You can use a mixture of baking soda and water to clean the terminals by removing corrosion and other debris. Look inside the battery to ensure that distilled water is fully covering the conductor plates. The cart's solenoid wire may also cause problems. This insulated wire channels the electric current from the battery that powers the cart.
Full Answer
Why is my electric golf cart not starting up?
If the solenoid is functioning properly, the battery is connected and charged, and you still are having a problem with the cart, then the problem is likely the motor. Check the motor for loose wires and make sure there is resistance from the drive belt.
Do you need to hire a professional to replace your golf cart?
Whether you own an electric or gas golf cart, it’s going to face some technical issues down the road. With frequent use, problems with the battery, tires, and other parts are extremely common. When the time comes to dealing with some of these complications, you have the option to hire professional help.
How do I know if my golf cart motor is burned out?
Test the cart. When the reset button has been pushed it, turn the cart on and gently push on the power pedal. If the cart moves, you have solved the problem. But if there is no motor noise at all, the motor is burned out and needs to be replaced.
How do you reset the power button on a golf cart?
Generally, where the wires enter the unit a small little red button will be sticking out in that same vicinity. Find the button and push it back in. Test the cart. When the reset button has been pushed it, turn the cart on and gently push on the power pedal.
Why is my Yamaha golf cart not working?
If your cart is sluggish or won't start, the battery may need to be charged. If it is charged, but still not working properly, make sure the battery terminal connections are clean and secure. You can use a mixture of baking soda and water to clean the terminals by removing corrosion and other debris.
Where is the reset button on Yamaha electric golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
Why does my Yamaha golf cart not move?
The main cause of a Yamaha golf cart clicking but not moving, is a faulty controller or solenoid. The battery has to be checked first to see if it's delivering the right voltage while in the idle state as well as when the pedal is pressed.
Why did my electric golf cart stop working?
If you're lucky, the problem could be as simple as a loose wire or a broken coil. In some cases, corrosion can also be a factor. If you suspect a faulty solenoid, your best bet is to take your cart to a repair shop. A mechanic can diagnose the problem and replace the solenoid if necessary.
Where are the fuses on a Yamaha electric golf cart?
Yamaha Golf Cart Fuse Box Location The fuse box in a 2014 Yamaha golf cart is located on the left side of the controller. The wires are tied to the roof drain. In a G2 electric cart, the fuses are present on the rear inner fender. This is on the front of the driver's side of the cart.
How do you troubleshoot an electric golf cart?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.
Why won't my Yamaha golf cart go forward or reverse?
The reason why your Yamaha G1 Golf cart is not moving forward is because a faulty solenoid. If your golf cart moves forward but not in reverse, you need to replace your solenoids.
How do you reset an electric golf cart?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
What are the problems with electric golf carts?
Electric golf carts have two areas where problems usually occur, the batteries and the motor. Before you spend a lot of time and money waiting on a repairman or taking your electric golf cart to the shop, take a few seconds to troubleshoot the cart on your own.
How to charge a golf cart?
Step 1. Test the wall socket where you charge your cart. Every golf cart has a built-in charger that connects to a wall socket. Take your wall socket 120-volt tester and check the actual socket that you use to charge the cart itself. Plug in your 120-volt tester and make sure the actual wall socket is good. If there is no voltage reading, your ...
What to do if your socket is not reading voltage?
If there is no voltage reading, your socket is bad and either needs to be replaced or the circuit breaker needs to be reset. You can reset the circuit breaker by flipping all the switches in your breaker box. An electrician should replace the socket.
Where is the electric motor on a golf cart?
Located under a panel at the back of your golf cart will be the electric motor. The panel will be held in place by four or six screws. Use your screwdriver to remove these, turning them counterclockwise.
Where are the batteries in a car charger?
If you are getting power to the charger, it's time to check the batteries. Most batteries are located under the seat, which flips up for access. Grab a hold of the back of your seat and flip it up to expose the batteries. There will be a row of batteries. Each one of these need to be checked.
How to test a 12 volt battery?
So, with your flat-bladed screwdriver, insert it into the screw slot on a clamp and turn it counterclockwise. Do this to both clamps. Using your 12-volt battery tester, test the voltage of this battery by touching each side of it to one ...
What are the problems with electric golf carts?
With frequent use, problems with the battery, tires, and other parts are extremely common.
How to prevent battery malfunction in golf cart?
To reduce the risk of battery malfunctions, do general maintenance on a regular basis by making sure your batteries are properly watered and free of corrosion. The most obvious sign of an issue with the batteries is when your golf cart doesn’t start. The first thing to do in this case is to fully charge your battery.
Why is my golf cart not clicking?
When the solenoid isn’t working properly, you might stop hearing the clicking sound, and your cart might have intermittent issues starting. If your battery is working well and your car is having trouble starting, it might be time for a solenoid replacement. Properly maintaining your golf cart will help to ensure it’s in prime condition ...
What to do if your cart doesn't start?
The first thing to do in this case is to fully charge your battery. If after doing this, your cart still doesn’t start, then your battery is probably dead. Before changing the battery, take a look at the terminal cables to see if they’re the root cause of the problem by cleaning them and making sure they look alright.
What is a solenoid on a golf cart?
A solenoid is a cylindrical coil of wire responsible for carrying electric current to the motor. It’s not uncommon for this part to stop working because it has to work constantly when you use your golf cart.
How to fix a flat tire that won't inflate?
If a flat tire refuses to inflate due to a leak, replace it. Begin by raising your car with car jack. Then, unscrew the lug nuts, and remove the tire and wheel rim. Then, replace the old tire with a new one.
What happens if your golf cart doesn't accelerate?
Bad Solenoid. If your golf cart does not accelerate, there is a possibility of the damaged solenoid. The solenoid is basically an electrical switch that enables the battery's flow from the battery into the motor. Check out the signs of the bad solenoid.
Why is my golf cart not accelerating?
When your electric golf cart does not accelerate, the first thing you need to keep in mind is that it is not a regular vehicle like your car . That's why the methods and solutions you use to get your car to start are not the same as the solutions you can apply to your cart.
Why is my golf cart speed controller not working?
There are many reasons behind a speed controller malfunction. The most common problem that happens in the controller has aged due to infrequent use. These are just some of the issues that could be affecting your vehicle's acceleration. If you have trouble finding the issue of your golf cart accelerator, don't be afraid to take it to the mechanic.
How does a golf cart solenoid work?
The golf cart speed controller and solenoid are both controlled by the accelerator. The pedal is connected to the potentiometer. That means when you are pressing the pedal for acceleration, you are actually going through the potentiometer by pushing a rod. The potentiometer works as a communicator and tells the speed controller how much voltage it ...
What does a Yamaha cart run on?
Yamaha carts run on electricity generated by an acid-based rechargeable battery and most problems can be traced to this source. If your cart is sluggish or won't start, the battery may need to be charged. If it is charged, but still not working properly, make sure the battery terminal connections are clean and secure.
Why is my golf cart not clicking?
This insulated wire channels the electric current from the battery that powers the cart. If you press on the cart's accelerator and do not hear a clicking sound, the solenoid wires may need tightening.
Do Yamaha golf carts need maintenance?
Yamaha golf carts, like any other machine, will occasionally require troubleshooting and maintenance to ensure that they are functioning properly. Learning to troubleshoot your cart will help you recognize any potential problems before they become serious issues or safety hazards.