustion, etc. 1. Leaking gas: If you face leaking gas issues in your golf cart, then there is a high chance that it may cause a dirty valve set, wrong fuel level, and damaged engine. 2. Poor acceleration:
What are the issues with the Ezgo golf cart?
1. Leakage: If you face issues in gas leakage in your Ezgo golf cart, you should check the fuel level, air filters, and engine to troubleshoot the issues. 2. Low gas economy: Most of the people who have a 1990’s model of golf cart muffler may go through these issues.
Why is there oil in my Yamaha golf cart?
Why is there oil in the airbox of your Yamaha golf cart? There’s oil in your airbox because there’s too much oil in your engine. If there’s too much oil, it’s probably because of a mismarked dipstick in your engine. To fix this, drain out all the oil in your engine then fill in exactly one quart of oil.
Why does my Yamaha golf cart smoke?
A Yamaha golf cart may be smoking because the exhaust is plugged with burnt oil that causes back pressure. If it’s blowing the oil fill cap off, then oil is clogged up and causing pressure in the crankcase.
Why does my Yamaha G16 burn oil?
Your Yamaha G16 is burning oil because it has fuel in the oil. The first thing you should try to fix the burning oil problem is replace the old oil in your cart with exactly one quart of high quality oil. Hopefully this immediately fixes your problem. If your oil is overfull then your G16 will burn oil.
Why is my G16 oil overfilled?
Your oil being overfull might be because you lifted your cart which causes your oil dipstick reading to be off (the full mark is incorrect). This causes you to overfill your oil. If your oil smells like gas and is too overfull then gas will get dumped into the crankcase of your G16 and cause smoking.
How to fix a G16 engine?
To fix this, take out your airbox and clean it, clean your carburetor, drain your oil and fill in exactly one quart of oil.
Why is my Yamaha G9 smoking?
Your Yamaha G9 might be smoking because your oil rings are stuck on a piston due to engine sludge buildup. If this is the case, your engine needs to be rebuilt to fix it. Your G9 might be smoking because of oil in the muffler. Run your cart hard for 30 minutes to an hour or cook your muffler in a bonfire to fix this.
How to fix a G16 airbox?
Fix this by draining your G16’s oil and then filling in exactly one quart. Clean out the excess oil in your airbox as well.