how to make a 36v golf cart run longer

You can make the 36V EZGO go faster by removing and replacing worn-out parts, replacing the tires and removing additional weight from the cart. Cleaning the engine can also increase the speed of the cart. Replace worn-out parts

Full Answer

How do I know if my golf cart is 36 or 48?

Look on the battery for the voltage then multiply that by how many batteries you have and you will know whether your golf cart is 36 or 48 volts. For example, if you have 4 batteries and they are 12 volt… 4×12=48.

How to make a golf cart faster?

6 Ways You Can Make a Golf Cart Faster 1 Add More Torque to Your Golf Cart 2 Upgrade Your Golf Cart's Motor 3 Improve the High-Speed Controller of the Cart 4 Add Better Golf Cart Tires 5 Use a Higher Powered Golf Cart Battery 6 Watch the Weight in Your Golf Cart

How to make your golf cart batteries last longer?

Moreover, the battery for a cart does not recharge itself as the vehicle runs like batteries in cars do (cars have alternators). Therefore, regular use will drain the battery which, in turn, may shorten its life. That being said… Here are 6 Tips to Making Your Golf Cart Batteries Last Longer. 1. Always Use Distilled Water

How many 12V batteries in a 36 V golf cart?

One of the ways to do that is to change up the batteries. You can use three 12V batteries in a 36 V golf cart, but you may find this has a negative effect on the cart’s performance and the battery life. However, this will significantly depend on the batteries you opt to install and whether they have the same power as the existing 6V configuration.

What is the average run time for a 36V golf cart?

The average drive time or range for a 36 volt DC system is about 30 miles on a full charge.

How long should a 36 volt golf cart last on full charge?

Typically, an electric golf cart has between 45 and 90 minutes of full-power run time on a fully charged battery.

How do you remove the speed limiter on a electric golf cart?

Basically, an electric speed governor can be controlled by a tiny metal rod that's located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.

How do I upgrade from 36V to 48V?

It all depends on your battery bank used with this 36V to 48V conversion. can only be accomplished through installing a 48V motor capable of higher torque, or installing a 48V controller with a higher current limit (amperage). When DC power is discussed, amperage equals torque and voltage equals speed.

Should you leave a golf cart plugged in all the time?

Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.

Should I charge my golf cart every night?

Should you charge new golf cart batteries? Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.

Can you make a 36 volt golf cart faster?

A new battery will increase a golf cart's motor output. The result of the motor output increase is higher speed. Purchasing new batteries with a higher voltage maximum will increase your golf cart's speed dramatically. We highly recommend Golf Cart Batteries, if you plan to replace.

How can I make my electric golf cart go faster without upgrading?

How to Make an Electric Golf Cart Faster Without UpgradesWash Your Cart Properly. ... Inspect the Batteries. ... Refill the Battery Water. ... Check the Gas Pedal and Linkage. ... Measure the Tire Pressure. ... Charge Up Your Battery Unit. ... Lighten Up Your Cart's Weight.

How do you turn off the governor on a electric golf cart?

0:061:28Golf Tips & Etiquette : Where Is a Golf Cart Governor Located? - YouTubeYouTubeStart of suggested clipEnd of suggested clipWell a golf cart's governor located is actually down in the motor. Compartment.MoreWell a golf cart's governor located is actually down in the motor. Compartment.

What happens if you put 48V to a 36V motor?

It won't hurt it to try it. All the will happen is that the controller will shut down earlier if the cut off voltage is set for the 48v which might be right at 42v which would be peak on the 36v.

What is better 36 volt or 48 volt golf cart?

Basically, a 48V system gives you more “pep in your step” and picks up/speeds up a bit faster than a 36V system. Energy Needed/Amps Drawn- A 48V system draws less amps and provides a little more range with all things being equal (cart/passenger payload weight, motor horsepower, etc).

Can a 36V controller handle 48V?

Re: Will a 36 volt controller handle a 48 volt battery? Probably already stated and answered but a 36v controller will work on a 48v battery, its just the controller wont kick in for lvc.

Why your EZ GO Golf Cart Runs Slower than Normal?

When you’re EZ Go RXV or TXT golf cart starts running slow, it is usually because of a faulty speed sensor or battery issues. I have compiled a couple of these reasons below. They include the following:

How to Boost the Speed of Your Electric EZ Go Golf Cart

There are several methods for you to make your EZ Go electric golf cart go faster. I have detailed these methods in this section.

Conclusion

Having a faster golf cart can get you from point A to B a lot quicker. Whether you want to upgrade your cart from stock, or just fix the speed you have lost due to faulty batteries or add on parts, this is something that can easily be done.

How to speed up a golf cart?

One of the easiest ways to speed up your golf cart is by increasing the tire size. If you don’t do anything else, but buy bigger tires, then you can speed up your golf cart by 2-4 miles an hour.

How does an electric golf cart work?

By upgrading these two restrictors, you can increase the power going to the motor . These devices are called the solenoid contactor relay and the electronic speed controller.

What is torque in golf carts?

Torque, or more accurately end torque in our use of the word, is the turning power of your wheels moving your golf cart. This torque is made by transferring the power from your engine to turning your wheels. The transmission, drive shaft, differential, and drive axles provide this transfer (or transmission ha!) of power.

