Increasing the speed of your EZ Go golf cart can be done by reprograming your speed control at the dealer, upgrading your batteries, motor, or replacing your speed control. Upgrading these can increase your typical speed from 12 MPH to 19.5 mph or above depending on your modifications.
Full Answer
How can I Make my EZGO golf cart faster?
Some tips to make your EZGO golf cart faster are: 1 Changing the solenoid and the controller 2 Upgrading the motor to an Admiral motor as this motor is known for its speed 3 Getting taller rear tires fitted in place of the existing ones
How do you make an EZGO TXT 48V go faster?
You can make an EZGO TXT 48V go faster by changing the RPM or the speed settings of the cart. Replacing old batteries, unlocking the speed settings or changing the controller will make your EZGO golf cart much faster. Batteries are one of the main components of the cart. Old or corroded batteries can lower the performance of a golf cart.
Do I need EZGO speed and torque upgrades?
So it's safe to say if you want more from your vehicle, you need the EZGO Speed and Torque Upgrades found at Buggies Unlimited. What can you expect from Buggies Unlimiteds selection of golf cart speed and toque enhancements?
How fast do golf carts go?
Most new and used golf carts are made to go a top speed of around 15 miles per hour. Although that is the perfect speed for most folks, there is an equal amount (if not more) of folks out there who are looking to increase their golf cart top speed and go faster than 20 MPH let's say.
How do I make my ezgo gas golf cart go faster?
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
How do I adjust the speed on my EZ Go golf cart?
0:237:10Simple Adjusting of an E Z Go Golf Cart Governor - YouTubeYouTubeStart of suggested clipEnd of suggested clipEngine. One Titan the governor spring located in the engine of most golf carts to adjust your cartsMoreEngine. One Titan the governor spring located in the engine of most golf carts to adjust your carts top speed.
How do you take the governor off a EZ Go golf cart?
General InstructionsDetach the cable from the carburetor. The cable is about the width of a straw. ... Follow the disconnected cable up to the governor. ... Disconnect the gas pedal cable from the governor and reroute it to the carburetor. ... Using your wrench, remove the bolt on the gas pedal shaft.
How do you turn off the speed limiter on a golf cart?
0:000:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo the farther you bend that normally the faster it goes and then that's it basically when you wantMoreSo the farther you bend that normally the faster it goes and then that's it basically when you want to return your heart you just bend that back down and go back to normal speed.
How do you make a golf cart go faster?
6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.
Why is my ezgo golf cart so slow?
A EZGO RXV and TXT golf cart can run slow because of a faulty speed sensor, low battery charge and insufficient levels of water in the battery. A problem with the speed sensor. A faulty speed magnet. One or more batteries could are weak and don't have sufficient charge or the water level could be low.
How do you adjust the governor on a Kawasaki engine?
5:317:43FH721V Kawasaki twin governor and throttle controls explained - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe same direction as full throttle. So you turn this one counterclockwise to set your governor.MoreThe same direction as full throttle. So you turn this one counterclockwise to set your governor.
What does removing the governor do?
Removing the governor will increase the maximum rpm of the engine, but the internal parts of the Predator 212 are designed for 3600 rpm. Generally, this isn't an issue with just the governor removal, the internal parts can usually withstand 5000 rpm without breaking apart (unless you go full throttle for too long).
How fast can a golf cart go without a governor?
What is the Average Golf Cart Speed? The average top speed of a typical golf cart without any upgrades is between 12 and 14 miles per hour. Without any sort of modification or upgrade on a golf cart, the top speed that you will be getting on a golf cart is about 14mph.
How do you bypass a speed sensor on a golf cart?
The speed sensor on the EZGO golf cart can be bypassed by unplugging it from the speed controller. By disconnecting the J5 pin on the speed controller, this will cause the golf cart to creep along as the controller will go into limp mode.
How do I speed up my EZGO TXT electric golf cart?
You can make your EZGO golf cart go much faster by adding more torque, upgrading the motor of or increasing the voltage of the batteries.Add more torque.Upgrade the motor.Increase the battery voltage.Decrease the load.
How do you change the governor on a golf cart?
If you find this rod, then your governor can be easily adjusted by accessing the cart's inner workings. Simply adjust the cable coming from this metal protrusion, turning the nut counterclockwise to make the cable longer, effectively adjusting the cart's governance to increase the overall speed.
How can I make my electric EZGO go faster?
0:1613:00How To Make Electric Golf Cart Faster | Plum Quick Bandit Speed UpgradeYouTubeStart of suggested clipEnd of suggested clipWe want to put this switch into tow mode. And also. I like to remove the positive battery cable toMoreWe want to put this switch into tow mode. And also. I like to remove the positive battery cable to the pack.
