The suspension in EZ Go can be greased manually by following these steps: Remove the cap on the front of the rear axle. Turn the wheel anti-clockwise until the cap is off. Remove the grease inside the cap. Pour the newly purchased synthetic water-resistant grease into the cap and replace it.
- Remove the cap on the front of the rear axle.
- Turn the wheel anti-clockwise until the cap is off.
- Remove the grease inside the cap.
- Pour the newly purchased synthetic water-resistant grease into the cap and replace it.
Where do I Send my EZ GO golf book?
E-Z-GO Division of Textron, Inc. P.O. Box 388 Augusta, Georgia 30903-0388 USA Inside USA Phone: 1-800-241-5855, FAX: 1-800-448-8124 Outside USA Phone: 010-1-706-798-4311, FAX: 010-1-706-771-4609 Title 28645G01OG_Golf_FRDM-FLT_Elec_2001+.book Created Date
Can I make changes to the design of my Textron golf cart?
TEXTRON Golf, Turf & Specialty Products reserves the right to make design changes without obligation to make these changes on units previously sold and the information contained in this manual is subject to change without notice.
What is the EZ GO design change policy?
E-Z-GO Division of TEXTRON, Inc. reserves the right to make design changes without obligation to make these changes on units previously sold and the infor- mation contained in this manual is subject to change without notice.
Where is the EZ GO office manual located?
Copyrighted Material This manual may not be reproduced in whole or in part without the express permission of E-Z-GO Division of Textron, Inc. Technical Communications Department E-Z-GO Division of Textron Inc., 1451 Marvin Griffin Road, Augusta, Georgia 30906 - 3852 USA Created Date
Where do you grease a golf cart?
0:111:03How to Check and Grease Your Golf Cart's Grease Fittings - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe pivot points on your steering.MoreThe pivot points on your steering.
How do you grease golf cart bearings?
1:135:50Golf cart front hub bearing install - YouTubeYouTubeStart of suggested clipEnd of suggested clipCar this is what we're doing so we've got to we've got to grease these bearings or big grease inMoreCar this is what we're doing so we've got to we've got to grease these bearings or big grease in them you just you can't put them in dry if you put them in dry.
How do I make my EZ Go TXT golf cart go faster?
Tighten the governor spring located in the engine of most golf carts to adjust your cart's top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly.
How can I speed up my EZ Go TXT gas?
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
Where are the grease fittings on EZ Go golf cart?
Grease is a type of lubricant that is used to reduce the friction between two surfaces of your EZ Go golf cart. It is often used in golf carts to keep them running smoothly and to prevent them from overheating. Grease fittings are located on the front and rear of the golf cart, near each wheel bearing.
How do you lubricate sealed bearings?
1:003:04How To: Grease a Sealed Bearing - YouTubeYouTubeStart of suggested clipEnd of suggested clipLike out of your grease gun or you can use a little bearing grease and pack it in there as hard asMoreLike out of your grease gun or you can use a little bearing grease and pack it in there as hard as you can we're going to take our seal all right. So we take pack this full of grease.
How fast is a EZGO TXT golf cart?
How Fast does a EZGO TXT Go? The 48B Electric EZGO TXT golf carts can achieve speeds of 14.5 to 19.5 MPH (23.3 to 31.4 KMPH.) The EZGO TXT gas models can go faster than the electric models, 19 MPH ± 0.5 MPH (31 ± 0.8 KMPH.)
How can I make my EZGO TXT 36 volt faster?
6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.
Why is my EZGO golf cart so slow?
A EZGO RXV and TXT golf cart can run slow because of a faulty speed sensor, low battery charge and insufficient levels of water in the battery. A problem with the speed sensor. A faulty speed magnet. One or more batteries could are weak and don't have sufficient charge or the water level could be low.
How do you adjust the governor on a EZGO TXT?
3:415:06How to Adjust an E Z Go Golf Cart Governor - WikiVideo - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou should see the cable lengthening slightly. This will make your cart faster tighten the nut toMoreYou should see the cable lengthening slightly. This will make your cart faster tighten the nut to make the cart move slower.
Why is my gas golf cart running slow?
Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
How can I make my electric golf cart go faster without upgrading?
How to Make an Electric Golf Cart Faster Without UpgradesWash Your Cart Properly. ... Inspect the Batteries. ... Refill the Battery Water. ... Check the Gas Pedal and Linkage. ... Measure the Tire Pressure. ... Charge Up Your Battery Unit. ... Lighten Up Your Cart's Weight.
Why do golf carts squeak?
The five most common reasons a golf cart squeaks include bad rubber bushings, front and rear spring failure, slipping belts, loose parts rubbing together, and problems with your wheels.
What maintenance is required for electric golf cart?
All the connections should be clean and tight. You shouldn't have any corrosion or dirt coating the connections within your golf cart batteries. If you do, create a solution using water and baking soda and clean them. It'll help you maintain proper connections within your batteries so that they charge correctly.
How do you change a wheel bearing on a golf cart?
5:0511:47How to replace a golf cart wheel axle bearing. Yamaha G29 - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd then your bearing will press off this way and then you press on the new one that way and this isMoreAnd then your bearing will press off this way and then you press on the new one that way and this is what it looks like. And that's it that's with the new bearing.
How do you change a wheel bearing on a Yamaha golf cart?
0:437:27How to replace Yamaha Electric Golf Cart Axle Bearings - YouTubeYouTubeStart of suggested clipEnd of suggested clipOther ways they grind out and fall apart. So I'm just going to show you real quick in a coupleMoreOther ways they grind out and fall apart. So I'm just going to show you real quick in a couple segments of this video how we do this job.