Increasing your golf cart batteries voltage is an excellent way to up your golf cart’s speed and power. This can be done on certain 36-volt models. Most of the time you can change the controller out and upgrade your batteries to 48 volts.
- Add More Torque to Your Golf Cart.
- Upgrade Your Golf Cart's Motor.
- Improve the High-Speed Controller of the Cart.
- Add Better Golf Cart Tires.
- Use a Higher Powered Golf Cart Battery.
- Watch the Weight in Your Golf Cart.
How do I increase the power of my electric golf cart?
Your electric golf cart has a few components that restrict the amount of power your motor receives, similar to the governor on a gas engine. By upgrading these two restrictors, you can increase the power going to the motor.
Will bigger golf cart tires make my golf cart go faster?
Bigger golf cart tires alone (20” to 24”), with no other upgrades such as a new motor, speed controller, etc., can add an extra 2-4 MPH of speed to your golf cart depending on the tire size. Some perks to upgrading tires to achieve more speed is:
Are electric golf carts faster than gas carts?
Electric motors are quite a bit different from gas motors. If your Club Car, E-Z-GO, or Yamaha golf cart is electric, then making your golf cart go faster will be a very different challenge. Electric motors use induction, and don’t use the same physics as a gas motor. They use electric power to create magnetic fields that spin a rod.
How fast do golf carts go?
Most new and used golf carts are made to go a top speed of around 15 miles per hour. Although that is the perfect speed for most folks, there is an equal amount (if not more) of folks out there who are looking to increase their golf cart top speed and go faster than 20 MPH let's say.
How do you remove the speed limiter on a electric golf cart?
Basically, an electric speed governor can be controlled by a tiny metal rod that's located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
How do I get more torque out of my 36 volt golf cart?
Change the Speed ControllerThe Speed Controller regulates the electric output of the motor; a higher voltage equals more RPM, and the faster your cart will travel. When you change the speed controller, you can reduce the voltage and increase the amperage of the motor, resulting in increased torque.
How can I make my electric golf cart go faster without upgrading?
How to Make an Electric Golf Cart Faster Without UpgradesWash Your Cart Properly. ... Inspect the Batteries. ... Refill the Battery Water. ... Check the Gas Pedal and Linkage. ... Measure the Tire Pressure. ... Charge Up Your Battery Unit. ... Lighten Up Your Cart's Weight.
Why is my 36 volt golf cart so slow?
Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
How do you bypass a speed sensor on a golf cart?
The speed sensor on the EZGO golf cart can be bypassed by unplugging it from the speed controller. By disconnecting the J5 pin on the speed controller, this will cause the golf cart to creep along as the controller will go into limp mode.
How can I make my golf cart governor faster?
3:415:06How to Adjust an E Z Go Golf Cart Governor - WikiVideo - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou can adjust the clutch to send more gas to your engine moving you faster. Find the small metalMoreYou can adjust the clutch to send more gas to your engine moving you faster. Find the small metal rod right next the clutch in the attached cable.
How fast does a 36V golf cart go?
between 12-14 mphHow fast is a 36 volt golf cart? Without any upgrades, you can plan on max speeds between 12-14 mph.
Can you convert a 36V golf cart to a 48V?
It all depends on your battery bank used with this 36V to 48V conversion. can only be accomplished through installing a 48V motor capable of higher torque, or installing a 48V controller with a higher current limit (amperage).
How do you take the governor off a golf cart?
0:000:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this leverMoreYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this lever you want to lift up and Bend and that pulls on the cable a little more.
How far can a 36v golf cart go?
A 36 volt golf cart is adequate for 2 to 4 passenger use when you are primarily using it on flat a flat surface. The average drive time or range for a 36 volt DC system is about 30 miles on a full charge.
Where is the speed sensor on electric golf cart?
Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.
Can a 36 volt golf cart go up hills?
A golf cart powered by a 36-volt motor would either move too slow or not at all when going up on a hill. It is recommended to use a 48-volt battery for optimum performance as it creates more low-end torque and faster acceleration.
Why your EZ GO Golf Cart Runs Slower than Normal?
When you’re EZ Go RXV or TXT golf cart starts running slow, it is usually because of a faulty speed sensor or battery issues. I have compiled a couple of these reasons below. They include the following:
How to Boost the Speed of Your Electric EZ Go Golf Cart
There are several methods for you to make your EZ Go electric golf cart go faster. I have detailed these methods in this section.
Conclusion
Having a faster golf cart can get you from point A to B a lot quicker. Whether you want to upgrade your cart from stock, or just fix the speed you have lost due to faulty batteries or add on parts, this is something that can easily be done.
How fast can a golf cart go?
If your objective is to make your cart road-worthy, changing the voltage of the battery is an effective way to achieve this. Most golf carts can attain speeds of up to 12 mph, which is perfect for leisurely rides around the golf course, but is too slow when traveling on neighborhood roads. Many communities require carts to travel at speeds of 20 mph, and the average cart with a 36-volt battery is unable to obtain that speed.
What is a golf cart?
Golf carts are an efficient and economical mode of transportation on the golf course and around neighborhood communities. While most older model carts use gasoline operated engines, newer carts are battery-operated, providing a quieter and eco-friendlier ride.
How does an electric golf cart work?
By upgrading these two restrictors, you can increase the power going to the motor . These devices are called the solenoid contactor relay and the electronic speed controller.
What is torque in golf carts?
Torque, or more accurately end torque in our use of the word, is the turning power of your wheels moving your golf cart. This torque is made by transferring the power from your engine to turning your wheels. The transmission, drive shaft, differential, and drive axles provide this transfer (or transmission ha!) of power.
How to speed up a golf cart?
One of the easiest ways to speed up your golf cart is by increasing the tire size. If you don’t do anything else, but buy bigger tires, then you can speed up your golf cart by 2-4 miles an hour.
What is the difference between an upgraded throttle body and an upgraded manifold?
These will allow for more air to pass into the opening of the motor. Upgraded throttle bodies may have more or bigger throttles to increase intake , while an upgraded manifold will have longer and more cylindrical tubes that allow for air to move faster to the combustion chamber.
Why is a longer tube better?
This may seem strange that a longer tube is better, but by being longer, it increases velocity of the air and has access to colder air which is more dense than warm air.
Can a golf cart transaxle be regeared?
The transaxle can be regeared or replaced to achieve a better gear ratio. This is similar to shifting gears on a bicycle. Most Yamaha, E-Z-GO, and Club Car golf carts have just a single gear transmission, and it’s best to keep it that way given the style of clutch most golf carts use. If your cart has a differential, then the same physics apply, ...
Can you convert a Yamaha golf cart to a 4x4?
Lastly, very few Yamaha, E-Z-GO, or Club Car golf carts come in 4 wheel drive, but there a lot of aftermarket manufacturers that sell kits for converting your cart into a 4X4. This increases torque, and also helps you maintain better traction, so less of that torque is wasted on tire slippage.
