Club Cart golf carts need the rear axle / rear end oil changed periodically. Here is how you do it. 1: Take your golf cart out for a spin for about 15 minutes to warm up the oil for faster draining. 2: Park your golf cart on a level surface. Put an oil pan under the cart’s rearend.
Full Answer
How to change oil in a club car golf cart?
Follow these steps to change the oil in your club car golf cart. The first step is to get the protection gear ready. Use work gloves, safety glasses and take safety precautions to avoid any injuries. The best time to change the oil is when the engine is still warm. The next step is to part your golf cart on a plane level.
How much oil does it take to fill a golf cart?
It fills with almost a full quart of oil. It is necessary to change the oil because the oil darkens and becomes dirty, causing harm to the golf cart. You first need to park your club car on a flat-leveled surface for a rear-end oil change.
How to tune up a club car golf cart?
I began to look up steps on how to tune up a Club Car golf cart. 1. Air 2. Fuel 3. Spark These are the basics for any gas-powered engine. These points can be checked BEFORE spending any cash on parts. Begin by raising the seat upon its hinges and lifting the cushion out of the hinge brackets.
How do club car golf carts work?
Club car golf carts are equipped with two kinds of engines. It is either equipped with an electric engine or a gasoline engine. A club car which is powered by a gasoline engine should be checked frequently and be handled just like any regular car. The oil should also be changed at proper intervals.
How do you lubricate a Club Car golf cart?
0:572:10Club Car Golf Carts - Lubrication Schedule - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou're going to want to actually feet see how the grease comes out of there fitting. Watch when IMoreYou're going to want to actually feet see how the grease comes out of there fitting. Watch when I push this see how it comes out you want to be able to see grease coming out of the fitting.
How often should you grease a golf cart?
EZ Go golf cart should be greased at least once every three months. This will help to keep it in good working condition.
What kind of oil do I use in my club car golf cart?
A Club Car golf cart uses 15w-50 or 10w-40 oil. Synthetic oil can also be used for a golf cart. Synthetic oils are good for heat, but can be difficult to handle.
Are there grease fittings on a golf cart?
The front end of your car will have "Zerk" or "Grease Fittings", that allow you to apply grease via a grease gun into the high wear points on the golf cart.
How do you grease golf cart wheels?
1:2318:47How to Repack Your Wheel Bearings Pt. 2 - YouTubeYouTubeStart of suggested clipEnd of suggested clipTake a dollop of Greece. You put that grease in the palm of your hand like that I'm right-handed I'mMoreTake a dollop of Greece. You put that grease in the palm of your hand like that I'm right-handed I'm going to use my right hand to pull the bearing in my left hand to have the grease in it.
Why do golf carts squeak?
The five most common reasons a golf cart squeaks include bad rubber bushings, front and rear spring failure, slipping belts, loose parts rubbing together, and problems with your wheels.
What kind of oil does a 4 stroke golf cart take?
All viable models of EZGO golf carts typically run on 10W-30 and 10W-40 engine oils. These oils have proven to be the best for these vehicles for a long time. The need to change the engine oil in an EZGO golf cart arises in every 125 hours of using the vehicle.
Do golf carts have oil filters?
If you're new to Yamaha golf carts, you may be wondering “Do Yamaha Golf Carts Have Oil Filters?” The simple answer is no, most Yamaha golf carts do not have oil filters included in their engines.
How do you drain oil from a golf cart?
0:184:01How to Change The Oil In a Golf Cart | Golf Cars Unlimited - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo that you can reach the plug you're gonna simply put on a 19 millimeter socket to loosen the drainMoreSo that you can reach the plug you're gonna simply put on a 19 millimeter socket to loosen the drain plug. And we're going to drain the engine oil from the back. Okay when you remove the oil filter.
How do you maintain a golf cart?
Start by consulting the owner's manual for your cart for any specific maintenance or safety precautions, and then follow these eight tips for golf cart upkeep:Charge Your Batteries. ... Fill Battery Cells, But Not Too Much. ... Clean The Batteries. ... Keep The Tires Filled. ... Check The Brakes. ... Keep An Eye Out For Oil Leaks.More items...
How do I maintain my EZ Go golf cart?
Perform regular maintenance on EZ Go golf cars to keep them in prime condition. For electric models, this includes making sure the tires are properly inflated and cleaning the battery terminals often. For gas golf cars, check the oil every week and, if it's low, fill with 10W-30 oil.
When to change oil on a golf cart?
The best time to change the oil is when the engine is still warm. The next step is to part your golf cart on a plane level. Turn the engine on and let it warm up for a while and then turn it off. Apply the brakes after you have turned off the engine.
How to park a golf cart?
You first need to park your golf cart on a flat surface. Turn the engine of the golf cart off. Remove the oil cap located that is usually on the top of the engine.It is of a round shape. Place the oil cap in a safe place. Remove the dipstick that is located on the driver’s side.
How to remove oil filter from a cart?
