Can You charge a 48 volt battery in a golf cart?
Charging 48 Volt Golf Cart Batteries If you have a 48-volt golf battery cart, you ideally have six 8V golf cart batteries to make up for the 48 volts. You can charge the batteries using the charging tips mentioned above. Ensure that the charging takes place before the batteries are completely discharged.
How do you charge an electric golf cart with a generator?
Replace the engine of your electric golf cart with a gas engine that has a generator fitted on it. The generator can charge the batteries that supply the power to an electric motor responsible for moving the cart.
How do you recharge a golf cart battery?
How do I recharge my golf cart batteries? You will need to find an outlet to plug your golf cart’s charger into. Then attach the clips to the battery terminals. Once this is done, you should see some results within 15-20 minutes depending on how drained your battery is.
How do you jump a golf cart charger?
0:065:57Next we're going to take connect the jumper cable to the main negative of the bad card. And connectMoreNext we're going to take connect the jumper cable to the main negative of the bad card. And connect it to the main negative of the good cart. After our jumper cables are connected.
How do you jump a 48v golf cart?
0:115:45So let me turn this thing around and okay here we've got this this golf cart here that is completelyMoreSo let me turn this thing around and okay here we've got this this golf cart here that is completely dead 48 volt. And the charger when you plug it in will not come on because the batteries are too
How do you bypass the charger on a club car?
2:544:33We can cut it. Real close to the OBC. And then put a ring terminal. As. I think that's a 5/16 holeMoreWe can cut it. Real close to the OBC. And then put a ring terminal. As. I think that's a 5/16 hole in it so it goes right over this tournament either way we've got to get this wire.
How do you disconnect a battery charger?
Once the battery is charged you can turn off the charger, then unplug it from the wall. Next you will disconnect the cables in the opposite order in which you attached them. Negative (black) clamp first, the positive (red). Your battery should be all charged and you should be ready to go.
How do you jumpstart a 48 volt system?
Jump starting a car with a 48-volt system is not an issue....CONNECTING/DISCONNECTING THE CABLES CORRECTLY Connect a positive + (red) clamp to the positive + terminal of the dead battery, making sure the connection is solid. ... Connect the other end of that cable to the positive + (red) terminal of the working battery.More items...•
How do you trick a golf cart charger to charge a dead battery?
1:144:15Then when I did is hooked up hot - hot ground the ground on the dead battery. And what that did isMoreThen when I did is hooked up hot - hot ground the ground on the dead battery. And what that did is it that's a little bit trickle.
How do you bypass a golf cart controller?
1:594:09So let's just go ahead and bypass the solenoid by putting one alligator clip on that bolt.MoreSo let's just go ahead and bypass the solenoid by putting one alligator clip on that bolt.
How do I reset my club battery charger?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
How do you bypass the electric solenoid on a golf cart?
Bypassing Golf Cart Solenoid Method If you do decide to bypass the solenoid, this is what you need to do: Take the two larger wires that connect to the solenoid and connect them directly (keeping all safety precautions in place). This should do the trick and if it does not work then the solenoid is not the problem.
Do you put the positive or negative terminal on First?
“Positive first, then negative. When disconnecting the cables from the old battery, disconnect the negative first, then the positive. Connect the new battery in the reverse order, positive then negative.”
Which battery terminal do you connect first when jumping?
Safety First: Remember, when connecting the positive cables to the batteries, you should always start by connecting the dead battery first. If you feed energy into the cables before they are connected to your battery, you can cause a safety hazard.
Can you leave a battery charger connected?
Proper and regular use of battery chargers can therefore increase the reliability and the service life of the battery. Even though there is no risk of overcharging with the use of a high quality charger, the battery should not remain connected to the charger for more than 24 hours.
Find A New Golf Cart Battery Charger Or Batteries
1. All Golf Cart Chargers 2. Club Car Chargers 3. EZGO Chargers 4. Yamaha Chargers 5. Buyer's Guide - Picking the Best Golf Cart Charger. 6. Golf C...
Troubleshoot An Old Golf Cart Battery Charger & Batteries
1. Why is my golf cart battery charger not working? 2. I manually charged my batteries, that did not work, now what? 3. Do I have a battery or a ch...
Golf Cart Charger Questions
1. How do I choose a replacement charger for my Powerdrive, Powerwise, etc.? 2. What's the difference between the Links & Summit charger? 3. How lo...
Golf Cart Battery Questions
1. Do I have 6v, 8v or 12v golf cart batteries? 2. Do I have a 36 volt or 48 volt golf cart? 3. How long do golf cart batteries last? 4. How can I...