How do I speed up my EZGO 48v?
You can make your EZGO golf cart go much faster by adding more torque, upgrading the motor of or increasing the voltage of the batteries.Add more torque.Upgrade the motor.Increase the battery voltage.Decrease the load.
How do you slow down a golf cart?
Just adjust the throttle idle screw until the engine runs but the cart does not move. Turn it in to increase the idle speed, and turn it out to slow and eventually stop the engine.
How do I unlock Freedom mode on EZGO?
Toggle the forward/reverse switch from the "neutral" position to "reverse" five times in quick succession. After a few seconds, the computer controller will beep four times, indicating it has shifted into the freedom mode.
How to get more speed out of golf cart?
Upgrading tires and increasing your tire size is by far one of the most economical and easiest ways to get more speed out of your golf cart. Equally applied, this is a great solution for both gas and electric golf carts. If you install a tire with a larger diameter on your golf cart, the end result is a higher top speed.
How fast can a golf cart go?
Most new and used golf carts are made to go a top speed of around 15 miles per hour . Although that is the perfect speed for most folks, there is an equal amount (if not more) of folks out there who are looking to increase their golf cart top speed and go faster than 20 MPH let's say.
How does a new battery work on a golf cart?
Simply put, most types of golf carts are designed to work with a range of different batteries. A new battery will increase a golf cart’s motor output. The result of the motor output increase is higher speed. Purchasing new batteries with a higher voltage maximum will increase your golf cart’s speed dramatically.
Is there a catch all solution to increasing golf cart speed?
A golf-cart weighed down by unnecessary clutter and debris is not a happy golf-cart! In closing, something to keep in mind is: There is no "catch-all" solution to increasing golf cart speed / golf cart power. There are many factors to consider such as, how the parts, pieces and changes interact with your golf cart.
Can you install a torque motor in an electric golf cart?
Essentially, installing a torque motor or speed motor may not be the end solution. With that said, something that you will want to keep in mind as you are upgrading, are the two main/major electrical components within your electric golf cart, that play a huge role in your golf carts system:
Do you need a lift kit for a golf cart?
Note: Depending on the size of the tire and the make/model of your golf cart, some golf carts will require a lift kit to accommodate the size of the new tires. If you are unsure whether you need a lift kit for your golf cart before replacing them, we have an excellent Resource that discusses this topic in more depth.
Why your EZ GO Golf Cart Runs Slower than Normal?
When you’re EZ Go RXV or TXT golf cart starts running slow, it is usually because of a faulty speed sensor or battery issues. I have compiled a couple of these reasons below. They include the following:
How to Boost the Speed of Your Electric EZ Go Golf Cart
There are several methods for you to make your EZ Go electric golf cart go faster. I have detailed these methods in this section.
Conclusion
Having a faster golf cart can get you from point A to B a lot quicker. Whether you want to upgrade your cart from stock, or just fix the speed you have lost due to faulty batteries or add on parts, this is something that can easily be done.
How to adjust EZ Go cart governor?
To adjust an EZ Go Cart Governor engine, start by removing the seat so that you can access the engine. Once the seat is off, remove the screws from the black plastic cover at the rear of the seat and then set the cover aside.
How to raise the top speed of a golf cart?
To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly. If you cannot find this spring, you likely have a newer model that is more difficult to adjust, though this is rare. Lift up the seat. Remove the seat cousins, which hide the engine.
How to make a golf cart go faster?
Loosen the small nut and tighten the larger nut. The more you tighten the larger nut, the faster your cart will go. Start slowly, only tightening the nut a quarter turn to start. You can over-stress the engine if you try to run it too quickly, and it will skip and potentially burn out if you are too eager.
How to get a cart to move faster?
1. Remove the seat and plastic covering over the engine. Sometimes you'll need to remove screws while some models have seats that pop right out. Expose the engine so that you can get to work adjusting the motor. If you don't have a central governor spring, you can still get your cart to move a little faster.
How fast can a golf cart go?
Adjusting the governor can make your golf cart go 5–10 mph (8 .0–16.1 km/h) faster. If you do this to an E-Z-GO golf cart, you might be able to go from 15 mph (24 km/h) to 22 mph (35 km/h). It will only take about 5 minutes to do it. Steps.
How many screws are in a golf cart engine?
There should be five screws in most models. The engine is in the front of golf carts, underneath this panel. Take off the plastic cover and set it aside with the seats. ...
How to change the speed of a car?
Locate your clutch pedal and line. The clutch is the pedal (sometimes a handle near your knee) that you use to put the car into reverse or change speeds. You can adjust the clutch to send more gas to your engine, moving you faster. ...
