With a charging device, golfers will have a unit that will circumvent the golf cart’s computer in order to charge the battery. In fact, the device may provide longer lasting batteries. While jump-starting the battery, players should locate the positive battery terminal and then connect the red clamp.
Full Answer
How does the OBC work on a golf cart battery charger?
When you plug the charger into your Club Car, the OBC will tell the battery charger when to start and stop charging based on the voltage levels in your batteries. As a result, golf cart battery chargers for 48 volt Club Cars need a working OBC to get them to start charging.
Why is my Yamaha golf cart not charging?
The most likely reasons why a Yamaha golf cart is not charging are: The battery charger is damaged
What voltage do I need to charge my Yamaha golf cart?
A minimum of 25-30 volts is required to wake up the charger and for it to begin charging your Yamaha Golf Cart. A failure in the “brain” of the charger can also cause the charger to take very long to start charging or to recharge fully.
How do I charge my golf cart battery?
When you plug in your charger to your cart it will fully charge the batteries. Once fully charged, the charger goes into its "storage mode" feature so long as it is connected to the golf cart and the wall.
How do you jumpstart a golf cart charger?
0:065:56How to jump a dead ezgo - YouTubeYouTubeStart of suggested clipEnd of suggested clipNext we're going to take connect the jumper cable to the main negative of the bad card. And connectMoreNext we're going to take connect the jumper cable to the main negative of the bad card. And connect it to the main negative of the good cart. After our jumper cables are connected.
How do you bypass a club car on your computer?
2:544:33How to Bypass On Board Computer | Club Car Precedent Golf Cart | OBCYouTubeStart of suggested clipEnd of suggested clipWe can cut it. Real close to the OBC. And then put a ring terminal. As. I think that's a 5/16 holeMoreWe can cut it. Real close to the OBC. And then put a ring terminal. As. I think that's a 5/16 hole in it so it goes right over this tournament either way we've got to get this wire.
How do you force a golf cart battery to charge?
Drive the golf car for an extended period of time so the batteries will discharge, plug the golf car charger in again and repeat this cycle for about 3 or 4 times. Each time will increase the battery charge and golf car run time.
How do you check a golf cart charging system?
Turn on the Charger – Once you have the voltmeter attached to your battery charger, turn on the charger to read the electrical output. Typically, the needle on the voltmeter will move from left to right – with right being higher – to gauge the amps produced. A reading of about 36 amps is typical for a battery charger.
How do I reset my club battery charger?
How to reset your Club Car's OBC after a faultKey Switch to Off.Forward/Reverse to Neutral.Tow/Run Switch to Tow.Disconnect the Battery NEGATIVE (–) wire from the Battery Minus terminal on the battery pack.Put the Tow/Run to Run.Forward/Reverse Switch to Reverse.Key Switch to On.Lock the throttle pedal down.
Can you bypass a micro switch on a golf cart?
You can bypass the reed switch in an EZGO golf cart by connecting the red wire of the reed switch to the white wire from the charger receptacles and to the red wire from the FRN micro switch.
How do you trick a golf cart charger to charge a dead battery?
1:233:46Reviving Dead 6v & 8v Golf Cart Batteries FAQ - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since thisMoreSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since this is this negative we make this battery six volt I jump to the corresponding.
What do you do if your golf cart won't charge?
Golf Cart Won't ChargeCheck our outlet to make sure that you're getting power to your electrical outlet.Check the water level in your batteries, using distilled water to refill only. ... Check for corrosion or any loose cables on the batteries.Check the condition of your charger's cables (AC and DC cables).More items...
What would cause a golf cart not to charge?
If your batteries aren't hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
Why is my gas golf cart not charging the battery?
Why Your Golf Cart Starter Generator is Not Charging. If your starter generator is not charging properly, it may be that the solenoid, voltage regulator or brushes are faulty. If you've ensured that all of these parts are working fine, the starter generator may not be drawing enough current to regenerate the battery.
How do you test a voltage regulator on a Yamaha golf cart?
Testing the voltage regulator on a gas Yamaha golf cartRemove the drive belt from the golf cart. ... As mentioned above, connect the voltmeter to the battery and check the voltage reading. ... Release the pedal and check if the reading is 12.5 volts or just above this value.More items...
How do I reset my electric golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do you bypass a golf cart controller?