How to test a 48V golf cart charger?
First, you will need a voltmeter. Attach a voltmeter to the positive and negative clamps of your battery charger to calculate the amount of power it creates.
How many stages does a 48 volt golf cart charger take?
The current 48-volt battery charger theory employs microprocessor-controlled charging profiles in three stages, sometimes two or four stage s.
What is the voltage of a 48 volt battery charger?
The AGM/flooded 48 Volt charger’s absorption stage, roughly the remaining 20%, includes the charger keeping at the absorption voltage which is between 57.6 VDC and 58.8 VDC, depending on charger set points and progressively decreasing the current until the battery pack is fully charged.
Why does my battery charger hum?
If repairing the wires didn’t get your charger working again, you can turn it back on and listen for the battery charger’s humming. The presence of a humming sound suggests that the transformer is operational, but the absence of a hum indicates a serious problem that may necessitate transformer replacement.
Why is my golf cart battery charger not turning on?
If your charger isn’t turning on, make sure it has some charge by hooking it to a car battery and check the wiring as well .
What happens if your battery charger fails?
You can become stranded if your batteries run out. If your battery charger ever fails, you should be able to figure out what’s wrong and how to fix it. You won’t be able to fix every issue with a quick DIY fix, but a thorough diagnosis will save you hours of frustration.
How to retain battery power?
To retain battery power and service life, follow the battery manufacturer’s instructions for charging procedures and voltages, or use a high-quality microprocessor-controlled charger.
How to choose a golf cart battery charger?
How to Choose the Best golf Cart Battery Charger. You must choose a battery charger according to the voltage of your cart to prevent the possibility of damage to your batteries. Check the charging receptacle of your golf cart and select your charger accordingly.
How many volts does a golf cart charger have?
There are about 8 different types of charger plugs that you can find across various golf cart models. While some of plugs are exclusively for either 36 volts or 48 volts carts, others will work with both voltages.
How to charge a deep cycle golf cart battery?
The following tips give an insight into the effective charging of a deep-cycle battery. Charge the deep-cycle battery fully between two consecutive uses of the golf cart. The battery must complete at least one full cycle before use. Check the water level periodically.
How to turn off golf cart battery?
Turn the ignition key of the golf cart to the OFF position. Although there is no battery draw when the key is left on, doing this is considered to be a safe practice.
What is the power of a golf cart generator?
The generator can charge the batteries that supply the power to an electric motor responsible for moving the cart. The 48 volts system in a golf cart usually features an onboard computer (OBC) that controls the battery pack charging process and restricts the charging when the cart is moving.
How to keep golf cart from accumulating?
Keep the golf cart where there is good ventilation to prevent gases from accumulating during the charging process.
Why does my golf cart go into tow mode?
Your golf cart usually runs in tow mode when it does not have enough power to get moving on its own. One reason may be that the batteries are old and do not have the same power as new ones. If this happens with new batteries, the most likely reason is that they don’t have enough charge.
How to troubleshoot a golf cart battery charger?
If your batteries get too low, you could be stranded. To avoid this, you have to ensure that your battery charger is working correctly. If your battery charger ever fails, ...
Why is my golf cart not charging?
If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart’s onboard computer is confused about how much charge they are currently carrying.
Why does my charger fail?
If your batteries aren’t hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
What to do if battery charger fails?
You can’t address every problem with a simple DIY repair, but a sound diagnosis can save hours of frustration. In many cases, the solution is simple, and you’ll be able to handle it with minimal expense.
Why won't my battery turn on?
Make Sure the Batteries have Some Charge. In the scenario that it doesn’t turn on, it might mean you waited too long to recharge them, and now the charge that they currently carry is too low for the charger to detect them. When your charger can’t tell that your batteries are hooked up, it often won’t even turn on.
Do golf carts need batteries?
If you find that your golf cart won’t go very far on a full charge, then you probably need new batteries. Test them to make sure that the power on them is low; if indeed it is, then you need new batteries.
Can a club car monitor battery charge?
Only the club car can monitor the charge of your batteries, but it bears mention because these computers can fail, thus requiring a replacement. If the Club Car’s computer is working correctly, the relay should make a “click” sound when you plug in your charger. If it does not, then you could easily have a blown fuse.
What happens if the voltage is low on a charger?