Secure your cart with a block of wood or a floor jack. While the oil drains, remove the oil filter. Make sure to place the pan in front of the oil filter and the drain hole. Put the plug back to its place and place it firmly after the oil drains out completely. Now, take the new oil filter and put it on tightly.
How often should a golf cart starter be checked?
The engine of a gasoline-powered golf cart must be checked on a monthly level. After the first hundred hours of use of the golf cart, the filter and the engine oil must be changed.
What kind of engine does a golf cart have?
Club car golf carts are equipped with two kinds of engines. It is either equipped with an electric engine or a gasoline engine. A club car which is powered by a gasoline engine should be checked frequently and be handled just like any regular car. The oil should also be changed at proper intervals.
How to change oil in a car?
You can change the oil easily by placing a funnel in the engine cap hole. Add the oil by passing it through the funnel into the engine. After you have added the oil, remove the funnel and put the cap back on properly. Start the engine and run it for about a minute.
How to get an O ring out of an engine?
While doing so, make sure that the o-ring remains in its place. Put the oil filter in a drip pan and let the oil drain out from the engine completely . Get a new oil filter for your engine and make sure that an o-ring is attached to the top of it.
What is a golf cart?
Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... link to Club Car DS Wiring Diagrams 1981 To 2002.
Where is the air filter on a 1996 DS Club Car?
On the 1992 – 1996 model DS Club Car with the FE290 Kawasaki engine, this is located on the driver’s side of the opening, and it is a black plastic box with two thumbscrews at the back. Turn each of these 90 degrees to unlatch and the back swings out.
What color should a spark plug be?
Use a spark plug socket and ratchet to remove the spark plug and inspect the ceramic insulator. This should be light brown to brown and not oily or wet. If it is black in color, you might be running too rich of a fuel mixture, requiring an adjustment to the air screw (we will cover this later).
How to set air mix and throttle screw?
To set the air mix and Throttle screw, we need to use the Torx T15 and remove 2 screws holding the cover that hides the adjustments. After removing the screws, pick up the right edge of the cover and pivot it over and off.
What to do if your air filter is too oily?
If the filter is not too oily but just dusty, use compressed air to blow the dirt out of it. If you can’t get enough of the contaminant out of the fibers, you will need to replace it.
How to start a car when it's cold?
Start It Up. After you have all of the safety measures in place, reach in and press the accelerator with your hand and the engine will begin to turn over. If the engine is still cold, you may need to use your other hand and press the choke button until it fires off.
Can you start a motor without the cart taking off?
When the microswitch is engaged in the “pressed” position, and the lever is in the “Neutral” position, you can start the engine without the cart taking off. It would be safest to chock the wheels to prevent an accidental runaway should you bump the lever while running the engine.
How to reduce noise in golf cart?
You can reduce the noise in a Club Car considerably by opting for an engine with lower HP, insulating or lining the engine compartment, opting for mufflers or addressing mechanical problems like loose screws.
Why does my gas golf cart make a squealing noise?
The gas golf cart tends to make a squealing noise due to a loose or worn out starter/generator belt, a loose drive and/or alternator belt or a dusty clutch. Loose or worn out starter/generator belt. Loose drive and/or alternator belt. Dusty clutch.
Why does my 2001 Club Car DS make a grinding noise?
The grinding noise in a 2001 Club Car DS is because of worn out brakes, a bad wheel bearing, low transaxle oil level in the rear end or a worn out input shaft bearing.
Why does my club car DS make a clunk?
The front-end clunking noise in a Club Car DS is due to worn out bushings under the spring and spindle, loose nuts on the spindle, a damaged rubber bumper or a cracked front leaf spring plate.
Why does my Club Car DS make a popping noise when turning the steering wheel?
The Club Car DS makes a popping noise when turning the steering wheel due to loose components in the front suspension, a cracked upper clevis, a worn out steering, missing bushings or lack of grease.
Why does my club car make a rattling noise?
The rattling noise in a Club Car DS is often because of a worn out clutch, loose bolts, a rod knock, a loose top light, a dirty guide ring or a windshield problem.
WEAR APPROPRIATE GEAR
Wear disposable gloves or other protective garments when cleaning or disinfecting cars.
PREPARE YOUR DISINFECTANT
Diluted household bleach, alcohol or household disinfectant solutions are effective for killing the coronavirus.
WIPE DOWN SURFACES
Disinfect all seats, steering wheels, door handles, keys, seat belts, gear shifts, air vents, mirrors, connectivity units, hand rails or bed door handles.
CLEAN VISIBLE DIRT
Clean any visible dirt from any part of the car that a person usually touches with hot soapy water.
USE CAUTION
Read the instructions of cleaners and disinfectants carefully. Mixing products such as bleach and vinegar, bleach and ammonia, bleach and alcohol, or hydrogen peroxide and vinegar can create deadly substances like mustard gas, chloroform or WIPE DOWN corrosive acid.
KEEP HAND SANITIZER CLOSE
Keep hand sanitizer that is at least 60% alcohol based available at consumer applications like golf courses.