1:594:09electric golf cart, simple Motor and controller bypass key hotwire direct ...YouTubeStart of suggested clipEnd of suggested clipSo let's just go ahead and bypass the solenoid by putting one alligator clip on that bolt.MoreSo let's just go ahead and bypass the solenoid by putting one alligator clip on that bolt.
What does Club Car onboard computer do?
Club Car uses an On Board Computer (or OBC) to monitor and control various functions of their carts. It functions as a Go/No Go control for the charging and drive systems. If the OBC detects a problem in either the charging or drive system, it will shut that feature off.
Where is the reset button on a Club Car golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
How do you remove the speed limiter on a electric golf cart?
Basically, an electric speed governor can be controlled by a tiny metal rod that's located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
How to start a golf cart with a battery?
First attach the red clamp to the positive of the battery. Next attach the black clamp to the negative. Now attempt to start the golf cart motor. If it starts, leave the emergency jump start kit attached for at least 30 minutes. If it does not turn over, wait about 5 minutes before you attempt that start again.
Why does my golf cart not turn over?
When this happens, the ignition wires can become unseated and the golf cart motor simply will not turn over. Before wasting your time jumping it, always look for the ignition wires as the cause.
How to clean corrosion off golf cart?
If you find corrosion on the wires, you can wipe it off with a towel. Make sure you use your gloves. Seat the ignition wires and tighten their connections. If the golf cart still does not work, you should check the battery.
Can you use a golf cart as a car?
You may also use a golf cart as a leisure vehicle . Many towns in South Carolina, Florida, North Carolina and other southern states have a profitable and lucrative golf cart market. The weather is usually decent enough and the terrain flat enough that owning a golf cart is more economical than a regular car.
Can you use a golf cart as a leisure vehicle?
Playing 18 holes of golf on a warm day is a great way to relax, but that relaxing outing can be marred by a golf cart motor that will not start. If you're a golfer, you know that a dead golf cart on the back nine is no fun. You may also use a golf cart as a leisure vehicle.
Can you jump a golf cart?
With all of the wires seated correctly and corrosion removed, you can now jump the golf cart motor. The emergency jump start kit has a self-contained battery, so you do not need another golf cart or vehicle to be present. You can later charge these batteries for subsequent use. First attach the red clamp to the positive of the battery.
How to troubleshoot a 2008 Yamaha golf cart controller?
You can troubleshoot the 2008 Yamaha golf cart controller using the following steps: Press the accelerator and check whether the voltage increases up to the full voltage of the battery. If it does not increase, then there is a problem with the controller or the batteries. Examine the batteries and check if they are dead.
Why has my Yamaha golf cart controller just died?
The controller on a Yamaha golf cart can die when the battery voltage is too high , or because of loose wiring in the charger.
How do I test my Yamaha g16 speed controller?
To test the Yamaha g16’s speed controller, check the voltage reading while pressing the accelerator. Test other components such as the batteries, the charger, and the solenoid for their smooth functioning.
What causes a golf cart speed controller to fail?
A faulty solenoid can cause major problems for a golf cart speed controller. Yamaha G22 also faces similar problems like G9 and G16.
What are the problems with a G16 golf cart speed controller?
The most common problems with a G16 golf cart speed controller is overheating and voltage issues.
Why is my Yamaha YDRE speed controller not working?
Generally, defective batteries and the motor are major causes of all the problems of a speed controller on a Yamaha YDRE.
Why is my Yamaha controller hot?
The primary reason why a Yamaha golf cart controller gets too hot is because of overuse. When the golf cart is used for long periods of time, the controller can start overheating.
How to maximize battery life on golf car?
To maximize the battery's lifespan and optimize its performance, charge the golf car before each use and perform battery maintenance as listed in the owner's manual.
Where is the plug in for a golf car?
Plug the male end of the DC outlet cord into the receptor on the golf car, located on the outside of the containment wall below the seat cushion. Allow the battery to charge.
How to charge a battery in a garage?
Place the battery charger on a solid, level surface that is fireproof, such as a concrete garage floor, and in a well-ventilated area. Plug the charger into a grounded, three-prong electrical outlet. Attach the DC outlet cord to the charger.
Why does my battery charger automatically turn off?
The battery charger will automatically turn itself off when the charge is complete to avoid overcharging.
How many holes does a Yamaha golf car have?
for use on golf courses or for personal short-range transportation. Each battery charge should allow the car's use for 36 holes of golf, or approximately eight hours of driving time.
Where to put female plug in charger?