Glad you got it going! Just a note though. If the incoming 110 volts to the charger is low, The efficiency of it's output is drastically effected. P=IxE, and so if E is low the charger tries to supply more I to produce it power to the battery back. This often happens with the use of long extension cords (or ones with to light of wiring) to supply the power to the charger. Just something you might want to take a look at. May not have anything to do with your situation, but just worth noting. I've had it happen myself. I was blaming the charger, and didn't realize that the incoming voltage to the charger was dropping down in the 90's. Another thing I would do, is ALWAYS start with a meter to determine the charge state of the battery pack first. You need to see what you are dealing with in there first. You can use the same meter (on AC instead of DC) to look at the 110 coming into the charger under it's load. Just a thought.
How long to charge a 12V battery?
The batteries are low you need to charge them with a 12 V charger 20-30 minutes each then try the charger again
Does EZGO golf cart have reed switch?
Your cart doesn't have a reed switch. EZGO uses them to prevent the golf cart from running while the battery charger is plugged in.
How many batteries does a golf cart have?
Because golf carts can have 6, 8, or 12 Volt batteries, you’ll want to pay attention to match that voltage on your charger if possible by setting it to the correct voltage or connecting it to the right number of batteries at a time to equal its voltage.
Why is my golf cart charger not turning on?
This is because golf cart chargers get commands to turn on and off by receiving voltage back from the cart when plugged in. So, if your batteries have been run down all the way or left without charging for a long while, your charger may not activate when plugged in.
Why does my charger spark?
If the charger is active or plugged in before connecting the batteries, it may cause sparks to occur. Charging of batteries can give off flammable gas… so we want to avoid causing arcing or sparks during this process. Ideally, your charger will match your batteries individual voltage and you can charge them one at a time, just like so.
What happens if your cart battery isn't hooked up?
If your cart's batteries aren’t hooked up in the correct way, or there's a weak connection between them, it can lead to a loss of power and cause your charger to fail.
Can you charge a battery one at a time?
Ideally, your charger will match your batteries individual voltage and you can charge them one at a time, just like so. There is no need to disconnect battery cables, you’ll simply be sending low amp voltage into one battery at a time. Some owners may have to do some math here.
Can you charge two golf cart batteries?
You can charge two of them using this method, because you’ll be doing it for a short period of time on each battery or pair. We’re not charging the batteries all the way here, we’re just trying to get enough voltage in them to get your normal golf cart charger to do it’s job. Remember to turn the charger off or disconnect it from power each time you move the charger to the next battery.
How to charge a 12 volt golf cart battery?
For these systems you can just use a 12 volt battery charger to charge each battery individually by placing the charger connections on the positive and negative terminals of each individual battery. You can again speed up the process if you happen to have that heavy duty battery charger with a 12v/24v adjustable output feature. ( Usually common on car lots and dealerships back in the day) Then you can charge up the bank even faster ( limited by charger output) place the charger connections on the positive terminal of the first battery and then the negative connection on that of the second battery that make up 24 volts. This will cut charge time down as you have less connections to make and depending on the charger output could decrease charge times. See Illustrations and images above.
How many volts does a golf cart battery need?
Others require a little less. So for example a 36 volt battery charger would require approx. 25-30 volts to activate, whereas a 48 volt charger would require 30-35 or even 40 volts present to activate.
How does a 12 volt battery charger work?
So being in a pinch a 12 volt battery charger will work to get some energy back into your dead golf cart batteries and revive them. The sole purpose here is to just get some energy back into the batteries so the golf cart battery charger itself can do the brunt of the charging and charge the batteries properly.
What type of battery is used in a golf cart?
Systems comprised of 6x 6 volt batteries… Usually found in older golf carts ( Pre-1990’s) across the board Club Car, Ezgo and Yamaha Brands but also Columbia, Harley Davidson ( Yep – Harley used to make a golf cart as they also made boats under AMF) other carts include Fairplay, Par Car or Western. For this system you will need either a 6 volt battery charger to charge individually by placing the charger connections on the positive and negative terminals of each individual battery. Or you can use a 12 volt battery charger and place the charger connections on the positive terminal of the first battery and then the negative connection on that of the second battery. This will cut charge time down as you have less connections to make and depending on the charger output could decrease charge times. See Illustrations and images above.
Why does my golf cart beep?
If you can get enough voltage and energy back into the batteries to make the golf cart move, beep or lights to work usually means there is enough voltage present at this point for the original golf cart battery charger to be plugged in and it will turn on to charge the batteries completely.
Why does my golf cart charger not know if it's plugged in?
So basically if the batteries in your golf cart are dead then the charger does not know it is plugged into a golf cart because it does not sense any voltage.
What does it mean when a golf cart battery is bad?
So being if the golf cart battery cable lug connector or connection between two batteries is bad the cart will usually not work, drive or charge. So check all the connections and cables for signs of corrosion or wear or completely broken off battery.