What is the difference between an upgraded throttle body and an upgraded manifold?

These will allow for more air to pass into the opening of the motor. Upgraded throttle bodies may have more or bigger throttles to increase intake , while an upgraded manifold will have longer and more cylindrical tubes that allow for air to move faster to the combustion chamber.

Why is a longer tube better?

This may seem strange that a longer tube is better, but by being longer, it increases velocity of the air and has access to colder air which is more dense than warm air.

Can you convert a Yamaha golf cart to a 4x4?

Lastly, very few Yamaha, E-Z-GO, or Club Car golf carts come in 4 wheel drive, but there a lot of aftermarket manufacturers that sell kits for converting your cart into a 4X4. This increases torque, and also helps you maintain better traction, so less of that torque is wasted on tire slippage.

Can you upgrade a golf cart to a single joint axle?

Each golf cart is different, but if your cart has jointed axles, meaning more than one piece to allow for movement of the suspension components , then you can upgrade to solid drive axles for a rear wheel driven cart or single joint axles for a front wheel drive.

How to make an EZGO golf cart go faster?

You can make your EZGO golf cart go much faster by adding more torque, upgrading the motor of or increasing the voltage of the batteries. Add more torque. Upgrade the motor. Increase the battery voltage. Decrease the load.

How to clean a golf cart?

Perform a power wash for the golf cart. Scrub the cart thoroughly to remove dirt and grime. Grime accumulated over a span of time can make your cart go slowly. Check for grime and small stones under the pedal and wash them off. Remove the stones using a screwdriver or a pair of pliers.

Why does my EZGO cart slow down?

Any engine that has been used for a long time will definitely slow down due to the dust and grime build-up on it. Cleaning the engine of your EZGO cart will help you regain the lost speed. This is a cost-effective and efficient method of boosting speed.

How to increase torque on EZGO golf cart?

Increasing the torque of your EZGO golf cart will automatically increase its speed. To increase the torque, you will have to increase the RPM of the motor. You can do this in 2 ways. Increase the voltage of your motor to get more RPM. Replace the motor with one which has a higher RPM.

How to make a 36V EZGO go faster?

You can make the 36V EZGO go faster by removing and replacing worn-out parts, replacing the tires and removing additional weight from the cart. Cleaning the engine can also increase the speed of the cart.

What happens when a cart is overloaded?

Every cart is designed to carry a certain load of weight. When the cart is overloaded, it will move at a slower pace. Try to keep the cart light and without much weight. This will definitely enhance the speed.

What are the main components of a golf cart?

Batteries are one of the main components of the cart. Old or corroded batteries can lower the performance of a golf cart. Hence it’s important to maintain them in the right condition.

1. Speed Sensor Issues

The speed sensor is an essential and critical part of golf cart operation that helps to ensure that cart runs smoothly and efficiently. It operates by measuring how fast you are driving and how much electricity is needed to maintain that speed. When the speed sensor ends up running into trouble, chances are your cart may end up running slowly.

2. Low Battery

Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.

4. Bearing Encoder Issues

The bearing encoder is an essential part of your golf cart that provides you with careful electrical charge distribution throughout your cart. It works by encoding various elements of your cart's operation and translating them to different impulses to keep the power running smoothly.

5 Ampacity Controller Fault

The Ampacity controller is a part of your cart that helps to manage the amperage that produces and uses as your cart drives. When this particular part malfunctions, you're going to run into some issues with your cart operation.

How to Increase your golf cart speed?

Are you looking to increase your golf cart speed? Learn more about how to make your golf cart go faster.

How long do golf cart batteries last?

Cheaper batteries have much shorter life spans compared to quality golf cart batteries that cost more. The latter may last up to 10 years if maintained properly. So, you end up gaining in the long run even if your initial investment is high. Also, be on the lookout for tax cuts from time to time.

How to prevent a golf cart battery from corroding?

In order to prevent this, coat its wire lugs, terminals, nuts, and bolts with any quality non-hardening sealant.

What type of battery does a golf cart use?

Most golf carts run on lead-acid batteries ( although this is changing ), much like other normal vehicles do. However, the difference is that a battery for a golf cart is usually of 6, 8, or 12 volt deep-cycle lead acid battery, whereas a normal vehicle uses a 12-volt starter or ignition battery. Moreover, the battery for a cart does not recharge ...

How to maintain a battery?

1. Always Use Distilled Water. Battery maintenance is best done in a well-ventilated area on a plain and level surface. After removing the battery cells’ plastic caps, top off each cell’s reservoirs with distilled water. Never use plain or tap water. Also, never allow the cell’s fluid level to dip below its plates.

Does a cart battery recharge itself?

Moreover, the battery for a cart does not recharge itself as the vehicle runs like batteries in cars do (cars have alternators). Therefore, regular use will drain the battery which, in turn, may shorten its life. That being said….

Do golf cart batteries work?

Though vehicular batteries are made similarly and out of similar materials, when used in golf carts, the way they are used is different. The maintenance of golf batteries will be somewhat similar to maintaining other batteries. However a couple of things are different. Follow the above mentioned tips to keep your golf cart batteries, in turn your golf cart, in prime working condition.