Golf-FAQ.com

how to fix club car golf cart

by Hulda Hudson MD Published 3 years ago Updated 2 years ago
image

How to Fix a Club Car golf cart that keeps running

  • Examine the linkage and make sure they are working properly.
  • Check whether the solenoid is OK and Replace it.
  • On the right-hand side of the car motor, there is a wired connection. Sometimes it can loosen up. Remaking it can solve your problem.
  • The top one of the microswitches may cause the problem. Fixing it should be enough.
  • Seek help from professional and ask them to inspect if the gas cables are alright (if you have a gas golf car).
  • Replace the battery.
  • Check if the onboard computer or OBC is all fine.

Full Answer

How do you align a golf cart?

How to install Club Car front leaf spring

  • Put the sleeve inside the bushings at the front leaf spring. Place two sleeves around each end of the bushing at front leaf spring. ...
  • Jack up the Club Car from the back. Use a ¾-inch socket to loosen the lug nuts on the back tire. ...
  • Take OFF the shot. ...
  • Take OFF the old leaf spring. ...
  • Install the new leaf spring. ...
  • Re-install the tire and repeat on the other side. ...

How do you fill the battery in a golf cart?

Step-by-step Guide

  • Step 1. – Insert pump into jug of distilled water! ...
  • Step 3. – Once hand pump bulb is primed remove the dust cover from the end of the fill line on your battery watering system.
  • Step 4. – Squeezing the golf cart battery watering system hand pump with firm steady pressure to pump water into the battery cells.
  • Step 5. ...
  • Step 6. ...

How to properly drive a golf cart?

  • When you go for your backswing, you should shift your weight backward. This will give your swing more power.
  • A lot of times your instinct might be to have a fast backswing thinking that it will give you more power to crush the ball. ...
  • Stay flat. ...
  • Take a steady backswing and pause at the top to reset before begin your downswing. ...

How to quiet a golf cart?

Why are golf carts noisy?

  • Engine size. The size of a golf cart’s engine will generally dictate how much noise it makes. ...
  • Insulation. Even though there’s not really much to a golf cart, most will have some kind of insulation. ...
  • Mufflers. Not all gas golf carts will come with a muffler fitted because it’s not a legal requirement. ...
  • Mechanical issues. ...

image

How do you fix a non running golf cart?

2:5011:17One simple trick to fix non running golf cart. - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo we can use this little angle pick tool hopefully go in there and hook it pull it back up out ofMoreSo we can use this little angle pick tool hopefully go in there and hook it pull it back up out of the way over here drop the new brush in set the spring back down on it fasten.

Why won't my golf cart go forward or backwards?

The problem could be with either the Run/Tow switch or Forward/Reverse switch or both. Check the switches to ensure that they aren't stuck midway. If they are, getting them released should help. However, if they show signs of wear and tear, you must get them replaced.

What would cause a golf cart not to move?

Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.

What causes a golf cart to suddenly stop?

If the connections from the solenoid have become loose or if there is some other loose contact, the cart might behave in this manner. It can also be caused by a faulty motor or a faulty key switch. If the micro-switch is faulty, it can also cause the cart to suddenly stop midway.

How do you diagnose a golf cart problem?

There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.

Why does my golf cart click but not move?

A Club Car golf cart can start clicking but not move, due to dust accumulating inside the battery ports. Opening the battery ports and checking whether there is any dust accumulation can tell you if this is the case. Cleaning it thoroughly with a cloth can resolve the problem.

Where is the reset button on a Club Car golf cart?

Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.

Where is the reset button on golf cart motor?

First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!

How do you know if your golf cart motor is bad?

You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.

Why does my electric golf cart have no power?

If you're lucky, the problem could be as simple as a loose wire or a broken coil. In some cases, corrosion can also be a factor. If you suspect a faulty solenoid, your best bet is to take your cart to a repair shop. A mechanic can diagnose the problem and replace the solenoid if necessary.

Why are golf carts used?

Golf carts were originally used to transport those with disabilities who couldn’t walk far distances on their own. It was realized that golf carts could also offer useful transportation on golf courses, but they were not widely accepted at first.

What color are golf carts?

Golf carts are commonly white in color.

How to prevent battery malfunction in golf cart?

To reduce the risk of battery malfunctions, do general maintenance on a regular basis by making sure your batteries are properly watered and free of corrosion. The most obvious sign of an issue with the batteries is when your golf cart doesn’t start. The first thing to do in this case is to fully charge your battery.

What are the problems with electric golf carts?

With frequent use, problems with the battery, tires, and other parts are extremely common.

How to fix a flat tire that won't inflate?

If a flat tire refuses to inflate due to a leak, replace it. Begin by raising your car with car jack. Then, unscrew the lug nuts, and remove the tire and wheel rim. Then, replace the old tire with a new one.

Why is my golf cart not clicking?

When the solenoid isn’t working properly, you might stop hearing the clicking sound, and your cart might have intermittent issues starting. If your battery is working well and your car is having trouble starting, it might be time for a solenoid replacement. Properly maintaining your golf cart will help to ensure it’s in prime condition ...

What to do if your cart doesn't start?

The first thing to do in this case is to fully charge your battery. If after doing this, your cart still doesn’t start, then your battery is probably dead. Before changing the battery, take a look at the terminal cables to see if they’re the root cause of the problem by cleaning them and making sure they look alright.

What is a solenoid on a golf cart?

A solenoid is a cylindrical coil of wire responsible for carrying electric current to the motor. It’s not uncommon for this part to stop working because it has to work constantly when you use your golf cart.

How to find tire pressure?

To find the right pressure, check the air pressure rating in each tire’s rim. Then, with an air pump, inflate each tire to the appropriate pressure.

Securing a stable connection

A faulty circuit will never establish a secure connection. Ensuring a stable connection means setting the circuit in the correct order.

Finding out the blown-out fuse

Locating the fuse box can be intimidating if you don’t know where to find it. Let us start with the Club Car-

Fixing the faulty fuse

This is our final task that should fix the headlight problem. Now that we have located our fuse-box, it is the time to get into the work-

Some specific reasons to prevent fuse-damage

An older cart is more prone to fuel damage. Besides, a faulty electrical system can always make the cart vulnerable to damages. Here are some of the specific reasons that can cause fuse damage. Do check them frequently to ensure a safe connection-

image
A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9