how to make a 36 volt golf cart faster

How to Make a 36 Volt Golf Cart Faster

• Step 1. Remove any unnecessary additions, racks or parts on your golf cart. Club racks, roofs, windshields, decorations...
• Step 2. Power-wash your cart. Use a hose and soap to scrub all of the dirt and grime off your cart that is slowing it...
• Step 3. Check the shaft under the ignition pedal. Be sure that there is not a crank...

Full Answer

How can I make my golf cart faster?

How to Make a 36 Volt Golf Cart Faster Remove any unnecessary additions, racks or parts on your golf cart. Power-wash your cart. Check the shaft under the ignition pedal. Put larger tires on the cart. Replace any old or worn-out parts that are causing the cart to move slower than it should.

What is the fastest voltage for a golf cart?

Feb 02, 2022 · How to Make a 36 Volt Golf Cart Faster Remove any unnecessary additions, racks or parts on your golf cart. Power-wash your cart. Check the shaft under the ignition pedal. Put larger tires on the cart. Replace any old or worn-out parts that are causing the cart to move slower than it should. How fast can a 36V golf cart go?

Will bigger golf cart tires make my golf cart go faster?

Increasing your golf cart batteries voltage is an excellent way to up your golf cart's speed and power. This can be done on certain 36-volt models. Most of the time you can change the controller out and upgrade your batteries to 48 volts. This will make your golf cart have comparable speeds with a newer higher voltage cart.

Do new batteries make a golf cart go faster?

Mar 04, 2022 · The following six strategies will allow you to make your golf cart faster: Add more power to the engine. Upgrade the motor. Ensure that the high-speed controller of the golf cart is improved. You can purchase better tires for your golf cart too. A high powered golf cart battery allows you to function in a higher degree.

How fast does a 36 volt golf cart go?

12MPHStandard 36V and 48V golf carts are capable of the same top-end speed (12MPH). You can, however, make your golf cart go faster by doing a couple of things: Larger Tires - You can purchase larger tires. The larger the diameter of the wheels, the faster your golf cart will go.

Can you make a 36V golf cart to 48V?

Yes, but effective and simple. However, although it is possible to upgrade these vehicles to electronic speed control at either the 36V or 48V level, I would not recommend it due to the cost associated with the conversion. You can buy a modern 48V cart for far less money than the 36v to 48v conversion.Nov 30, 2011

How do you remove the speed limiter on a electric golf cart?

0:000:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt looks up look inside. There's 12 cable down right here this lever you want to lift up and BendMoreIt looks up look inside. There's 12 cable down right here this lever you want to lift up and Bend and that pulls on the cable a little more.

Why is my 36 volt golf cart so slow?

Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.Jul 14, 2021

Can you put 3 12v batteries in a 36V golf cart?

If you have a 36-volt golf cart that runs on six 6-volt batteries, you can replace them with three 12-volt batteries, which often are easier to find.

What happens if you put 48V to a 36V motor?

Your 36V controller might not work with a 48V battery. It might be programmed to fault out and quit when voltage exceeds a preset level. Low voltage cutoff will be set for a 36V battery, not 48V, so it will not protect your 48V battery.Aug 12, 2015

Can you make an electric golf cart go faster?

Another word of advice: shift your gear ratio from 12.5:1 to 6:1 to make it go 12 miles per hour faster than it did before! But there's a catch: you have to give up some torque in order to increase the speed of your golf cart.Aug 29, 2019

How do you take the governor off a electric golf cart?

0:101:28Golf Tips & Etiquette : Where Is a Golf Cart Governor Located? - YouTubeYouTubeStart of suggested clipEnd of suggested clipWell a golf carts governor located is actually down in the motor compartment some of them there'sMoreWell a golf carts governor located is actually down in the motor compartment some of them there's electric ones nowadays.

How do you bypass the governor on a EZ Go golf cart?

General InstructionsDetach the cable from the carburetor. The cable is about the width of a straw. ... Follow the disconnected cable up to the governor. ... Disconnect the gas pedal cable from the governor and reroute it to the carburetor. ... Using your wrench, remove the bolt on the gas pedal shaft.

Can a 36 volt golf cart go up hills?

A golf cart powered by a 36-volt motor would either move too slow or not at all when going up on a hill. It is recommended to use a 48-volt battery for optimum performance as it creates more low-end torque and faster acceleration.

How do I increase the torque on my electric golf cart?

3:2217:29How To Add More Torque To Your Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipThis right here motor is going to add around 70 percent more torque over your stock motor. And youMoreThis right here motor is going to add around 70 percent more torque over your stock motor. And you must upgrade the controller as well. So also flat terrain and a good quality battery pack for these

What causes an electric golf cart to run slow?

