Lowering the tire pressure on your golf cart tires, or even your automobile’s tires for that matter increases your traction. The reason for this is that you increase the amount of surface area of the tire that is in contact with the ground. More rubber on the road, or sand, in this case, causes an increase in traction.
Full Answer
How to make your golf cart faster?
Steps to make your Golf Cart Faster: 1 Alter the gear ratio 2 Use bigger tires 3 Increase overall RPM 4 Use a high powered battery 5 Use a speed chip or magnet
Can you change the drivetrain on a golf cart?
So this seems like it would be a little difficult, as most golf carts only have a direct connection from motor to transaxle to drive axle. However, even in this most limited form of a drivetrain, each of those pieces can be upgraded in some way or another. Another way to get better torque is to replace drive axles.
How to increase gear ratio in a gas powered golf cart?
If your cart has a differential, then the same physics apply, you can regear the differential to allow for a gear ratio that better suits you. When increasing power in your gas powered golf cart, it’s best to think of your gas motor as an air pump. The more efficiently it moves air, the more power it has.
How does torque work on a golf cart?
It’s supplied by the motor, and increasing it involves making your engine more efficient, which is different for gas vs electric golf carts. Torque, or more accurately end torque in our use of the word, is the turning power of your wheels moving your golf cart. This torque is made by transferring the power from your engine to turning your wheels.
How can I improve my golf cart performance?
6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.
How can I add more torque to my golf cart?
Change the Speed ControllerThe Speed Controller regulates the electric output of the motor; a higher voltage equals more RPM, and the faster your cart will travel. When you change the speed controller, you can reduce the voltage and increase the amperage of the motor, resulting in increased torque.
How can I make my golf cart climb hills better?
An older cart can be upgraded to perform better up hills. Adding larger 20"- 23" all terrain tires will help. 1) Tighten your terminal connections. 2) Clean any corrosion on battery terminals and cables.
How can I make my golf cart stand out?
It's all about revving up what is nondescript and making it one of a kind.Tires and Rims. If there's one way to make your golf cart stand out, it's with the tires and rims. ... Lift Kit. ... Paint or Wrap. ... Seat Cushions. ... Steering Wheel. ... Stereo Systems. ... Fans and Blowers. ... Headlights and Tail Lights.More items...•
Why is my electric golf cart so slow?
Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
How do you remove the speed limiter on a electric golf cart?
Basically, an electric speed governor can be controlled by a tiny metal rod that's located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
Why does my golf cart struggle up hills?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.
Why does golf cart lose power going uphill?
When your electric golf cart struggles on inclines, it means that you have to work harder to lift the front wheels. The cart's batteries interfere with its acceleration, and your speed decreases.
Why is my Club Car so slow?
The main reasons for a Club Car Precedent running slow is because of a weak battery, or faults with the MCOR, solenoid and throttle cable. Some of the other reasons the cart may slow down are: Solenoid contacts can get jammed as they wear out; experts call this 'welded solenoid'. The MCOR could be an issue.
Can you modify a golf cart?
Off road golf cart modifications can be used to offer improved performance and safety, or they can be modified for fun, like adding decals or more power. Knowing how to upgrade your golf cart, and exactly which modifications are right for you, is, of course, where a lot of golf cart owners get stuck.
How do you make a lift kit for a golf cart?
0:377:12Easy Home Made Golf Cart Lift. Club Car DS - YouTubeYouTubeStart of suggested clipEnd of suggested clipAll right so if you guys follow the channel at all you know that I had the golf cart wrapped. And IMoreAll right so if you guys follow the channel at all you know that I had the golf cart wrapped. And I put some wheels and tires on it and. Now. I can't drive it because the wheels and tires are taller.
What kind of Jack do you use on a golf cart?
A scissor-type floor jack is best to use when lifting a golf cart. The front and back wheels must be lifted evenly, so it stays balanced while being raised, which can be difficult with just one type of jacking device for each tyre at once.
How to speed up a golf cart?
One of the easiest ways to speed up your golf cart is by increasing the tire size. If you don’t do anything else, but buy bigger tires, then you can speed up your golf cart by 2-4 miles an hour.
How to get better torque on a golf cart?
Another way to get better torque is to replace drive axles. Each golf cart is different, but if your cart has jointed axles, meaning more than one piece to allow for movement of the suspension components, then you can upgrade to solid drive axles for a rear wheel driven cart or single joint axles for a front wheel drive.
How does an electric golf cart work?
By upgrading these two restrictors, you can increase the power going to the motor . These devices are called the solenoid contactor relay and the electronic speed controller.
How to increase intake?
The easiest way to increase intake is to buy a high-flow air filter like the ones from K&N. They can install directly on to your factory intake system and only cost about twice as much as a regular air filter.
What is the difference between an upgraded throttle body and an upgraded manifold?
These will allow for more air to pass into the opening of the motor. Upgraded throttle bodies may have more or bigger throttles to increase intake , while an upgraded manifold will have longer and more cylindrical tubes that allow for air to move faster to the combustion chamber.
What is power in golf carts?
Power is defined as the rate of work being done. It’s supplied by the motor, and increasing it involves making your engine more efficient, which is different for gas vs electric golf carts.
Why is a longer tube better?
This may seem strange that a longer tube is better, but by being longer, it increases velocity of the air and has access to colder air which is more dense than warm air.
How to make a golf cart go faster?
The best way to make your golf cart go faster is by upgrading to larger tires, increasing the RPM, or by using speed chips and magnets. Most golf carts today are used for not just the game alone, but also activities like farming, racing, camping, hunting and a lot more. These activities require the carts ...
