It's probably a out of round or bad tire causing the shimmy. It could also be a bent wheel or axle. The easiest way to check would be jack the golf cart up and spin each tire and see if they spin true.
Full Answer
What to do if your EZGO golf cart has a wobbly front wheel?
You can try out the following steps on a 2006 gas EZGO golf cart that has a wobbly front wheel. Jack up the golf cart to lift the front wheels off the ground. Try shaking the tires from side to side and top to bottom. If you’re able to shake the tires both ways, it indicates that the wheel bearings need tightening.
How to fix a golf club car with bad ball joints?
Hold the front end of the club car and shake it for sometimes. If there is an issue with the front end, it means the sound occurs because of the bad ball joints. Remove the wheel and control the arm to replace the old ball joints with the new one. Make sure that the new ball joints should be properly lubricated.
How do you toe-in and toe-out a golf cart?
To toe-in, turn it towards the Club Car’s front end and toe-out, turn it towards the back end of the Club Car. After the tires are aligned correctly, lower the cart to the ground and double-check the symmetry.
What should I do if my golf cart won’t go up?
Check if the tires of the cart have too much pressure. If they have about 20 PSI pressure, you can try lowering it to 12 PSI in the front tires. The rear tires can have a pressure between 20 to 22 PSI each. Check the shocks to see if they show resistance to moving them by hand after unbolting them. If not, you must change them.
What causes a shimmy in the front end?
If you feel a slow shake, it's likely that your wheel was bent to the point it can't drive straight. If you feel a fast, vibrating shimmy, hitting the bump may have knocked your vehicle's weight off, and now a tire is out of balance. Either way, now your vehicle's parts are out of sync.
What would cause a golf cart to shake?
The common cause of golf cart vibrates when accelerating due to damaged inner CV joints, broken motor mounts, unbalanced tires or a bent driveshaft. To fix this issue, you should check the CV joints of your golf cart. Check the driveshaft, whether this is in good condition or not. The CV joints should be well greased.
How do I make my golf cart ride smoother?
How to Make a Golf Cart Ride SmootherCorrect Tire Pressure. ... Replace Worn Out Shocks and Struts. ... Check the Fluid and Filter. ... Replace the Clutch. ... Flat Spot in Tire. ... Tire Damaged or Out of Line. ... Worn Out Suspension Bushings. ... Check Your Lift/Tire Combo.More items...
How do you align a front end golf cart?
1:184:39Crash Course #11 How to Adjust Toe and Camber - YouTubeYouTubeStart of suggested clipEnd of suggested clipWe can drive in a straight line with our steering wheel straight as well. So after we've done thatMoreWe can drive in a straight line with our steering wheel straight as well. So after we've done that the next step is to measure the distance between the front of the tires.
What does the MCOR do on a golf cart?
Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for "Motor Controller Output Regulator".
Why does my golf cart jerk when I take off?
Your Club Car golf cart jerks when taking off, because of a faulty MCOR or low battery charge. Wiper arms that are adjusted incorrectly can also cause a golf cart to jerk. Faulty MCOR.
What makes a golf cart ride rough?
Your golf cart ride can be rough because of tire problems, suspension problems or issues with the transmission. Tire Problem: Incorrect air pressure and wrongly aligned tires are two key tire-related problems that can trigger rough golf cart rides.
How can I make my golf cart more stable?
Drop Spindle kits are used to replace and increase the golf cart spindle size and length. This can give your golf cart a wider stance, and increase the stability. The wider stance is perfect for those looking to fit those big off-set wheels on your cart, which in turn, can allow you to add wider and taller tires.
What PSI should my golf cart tires be at?
15 to 25 pounds per square inchThese tires typically use anywhere from 15 to 25 pounds per square inch (PSI), with the average being 20 to 22 PSI. For golf carts driven off-road or on rougher terrain, it's not uncommon to under-inflate tires to gain additional traction. However, under-inflated tires wear down prematurely.
How do you adjust the steering on a Club Car golf cart?
Turn the steering wheel to either side and lock it. Do this a few times and watch out for any play or slippage. Turn the wheel once again to any side slightly so that the rack moves out of the neutral position. Loosen the adjustment nut at the bottom of the cart with counter-clockwise turns using a large wrench.
How do you align Club Car in Front End DS?
0:123:08Club Car DS Front Alignment - YouTubeYouTubeStart of suggested clipEnd of suggested clipOut just a little bit in the front. And what we can do then is actually adjust the tie rod in theMoreOut just a little bit in the front. And what we can do then is actually adjust the tie rod in the back that connects and dictates the distance. Between the two tires. In the rear.
How do you adjust the steering on a EZ Go golf cart?
Rotate the middle adjustment clockwise to attach with the rack. Again, turn counter-clockwise by a 22.5 to 45-degree angle. Repeat this step to assess the binding. If the steering wheel is not binding well, then the issue could be with tie rods and may need replacement.
How to fix a Yamaha golf cart?
Steps to fix the issue: To fix the Yamaha golf cart G1, you should check the fuel pump and engine oil of the golf cart G1. Check the quality of your engine and replace it if you have used this for a long time. You should also check the batteries to whether it’s working or dead. Replace this if it needs replacement.
How to fix a golf cart tire?
To fix the issue, you should align the tires. Check the tire’s height, and both tires need to place in the same position. Remove the tires and clean them if there are any particles stuck in them. Check the engine of your golf cart, steerings, and solenoids. Install a new tire if it needs, and then go for a test driving.
Why does my Yamaha G16 shake?
Yamaha G16 golf cart shaking. Yamaha G16 golf cart shaking can occur due to bad solenoids, ignition, solenoid breakdown, and faulty batteries. To fix the issue, you should open your golf cart’s tires and engine to check whether it’s in good condition or not.