Perhaps the most common reason that a golf cart slows down is when it doesn't have enough power output from your battery. Often, this occurs if the battery pack charge is too low and your cart is out of power. However, if your cart is fully charged and has no problems there, the voltage output may be to blame here.

How To Make Your Golf Cart Go Faster (Top 6 Ways) - Golf ..

There are many many ways to make your golf cart faster and increase your torque and overall power. First and foremost, let's take a few steps back and look at defining some of the basic electrical concepts and terms which are very important to adequately understand and grasp regarding your electric golf carts power. More ›

Runs slow in forward 98 ez go golf cart 36 volt, 98, I had ..

Runs slow in forward 98 ez go golf cart 36 volt, 98, I had to change forward/reverse switch, batteries are - Answered by a verified Electric Vehicle Mechanic. We use cookies to give you the best possible experience on our website. More ›

Golf Cart Speed Controllers: A Beginners Guide - GolfCarts.org

If your golf cart is going to be used for transporting 2 people or light loads on flat ground, and smooth roads, a small 200-300 AMP controller with a 2-5 horsepower motor should adequately perform. You'll find that most vehicles in this category run with 24 to 36 Volt battery packs. More ›

This may be the fastest golf cart on the planet, and it ..

However, a company is making custom golf carts that go way faster than your normal golf cart. Lacern Golf Cars makes custom-built golf carts that go up to 55 mph. This one, shown below, goes 50 mph. More ›

Fix Golf Cart Noises (Whining, Grinds, Beeps, Clicks ..

Golf Cart Making Whining Noise. Golf carts can sometimes make some very weird noises. While these noises may not be particularly dangerous, they can be irritating and possible a sign of damage. If you want your golf cart to last you for many years to come, you'll want to investigate and fix such noises. More ›

Faster in reverse than in forward - Golf Carts Forum

Tweet. #2. April 10, 2013, 03:27 PM. Being a 1984 it is probably a resistor cart. Electrically the only thing I can think of it going faster in reverse than forward is the F/R switch being bad. It could be done. The motor has to spin in the same direction to go forward regardless of polarity of wiring. So I would find out why its faster in ...

CLUB CAR CONTROLLERS AND TROUBLESHOOTING - Golf Cart Parts ..

This controller is very common in the 36 Volt Club Cars. ... 300-600 Amp controller is highly recommended and commonly used in both 36 V and 48 V Club Cars. ... if a golf cart is left for no use for a longer period, then capacitors used in the golf cart controller tends to dry up which leads to a malfunction of the controller internally. More ›

How to get more speed out of golf cart?

Upgrading tires and increasing your tire size is by far one of the most economical and easiest ways to get more speed out of your golf cart. Equally applied, this is a great solution for both gas and electric golf carts. If you install a tire with a larger diameter on your golf cart, the end result is a higher top speed.

How fast can a golf cart go?

Most new and used golf carts are made to go a top speed of around 15 miles per hour . Although that is the perfect speed for most folks, there is an equal amount (if not more) of folks out there who are looking to increase their golf cart top speed and go faster than 20 MPH let's say.

How does a new battery work on a golf cart?

Simply put, most types of golf carts are designed to work with a range of different batteries. A new battery will increase a golf cart’s motor output. The result of the motor output increase is higher speed. Purchasing new batteries with a higher voltage maximum will increase your golf cart’s speed dramatically.

What is a series wound DC motor?

Series Wound DC Torque Motors are made with a larger field coil inside. A larger field coil inside of the motor , allows a larger magnetic field generation and holds the armature much more securely, thus producing greater torque. This is an excellent option if you're looking for more torque in your Club Car, EZGO or Yamaha golf cart, but are not so concerned about the speed.

What is torque in motors?

You know what 'speed' is, of course, but what is torque? Torque is the pulling power of the motor and is a function of current. So, basically, the higher the current, the more torque.

Do you need a lift kit for a golf cart?

Note: Depending on the size of the tire and the make/model of your golf cart, some golf carts will require a lift kit to accommodate the size of the new tires. If you are unsure whether you need a lift kit for your golf cart before replacing them, we have an excellent Resource that discusses this topic in more depth.

Is there a catch all solution to increasing golf cart speed?

A golf-cart weighed down by unnecessary clutter and debris is not a happy golf-cart! In closing, something to keep in mind is: There is no "catch-all" solution to increasing golf cart speed / golf cart power. There are many factors to consider such as, how the parts, pieces and changes interact with your golf cart.