- Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. ...
- Mix 8 ounces of Epsom salts into 2 quarts of warm distilled water: Stir thoroughly. ...
- Put the battery or batteries on a charger
What is the best battery for a golf cart?
Keep Golf Cart Battery Cells Full. Fill battery cells with distilled water one quarter to one half inch above the plates. Do not use tap water. The water level you fill will dictate how often you will need to check the battery.
What are the best golf cart batteries?
Jun 07, 2017 · Kerry shows you how to properly fill your electric golf cart's batteries.http://golfcarsunlimitedinc.comFollow us: https://www.facebook.com/golfcarsunlimitedinc
Who has the best golf cart battery charger?
Dec 03, 2021 · The battery cells (aka water fill holes) should be filled with distilled water (not tap water) between 1 and 12 inches above the plates. The top of the batteries will likely accumulate more acid if you have 14 inch of water on them, but if you have 12 inch of water on them, you will have to check them more often.
Where to buy Trojan battery?
Clean the battery top with a cloth or brush and a solution of baking soda and water. • When cleaning, do not allow any cleaning solution or other foreign matter to get inside the battery. Rinse with water and dry with a clean cloth. Clean battery terminals and the inside of cable clamps using a post and clamp cleaner.
How much water do you put in Trojan golf cart batteries?
How full do you fill golf cart batteries with water?
How do you recharge golf cart batteries?
Do you fill golf cart batteries before or after charging?
What happens when golf cart batteries are low on water?
Can you revive a dead golf cart battery?
How do you put a golf cart battery back to life?
- Step 1: Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. ...
- Step 2: Mix 8 ounces of Epsom salts into 2 quarts of warm distilled water: Stir thoroughly. ...
- Step 3: Put the battery or batteries on a charger.
How do I know when my golf cart is fully charged?
How do you add water to a Trojan battery?
Do you have to add water to golf cart batteries?
How do I know if my golf cart batteries need water?
How to clean a battery?
1. Examine the outside appearance of the battery. Look for cracks in the container. The top of the battery, posts, and connections should be clean, free of dirt, fluids, and corrosion. If batteries are dirty, refer to the Cleaning section for the proper cleaning procedure. Repair or replace any damaged batteries.
Do batteries need water?
Flooded batteries need water. More importantly, watering must be done at the right time and in the right amount or the battery’s performance and longevity suffers. Water should always be added after fully charging the battery. Prior to charging, there should be enough water to cover the plates.
What is a deep cycle battery?
Deep-cycle batteries are used for various types of applications specific such as RV, golf cars, renewable energy, and marine.
What is the electrolyte in a VRLA battery?
In the flooded types, the electrolyte is a solution of sulfuric acid and water that can spill out if the battery is tipped over. In VRLA batteries, the electrolyte is suspended in a gel or a fiberglass-mat (AGM technology), allowing these batteries to be mounted in a variety of positions.
What is a VRLA battery?
In VRLA batteries, the electrolyte is suspended in a gel or a fiberglass-mat (AGM technology), allowing these batteries to be mounted in a variety of positions. Before getting started, be sure to identify the type of battery involved.
How many batteries are needed for a 48 volt system?
For example, you may connect a series of eight 6V batteries, six 8V batteries or four 12V batteries for a 48-volt system.
Does connecting batteries in series increase the capacity of the battery?
Connecting batteries in series does not increase the capacity of the batteries; it simply increases the overall voltage to meet your system requirements. Once your voltage requirements are met, and if space allows, you can double the batteries in a parallel connection — thereby doubling your battery capacity.
When to change golf cart batteries?
March 29, 2019. So, it’s time to change your Golf Cart Batteries. The signs are already visible. Your cart starts to slow down before you finish 18. The batteries don’t seem to take a full charge. You could truck your cart to a dealer or have someone come by and install the new batteries for you, but all of that adds labor to the cost ...
How to clean battery bays?
Battery acid can permanently mark concrete and almost anything else. Then grab your baking soda and water solution and totally clean the battery bay and dry with a towel. Use a paint scraper to remove any excess acid.
Can you add water to a battery?
Never add water to a battery when it is discharged. An equally important thing to consider is the type of water you should use to refill your battery. Regular tap water is no good. It contains minerals, chemicals, and other contaminants which will disrupt the chemical processes that take place inside the batteries.
Why do you need to refill a battery with water?
You are only required to refill your battery with water in order to maintain the chemical makeup of the battery. However, accidents can happen, and a battery may be tipped or dropped, causing the acid to spill out. If this happens, you will need to replace the sulfuric acid that has been lost.
What happens when you recharge a battery?
This water evaporation is a normal part of deep-cycle battery functionality, and when you recharge the battery, the water quantity is usually restored to its optimal amount. However, after a number of charge cycles, or if the cart has not been used for a while, you might notice that the water levels are low even when the battery is not discharged.
Why do batteries dry out?
The heat causes the water to evaporate, diminishing your batteries’ access to the crucial electrolytes. When the water levels are low, the battery plates will be exposed to the air for longer than they should be, which will cause them to dry out and flake off. This results in a condition called sulfation.
What happens when water levels are low?
When the water levels are low, the battery plates will be exposed to the air for longer than they should be, which will cause them to dry out and flake off. This results in a condition called sulfation. Once sulfation takes hold, your battery will no longer hold a charge, rendering it useless.
What happens when a battery is discharged?
When a battery is discharged, the water level will be low by design. If you refill it, and then charge the battery, it will overflow. This will leak battery acid everywhere, which will then cause corrosion. Never add water to a battery when it is discharged.
Why do you need distilled water for batteries?
Instead, you must use distilled water. This is because distilled water is essentially pure water, free of any contaminants that will harm your battery. Now for the process.
Can you replace a golf cart battery?
If the ride and power is short lived it is still likely you will need to replace your golf cart battery. It is also quite possible that your golf cart battery charger is not charging properly. You will need a volt meter to check the power output of your battery charger.
How to clean a battery with acid?
Step 1: Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. Clean the battery with your paintbrush dipped in a baking soda solution. Rinse your battery with plain water, making certain none of the water gets into any of the cells.
What is the phone number for Trojan Battery Company?
Please contact Trojan Battery Company’s technical support engineers at 800-423-6569 Ext. 3045 or +1-562-236-3045 for help interpreting any test data.
How to prevent corrosion on battery terminals?
To prevent corrosion, after tightening the fasteners, apply a thin coat of terminal protector spray that can be purchased through your local battery dealer.
What is battery cable?
Battery cables provide the link between the batteries, equipment and charging system. Faulty connections can lead to poor performance, terminal damage, meltdown, or fire. To ensure proper connections, please use the following guidelines for cable size, torque values and terminal protection.
Do batteries need to be charged before shipping?
Due to the potential for self-discharge during shipping and storage, batteries should be given a full charge prior to first use. See the next section for details on proper charging.
Why is it important to charge a battery?
Proper charging is imperative to maximize battery performance . Both under- or over-charging batteries can significantly reduce the life of the battery. Most chargers are automatic and pre-programmed, while others are manual and allow the user to set the voltage and current values.
Do deep cycle batteries release gas?
Deep-cycle flooded/wet lead acid batteries release small amounts of gas during usage, particularly during the charging process. Deep-cycle AGM and gel batteries do release gas, but at a much lower rate than the flooded types. It is critical to charge batteries in a properly ventilated area.
Where should batteries be stored?
Batteries should be stored and installed in a clean, cool and dry place , keeping water, oil, and dirt away from the batteries. If any of these materials are allowed to accumulate on the batteries, tracking and current leakage can occur, resulting in self-discharge and possible short-circuits.