How to adjust a gas golf cart?
There are two ways this can be achieved in a gas golf cart. The first option is to adjust the mechanical ground speed governor assembly. The second method is to replace the engine with one that has a higher rpm output.
What are Golf Cart Speed Chips?
As the name indicates, golf cart speed chips increase the speed of the cart. They help the cart to go at a speed faster than its pre-programmed speed limit set in the electronic system.
Does a Golf Cart Speed Magnet Really Work?
A golf cart speed sensor magnet increases the speed by up to 21mph on a 48V Precedent IQ and Club Car DS golf carts that use ADC motors without any loss of torque. With a slight reduction in torque, the speed can be increased further up to 28mph.
Why is my speed magnet not working on my golf cart?
One reason that the speed magnet may not be working on the golf cart is that it has been turned the wrong way. Another reason is that it could be functioning as a standard magnet . This can be confirmed by checking it with another magnet to determine the number of poles it has.
How fast does a club car DS go?
When the cart is programmed to Speed Code 4 setting, the motor of the golf cart will move at 19.6mph.
What is the speed chip on a 2000 golf cart?
The EZ-Go speed chip or freedom chip can be used with 2000 model golf carts or later with electric power drive systems. This helps to increase the speed of the cart from 13.5mph to 19mph.
Electric Golf Cart Power Options
So, how do you gain more electric golf cart power? When speaking about DC golf cart motors, you must first understand that voltage equals speed and amperage equals torque. If you want more speed, you increase the motor rpm. There are two ways to do that.
Motors
To gain more power from an electric golf cart, you could also utilize a different motor. Series wound DC torque motors have a much larger field coil inside allowing them to generate a larger magnetic field and hold the armature more securely producing greater torque.
Controllers
However, installing a torque motor alone may not always be the solution. You also have two major electrical components between the battery bank) and the motor. These components are the solenoid contactor relay and the electronic speed controller.
How to increase top speed of golf cart?
By increasing the tire and wheel size on your golf cart, the rotational output from your motor or engine will remain the same, however, you will have gained extra surface area on those rotations resulting from a top speed being increased from as little as 1 MPH to as much as 3 MPH.
How fast can a golf cart go?
Most Golf Carts are manufactured to go a max of 19.9 MPH with an average top speed of 14-15 MPH.
How many amps does a golf cart have?
For example, most golf carts approximately have a 300 Amp controller and performance controllers can be as high as 650 amps. That is like going from a 4 cylinder engine to a V8/V10. So be ready for an increase to your joyriding.
How to get faster in a car?
3. Replace the Motor/Engine. Replacing your motor or engine can help achieve higher speeds in most vehicles. Depending on the motor that is purchased, speed gains can range from 2 MPH to 7 MPH.
Can you reprogramme a golf cart controller?
Visit your local dealer for the manufacturer of your golf cart, and they will be able to assist in the possible reprogramming of the controller or modify the governor on a gas engine if they are permitted to do so. Be aware of the dealers that do not represent a manufacturer though as it can potentially lead to an illegal modification that would not be supported by a warranty.
Does a golf cart have a performance controller?
There are numerous performance-modified controllers to increase speed in vehicles. You need to be careful though as this will not only increase top speed, but also acceleration. Acceleration is great, however, keep in mind that you are driving a simple golf cart that was not intended for performance modification. For example, most golf carts approximately have a 300 Amp controller and performance controllers can be as high as 650 amps. That is like going from a 4 cylinder engine to a V8/V10. So be ready for an increase to your joyriding.
Why do we need steering input?
As we have explained in the past, if a car is tight in the middle of the turns, we must add steering input to help increase the front traction to compensate. Then as we pass mid-turn, the added steering generates more than enough front traction to overcome the tight condition and the car begins to get loose.
Why is the moment center important in dirt cars?
The improved technology related to the front end geometry and moment center has helped the dirt cars develop better grip in the front and we now see less rear steer, especially with the tighter conditions. This improves mid-turn speed and helps promote bite off the corners.
Why do you put shock on your tires?
Sticker "Shock" We have learned that traction can be better maintained if we can decrease the amount of torque that reaches the rear tire contact patches that comes from the initial application of power. Doing this helps the tires adjust to the transition of forces from lateral to longitudinal.
How does antisquat work?
Antisquat enhances rear traction in two ways, first by helping keep the rear of the car higher and with that the center of gravity. This promotes more load transfer. And second, by keeping the rear spoiler higher due to less squatting.
How does setup help a car?
The Setup Helps The way in which we set up the car can help us get more traction off the corners on flatter racetracks. One thing we did some years ago is to split the rates of the rear springs so that the left rear spring is a higher rate than the right rear spring. When we accelerate, we transfer weight to the rear of the car. As that weight is applied, the rear springs must compress to absorb the added weight. If the LR spring is stiffer, then it will compress less than the RR spring and this will increase the amount of the total sprung weight supported by the RF and LR tires. This produces an increase in the crossweight percent, usually making the car tighter off the turns while under acceleration.
What device transfers torque to itself?
We do this using devices such as a pullbar or a lift arm. These items momentarily transfer the torque to themselves instantly and effectively at the very moment the throttle is applied.
How much spring split is needed for a coilover?
On Asphalt Late Model cars, a 10- or 15-pound split (RR less than the LR) does what is needed. A 25-pound or greater split may be too much for a coilover car and cause an unbalanced setup that would be far too tight into and through the middle of the turns. For cars with big springs in the rear and a metric four-link suspension, a larger split is sometimes needed.
