Locate the golf cart’s governor; you can find the governor by tracing the thickest cable running from the gas pedal. This cable runs through the governor on its way to the carburetor. Use a screwdriver—or in some cases a wrench—to loosen the tension on the governor’s springs.
Full Answer
How do you fix a golf cart that stalls on hills?
The brake bub will spin out when there is too much load to prevent any damage to the rear axles, causing the golf cart to stall on hills. Remove the covers from the rear wheel. Notice the castle nuts that are holding the hub to the axles. Apply the brakes.
What should I do if my golf cart is not accelerating?
If nothing happens, it’s most likely an electrical issue. On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge. If there is no click when the pedal is pushed, then there is no solenoid activity.
How to troubleshoot a gasoline golf cart?
How Do You Troubleshoot a Gasoline Golf Cart? Spark Plugs. Let’s start with the spark plug. ... Is it all oily, fouled, or the gap bridged in any way? If this all... Fuel. Okay, the electrical system checks out and the engine still won’t start. Before screwing the spark plug back into... Air. Check ...
How do I Reset my Electric golf cart?
On electric motors there are often reset buttons that act like mini circuit breakers. Generally, where the wires enter the unit a small little red button will be sticking out in that same vicinity. Find the button and push it back in. Test the cart. When the reset button has been pushed it, turn the cart on and gently push on the power pedal.
How do you fix a golf cart accelerator?
Open up your cart hood and find the wires connected to your controller. Check to make sure each of these wires is properly screwed down and held in place. Inspect all other wires throughout your engine and accelerators. Tighten the connections on these wires to ensure that they run smoothly.
Why does my golf cart click but not move?
A Club Car golf cart can start clicking but not move, due to dust accumulating inside the battery ports. Opening the battery ports and checking whether there is any dust accumulation can tell you if this is the case. Cleaning it thoroughly with a cloth can resolve the problem.
How does an electric golf cart gas pedal work?
How Does An Electric Golf Cart Accelerator Work? The golf cart speed controller and solenoid are both controlled by the accelerator. The pedal is connected to the potentiometer. That means when you are pressing the pedal for acceleration, you are actually going through the potentiometer by pushing a rod.
What would cause a golf cart not to move?
Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
Why wont my golf cart go forward or backwards?
Check the Forward/Reverse switch of your golf cart for loose connections. If the connections are intact, interchange the top and bottom wires at the rear. If the cart now goes in reverse but not forward, the problem is with the switch. You have to just change the switch in this case.
Why is my electric golf cart making a clicking noise?
Golf Cart Making Clicking Noise Typically, a clicking noise on a golf cart suggests that wheels drums may be touching the sides of the vehicle. You may also hear a click sound if your car has lost any bolts that are wiggling in place as you ride your cart.
What does a potentiometer do on a golf cart?
It sends an electrical signal to the speed controller from the accelerator pedal, indicating the pedal's position. When it is working properly, the potentiometer allows your golf cart to accelerate smoothly. Find your potentiometer and inspect it for any cracks, broken parts, or disconnected wires.
Are golf carts easy to fix?
What if you find a problem with the motor housing or the armature? Unfortunately, these electric golf cart issues aren't so easy to fix. You're probably better off to replace the motor than trying to salvage what's left of it.
How do you troubleshoot an electric golf cart?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do I know if my golf cart solenoid is bad?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
How do you tighten the belt on a EZGO golf cart?
How to Adjust the Drive Belt on an EZGO Golf Cart. There is no way to adjust a drive belt, so it's important to get the right size belt in the first place. To be sure, visit your local mechanic or call a certified technician to help you get the right drive belt for your EZGO golf cart.
Why is my golf cart not accelerating?
When your electric golf cart does not accelerate, the first thing you need to keep in mind is that it is not a regular vehicle like your car . That's why the methods and solutions you use to get your car to start are not the same as the solutions you can apply to your cart.
What happens if your golf cart doesn't accelerate?
Bad Solenoid. If your golf cart does not accelerate, there is a possibility of the damaged solenoid. The solenoid is basically an electrical switch that enables the battery's flow from the battery into the motor. Check out the signs of the bad solenoid.
Why is my golf cart speed controller not working?
There are many reasons behind a speed controller malfunction. The most common problem that happens in the controller has aged due to infrequent use. These are just some of the issues that could be affecting your vehicle's acceleration. If you have trouble finding the issue of your golf cart accelerator, don't be afraid to take it to the mechanic.
How does a golf cart solenoid work?
The golf cart speed controller and solenoid are both controlled by the accelerator. The pedal is connected to the potentiometer. That means when you are pressing the pedal for acceleration, you are actually going through the potentiometer by pushing a rod. The potentiometer works as a communicator and tells the speed controller how much voltage it ...
What does it mean when your cart doesn't start?
If your cart does not start smoothly, hesitates before starting, or does not gain speed properly, these are all signs of a bad or damaged accelerator.
How to check for leaks in golf cart?
You can check for any leaks by following these steps: Crank up the golf cart and check every seal for leakage. You can also spray wd40 at the clutch to find leaks. When the cart becomes hot, the voltage also drops. So, make sure you provide enough voltage to the batteries so the cart can run.
What happens when you press down the gas pedal on a gas cart?