Insert the grounded female plug into the slot on the back of the charger, or attach the positive and negative connectors to their respective color-coded nodes on the back of the charger, depending on the charger model you have. Remove the faceplate covering the DC receptacle, if there is one.
Can you disconnect a car charger while charging?
Do not disconnect the DC outlet cord from the battery receptacle while the charger is on. This may create a charged arc that could cause an explosion. Unplug the charger first if you need to disconnect the car before it is fully charged.
How many volts does a Yamaha golf cart need to charge?
A minimum of 25-30 volts is required to wake up the charger and for it to begin charging your Yamaha Golf Cart. A failure in the “brain” of the charger can also cause the charger to take very long to start charging or to recharge fully. This can be solved by an easy replacement and doesn’t even require many bucks.
Why is my Yamaha Golf Cart Not Charging?
Your golf cart will not start charging if your charger won’t turn on. And this happens if you don’t recharge the battery for a long time. So, the current charge that they’re carrying right now might be just too low for the charger to detect.
Why is my Yamaha battery decoloring?
In case of decoloration and if it has lost its charge, then most probably the batteries have become damaged. This can be caused due to the use of the wrong charger. Make sure to use the original Yamaha charger with the label of 48 volts.
How many volts does a battery charger need?
The charger has a requirement of a minimum volt that allows it to recharge the battery. As mentioned earlier, the minimum volt must be around 25-30 Volts for the charger to recharge the battery.
Why doesn't my G1 golf cart charge?
Often, the G1 golf cart doesn’t charge because of a bad receptacle. Make sure that the receptacles fit tightly and are clean. If not, then you can get the receptacles cleaned and tightened.
Why won't my charger charge?
When you plug in the charger, and it just won’t start charging, or nothing happens, most plausibly, the problem is with the batteries or their connection.
Why is there a problem with battery connection?
The first reason that causes hindrance in connection is corrosion. It should be prevented at all costs for the normal functioning of the batteries. Clean the battery terminals in case it corrodes.
What is an OBC golf cart?
All Club Car golf carts newer than 1995 have an OBC or ” On Board Computer ” in the charge circuit to monitor and control several functions on the golf cart. The tutorial below explains a little about the OBC, how to reset it after charging problems, and what to do if its completely failed.
What happens if OBC detects a problem in charging or drive system?
If the OBC detects a problem in either the charging or drive system, it will shut that feature off.
Can OBC reset fix a club car?
There is always a chance the OBC has completely failed and the reset process will not fix the problem. Consult your Club Car manuals or call your local dealer.
Where is my User’s Manual for my golf cart battery charger?
Our manufacturer does not provide owner’s manuals. Here are the links to the Lester charger manuals (they are also linked to on our product pages):
How long does it take to charge a golf cart?
It depends on three factors, 1) the quality of your batteries, 2) how discharged your batteries are and 3) the quality of your charger. If you have 5 year old batteries that are very discharged and you have a lightweight 2-5 amp charger, it may take a very long time (10 hours or more). If you have brand new batteries, they are 20-30% discharged and you've got a heavy-duty charger, it can be pretty quick (1-3 hours). Again, it depends on all of the above factors, so it really could vary quite a bit.
How Do I Troubleshoot My Golf Cart Battery Charger if It Isn't Working?
Just so you know, this situation happens EVERYDAY. The first question we always ask is, how long has it been since you've charged your batteries? We ask this because often times if it has been a while (a couple weeks or more), or if you just got brand new batteries, or if your batteries have been really run down recently, it is possible that the batteries may not have enough voltage in them for the charger to start working. An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
What are some symptoms of a bad golf cart battery charger vs. bad batteries?
Bad Batteries: IN GENERAL, if the charger doesn't kick on or show any signs of life when you plug it into your cart, this is most likely a battery/connection issue. Learn more about the signs of a bad golf cart battery.
Will the golf cart charger automatically stop charging once the batteries are fully charged?
Yes. All automatic chargers are designed to charge your batteries until they are fully charged and then stop charging. So you do not need to manually shut off the charger or worry about overcharging your batteries. All Lester chargers are made with a number of internal safety mechanisms that ensure that they will never overcharge batteries.
What if I charge my batteries until my battery charger stops charging, but my golf cart won’t drive very far?
You probably need to test your batteries and likely will need to get new golf cart batteries.
Should I charge the golf cart after each use?
Yes. It is healthy for the batteries to be fully charged at all times. So, you should charge your golf cart every night. Automatic golf cart chargers will shut off once the batteries are fully charged, so there isn't a concern that they will be over charged.