Why does my Ezgo RXV shake?
The golf cart Ezgo RXV shaking issues that occur in your golf cart may be due to worn steering parts, loose lug nuts, and loose wheel bearings. This may be due to brake drums and tires. To fix the issue, check the steerings of your golf cart. If it’s worn, then replace it with the worn steering parts.
Why does my golf cart jerk?
The golf cart may cause a jerk because of the solenoid issues. You need to check the voltage reading (normal range or not) of the solenoid. If the range is more or less than the normal range, then replace this.
Why does my Club Car DS shake?
The Club Car DS shakes while accelerating due to various reasons that include low & dead batteries, bad motor controller output regulator, and other issues. It’s usually because of a lousy adaptor and clutches.
Is the Ping G25 adjustable?
Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...
How to make a golf cart spin?
Use a crayon or chalk and draw a circle on one of the front tires in the middle of the thread as it’s spinning. Repeat the above step for the other front tire as well. Rest the golf cart on the ground and move it forward or backward by a few feet. Measure the distance between the lines on the front and back of the tires.
How to check if golf cart tire is bulging?
Jack up the golf cart in such a way that only a single end is lifted at a time with just enough ground clearance. Keep a spray can or any object with a straight edge at a distance of about 1/8 inches from the tire to check if it has bulges on the side.
How to run a golf cart?
Turn each wheel around and mark a line around the tire circumference in the middle of the tread pattern. Bring the vehicle to rest on the ground and ensure that the tires are positioned pointing straight ahead. Move the golf cart forward by about five feet so that the tires are in the usual running position.
Why does my EZGO RXV shake?
The front end of an EZGO RXV may shake or vibrate due to one or more reasons. You may have an improper toe-in adjustment or there may not be sufficient pressure in the tires. You can do the following if the front end shakes when an EZGO PCS cart moves at a relatively high speed.
How to check alignment on a cart?
Spin the front wheels using your hand. You can also check the alignment when they are in the air. Use a crayon or chalk and draw a circle on one of the front tires in the middle of the thread as it’s spinning.
Why do you need front end adjustments on a golf cart?
Front end adjustments for most golf carts are needed because of damaged parts like bent A-arms or bent or worn out tie rods as well as worn out bushings.
How to tighten tie rods?
To do this, you’ll have to turn the rods either counterclockwise or clockwise. If the rods feel snug, pour some penetrating oil on them. Tighten the nuts on either end of the tie rods and take a re-measurement to ensure that nothing has moved out of place. Grease the steering gear, spindles and ball joints.
How to reduce weight of golf cart?
Replace them with lighter springs so that they don’t drop much at the rear end. Using a lithium pack battery also helps to reduce the overall weight of the golf cart. Also, if the cart uses electric cart shocks, replace them with gas shocks.
How to make a golf cart ride smooth?
You can make your golf cart ride smooth by checking for the above-mentioned problems in the cart and attending to them. Correct tire pressure. Check if the front and back tires have the correct and even pressure according to specifications. They may need different pressures based on the conditions and seasons.
Why is my golf cart so rough?
Your golf cart ride can be rough because of tire problems, suspension problems or issues with the transmission. Tire Problem. Suspension Problem. Transmission Problem. Tire Problem: Incorrect air pressure and wrongly aligned tires are two key tire-related problems that can trigger rough golf cart rides.
How to get smoother ride on Yamaha G16?
You can get a smooth ride from your Yamaha G16 golf cart by ensuring the following. Ensure that there is no air leak in the gaskets between the intake and the carburetor as well as the spacer. You can pull out the airbox and check for a damaged gasket or spacer.
Why is my club car bumpy?
Club Car Precedent bumpy ride. You are likely to experience a bumpy ride in your Club Car Precedent because of the reasons given below. Heavy-duty leaves. Check if your golf cart is fitted with heavy-duty leaves. These are often known to cause bounce.
Why does my EZGO RXV ride rough?
Why an EZGO RXV rides rough. Your EZGO RXV often tends to ride rough because of the following reasons. Too much air in the tires. If the golf cart tires have too much air and uneven pressure, the rides may be rough. You can consider checking this out and releasing the excess air or pressure.
How to align club car front end?
The best way of aligning the Club Car front end is to first adjust the placement of the camber, followed by the alignment of the wheel and tire, by toeing them in or out as per required .
How to loosen lug nuts on club car?
You must do this on all of the bushings to make the process easier later on. Jack up the Club Car from the back. Use a ¾-inch socket to loosen the lug nuts on the back tire.
What to do if camber does not budge?
If the camber still does not budge, redo the procedure on both joints and keep adjusting the position as required. After the front end of the driver’s side is completed, redo the whole procedure for the front tire on the passenger side of the Club Car.
Why does my golf cart wobble?
If the front-end of your golf cart wobbles while driving, it could be due to faulty and/or non-branded tires, incorrect tire alignment or a faulty engine. Faulty and/or non-branded tires. Incorrect alignment of the tires. Faulty engine.
How to measure tire distance?
Measure the tire distance. Measure the distance from the center point of the tire on the driver’s side to that on the passenger’s side. This should be measured from the front and backside of the front tires. The distance should roughly be around 34-3/8 inches.
What causes a club car to crash?
Front Leaf Spring Bushings: Worn-out bushings in the front leaf spring can cause the Club Car to crash while in motion and could also cause camber and tire issues. Replacing all the above parts will fix the front end problems and also improve overall control, camber and tire of your Club Car.
How to fix a club car that is wobbling?
Steps to fix the wobble: Align the tires properly. Examine the height of the tires and ensure that the placement of both tires is even. Pull out the tires and clean them if there is any dirt jabbed in them. You must also consider inspecting the engine of your Club Car , along with the steering wheel.