The solenoid gets pressed down to a thin plate. After repeated use of the cart and pressing down of the gas pedal, the pressure creates small electric arcs on the thin plate. This restricts the current from flowing.
Why does my EZGO golf cart hesitate?
The main reason why an EZGO Gas golf cart hesitates while accelerating, is because of a dirty carburetor. A dirty carburetor causes this hesitation. Regular cleaning can prevent this problem. Check the rubber boot and clean if you spot any dirt. In case it has worn out too much, you can replace the carburetor.
How to check if a cart is stalling?
You can easily check that. Run your cart for a few feet and feel the temperature. The same loose ends can also cause the cart to stall. Check every connection inside the battery for proper connection.
Why does my golf cart stall?
The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller. Batteries have lost charge. Faulty ignition. Problem with the direction switch. Faulty speed controller. Bad solenoid. The solenoid wears out every time the gas pedal is pressed down. The solenoid gets pressed down to a thin plate.
Why does my cart stutter?
If you change the battery, change the charger as well; otherwise, the battery will keep running down. If your cart seems to run fine for a few feet, and then it stutters, it is most likely the batteries. If it is not the battery, then check if it is the speed controller or the resistor.
Why does my golf cart stall when running forward?
If a golf cart runs in reverse, but stalls when running forward and accelerating, this indicates a faulty f/r switch.
How to charge a golf cart?
Step 1. Test the wall socket where you charge your cart. Every golf cart has a built-in charger that connects to a wall socket. Take your wall socket 120-volt tester and check the actual socket that you use to charge the cart itself. Plug in your 120-volt tester and make sure the actual wall socket is good. If there is no voltage reading, your ...
What are the problems with electric golf carts?
Electric golf carts have two areas where problems usually occur, the batteries and the motor. Before you spend a lot of time and money waiting on a repairman or taking your electric golf cart to the shop, take a few seconds to troubleshoot the cart on your own.
What to do if your socket is not reading voltage?
If there is no voltage reading, your socket is bad and either needs to be replaced or the circuit breaker needs to be reset. You can reset the circuit breaker by flipping all the switches in your breaker box. An electrician should replace the socket.
How to inspect a golf cart motor?
Located under a panel at the back of your golf cart will be the electric motor. The panel will be held in place by four or six screws. Use your screwdriver to remove these, turning them counterclockwise.
Where is the electric motor on a golf cart?
Located under a panel at the back of your golf cart will be the electric motor. The panel will be held in place by four or six screws. Use your screwdriver to remove these, turning them counterclockwise.
Where are the batteries in a car charger?
If you are getting power to the charger, it's time to check the batteries. Most batteries are located under the seat, which flips up for access. Grab a hold of the back of your seat and flip it up to expose the batteries. There will be a row of batteries. Each one of these need to be checked.
Can you use a carburetor on an electric cart?
There is no carburettor on an electric cart. Carburettors supply a mixture of fuel and air to the engine in a petrol engine.
Does the 2001 Ez Go golf cart have power?
Everything has power on my 2001 ez go golf cart everything is new but when I hit the gas pedal it dont move
Do carburetors have brushes?
Carburettors do not have brushes. Carburettors are on gas carts. Brushes are for electric carts.
How to replace battery in golf cart?
Since nearly all golf carts are electric, the battery often runs down and when empty the cart will not function at all. Remove the battery by disconnecting the cables to the battery terminals. Wearing gloves, remove the battery and replace it with a fresh one.
How to clean a cart battery?
If the cart still does not function with a fresh battery installed (one you are certain is fully charged), remove the battery cables and clean them by brushing with a wire brush. Inspect the battery case for leaks, cracks or damage. If the casing is cracked, a fresh battery needs to be installed.
Why are my golf cart batteries dead?
Keep your golf cart in good running condition with a little know-how. Golf carts frequently become damaged because of overuse, improper use or a lack of maintenance. The latter often results in dead batteries, which can be fixed rather simply.
How to fix a flat tire?
To fix a flat tire, first attempt to inflate the tire with an electric air pump. Listen for hissing sounds (air being released) and see if the tire remains inflated. If not, jack up the golf cart on a car jack. Remove the lug nuts that secure the tire to the axle and remove the entire wheel rim and tire. Replace the complete wheel rim and tire ...
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
Why won't my golf cart start?
Your golf cart won’t start if there is a problem with the fuel, airflow, or electrical system. Any one of these areas can cause your golf cart to fail to start. Try these steps to troubleshoot and pinpoint the exact failure point.
How to keep electric cart from being stationary?
The electric cart has many battery connections to be checked over and cleaned of all corrosion. A single battery failure in the battery pack could keep your cart stationary. Clean each of the terminals and tighten them back down.
How to check if golf cart starter is corrosion?
Find the ignition wire on your golf cart. This runs from your ignition switch to the starter solenoid. Check this over for corrosion on either end and make sure you’ve got a tight connection. If the connections use a spade lug, pull the connection loose, wipe off the terminal, and plug it back in again. Try to start the cart now.
How many hoses does a gasoline cart have?
The fuel pump on most gasoline powered carts usually has three hoses going to it. One is the gasoline in, one is the gasoline out, and the third is a hose that hooks to the crankcase vacuum.
How to check if a gas cart battery is charged?
First, you turn the key, press the pedal, and listen for a click. If nothing happens, it’s most likely an electrical issue. On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge.