How to Repair Golf Cart Batteries
- Place safety first by wearing safety glasses and gloves when working with lead acid batteries. The acid is very corrosive and can cause serious chemical burns.
- Disconnect the battery cables using a crescent wrench and remove the battery from the golf cart. ...
- Mix a solution of 4 oz. of Epsom salts in a pint of distilled water and stir until the Epsom salts are dissolved (if you heat the water ...
- Use a three-phase battery charger to recharge the battery. ...
- Turn the charger off when the golf cart battery is completely charged. Disconnect the charger leads and replace the cell caps.
How to revive golf cart batteries?
Here are the steps to follow : Step 1: The battery should be removed. Step 2: Start with cleaning the battery. Step 3: Now, use the same brush to wash it with fresh water and brush it all around the battery. Step 4: The process to revive golf cart batteries advances with the inspection of the battery for any cracks or any defects.
How do I know if my golf cart battery needs replacing?
Check the battery after it has charged for several hours or the next day. If the battery still hasn’t taken a full charge, they cannot be saved and it is time for some new golf cart batteries . If the battery has taken a charge, replace the cell caps and use your golf cart for a long ride and see how long the charge lasts.
Can you recharge a golf cart battery with Epsom salt?
Some cart batteries are not too far gone and can be rejuvenated using Epsom salts. Note: Electric Golf carts will have 6,8, or 12-volt batteries. These are the steps to attempt a repair and refurbish golf cart batteries:
Is it bad for a golf cart battery to go dead?
As letting the batteries go completely dead is very bad for the batteries and will definitely cut the life expectancy short. In the golf cart business we use a golf cart battery recovery unit like BatteryPete’s Super Charger to jump start the golf cart in seconds or minutes to get the customers golf cart battery charger to kick on…
How do you bring a golf cart battery back to life?
Step 1: Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. ... Step 2: Mix 8 ounces of Epsom salts into 2 quarts of warm distilled water: Stir thoroughly. ... Step 3: Put the battery or batteries on a charger.
How can I make my golf cart batteries better?
Here are 6 Tips to Making Your Golf Cart Batteries Last Longer.Always Use Distilled Water. Battery maintenance is best done in a well-ventilated area on a plain and level surface. ... Use a Proper Battery Charger. ... Trickle Charge the Battery. ... Prevent Corrosion. ... Pay More to Last More. ... Use Anti-Corrosion Lubricants. ... Final Note.
Does Epsom salt help golf cart batteries?
Mix 4 ounces of Epsom salts into a quart of warm distilled water and stir. Using a turkey baster fill each battery cell slightly over the lead plates. Do this for a cycle of 4 charges so the Epsom Salts remove the deposits on the battery plates.
Can you rebuild a golf cart battery?
Can you refurbish Golf cart batteries? Yes, it is reasonably possible to recondition your golf cart batteries. But, there will be a condition for that. If the battery is not fully dead and you can charge it up to a certain extent, it will be possible to refurbish it.
Does aspirin help golf cart batteries?
Be warned that adding aspirin will shorten the battery life, as the aspirin will react with the sulfuric acid to form acetic acid. Good for a boost, but bad for the innards of the battery.
How often should I add water to my golf cart batteries?
DO: You have to get your timing right. After charging your battery is when you want to add water. Adding water after charging prevents acid from spilling over. ... We recommend service once or twice a year. Always use distilled water so you don't add additional minerals into your battery.
Can you put vinegar in a car battery?
The chemical components inside the battery will react with the vinegar and cause severe harm to the battery. The battery might even fail to work when the vinegar is added; thus, you should be keen not to damage the battery with your own hands. However, vinegar is useful in cleaning corrosion on alkaline batteries.
Does Desulfating a battery work?
If you own a battery desulfator, you can lengthen its lifespan and enjoy even more miles on the road. Plug your car battery into a desulfator and you'll enhance its effectiveness even as it ages.
Can you Desulfate a golf cart battery?
When you want to desulfate your golf cart battery, there are just a handful of different tools that you'll need for this process. Thankfully, most people should be able to handle this process with little difficulty, as long as you understand how to open up your battery and handle a few simple tools.
How do you revive a battery that won't charge?
First, you need to light a fire and let it burn down to hot ashes. Then remove the filler/vent caps from the top of the battery, take the battery off the car, and place it on the hot ash. Be careful and make you it doesn't catch fire. The hot ashes should warm the battery up.
How do you recondition a battery with Epsom salt?
Replace battery cell solution – Mix 4 cups of water with 4 ounces of Epsom salt. Stir until the water is clear. Boiled water speeds up the process but isn't necessary. With the funnel, refill the cells with the new electrolyte solution.
What is Epsom salt in battery?
These salts may reduce the internal resistance to give a sulfated battery a few extra months of life. Suitable additives are magnesium sulfate (Epsom salt), caustic soda and EDTA (EDTA is a crystalline acid used in industry). When using Epsom salt, follow these easy steps to treat most starter batteries.
How to know if there is any problem with the charger or battery?
Frequently, it is the battery that is the problem and seldom with the charger. To know if the charger is not working, you can test it with another...
Can my charger still charge my golf cart cells if their voltage is low?
For automatic chargers intended for golf cart cells, it cannot charge if the battery is completely dead. If you have 36 volts for your golf cart b...
What is the estimated life of golf cart batteries?
On average, if there are proper maintenance and usage, the cells can last between 4 to 6 years.
Can you refurbish Golf cart batteries?
Yes, it is reasonably possible to recondition your golf cart batteries. But, there will be a condition for that. If the battery is not fully dead...
What kind of batteries go in a golf cart?
There is a lot of confusion about golf cart batteries. There are three types of lead-acid batteries: flooded, gel and AGM. Golf carts use flooded o...
How does low temperature affect golf cart batteries?
A low temperature can slow down the charge and discharge rate of any golf cart cells. Likewise, it decreases its charging capacity.
What do you need to recondition a golf cart battery?
Golf cart batteries are lead-acid types, so you need to wear your safety gear before doing the reconditioning process. The safety gear you need are goggles, rubber gloves, and apron.
Why can't you dispose of golf cart batteries?
You cannot readily dispose of these kinds of waste because it contains chemicals detrimental to the environment.
How many volts does a golf cart battery need to charge?
For automatic chargers intended for golf cart cells, it cannot charge if the battery is completely dead. If you have 36 volts for your golf cart battery set, then it must have at least 20V to 25V, for your automatic charger to recharge it back. For a 48-volt golf cart battery set, it must retain 30V to 35V for your automatic charger to recharge it.
How to know if a battery charger is not working?
To know if the charger is not working, you can test it with another cell. To examine if each cell has the right voltage capacity, use a voltmeter. Charge your battery to full capacity before reading its voltage with a voltmeter.
How many volts does a golf cart have?
In that case, you probably own a personal golf cart. It usually has 4, 6, or 8 6-volt lead -acid batteries – a lower capacity but similar cell to the ones used in standard lead-acid car batteries. There will come a time that your golf cart batteries will die out or reduce its charge capacity. Replacing all those 4 to 8 power packs would cost you ...
Can you refill a golf cart if it is not charging?
Check for the water level of your golf cart cells. If it is not at full level, do not refill unless you are done charging it to 100 percent full capacity. Filling the water at a full level before charging can cause spillage during the charging process. Work in a well-ventilated area for the reconditioning.
Simple Steps in Reviving Old Golf Cart Batteries
If you want to get some use out of your old golf cart, there are steps that you can take to revive your old battery and make it functional again.
What is the life span of a golf cart battery?
The average life span of a golf cart battery is four to five years. It is best to get new batteries when they die. But if you're not keen on spending money, Epsom salt is a cheap and effective alternative for powering your cart around the block that you can try before replacing them with new ones.
The battery works extremely slow after charging it overnight, will the Epsom solution work? Epsom salt help?
Saltwater can be a good solution to fix your battery, but if you have tried this and it did not work, then it is time to replace your batteries.
How do I know if my golf cart batteries are healthy?
One definite way is by undergoing a load test which can be done when charged fully. This is to ensure that your golf cart batteries are in proper condition and not showing any signs of problems or defects such as an old battery.
If the batteries are fully charged, how long should I expect for it to work?
If you have new batteries, then 30-50 miles should be possible. There are two ways to know how old a car battery is. The easiest way is by looking at the date code on top of it and if you have trouble deciphering that, then there's always an easy solution by performing a load test.
After a few attempts to charge the batteries, tried trickle charge as well but still won't work?
It is possible that your battery has gone too far and will need to be replaced. This can happen if you have not been able to charge it for a while or when the voltage does not increase after several hours of charging.
What will happen if the battery gets overfilled (watering system)?
The worst thing you can do to a battery is to overfill it. This results in loss of acid or changes the level of electrolyte (acid) inside, which then damages the plates within and shortens its life expectancy.
How to change battery in golf cart?
Step 1. Open the battery compar tment. Since golf cart batteries are generally under the front seat this requires that the front seat be lifted out of the cart. On some cart models the front seat is hinged and the front of the seat is lifted straight up. Step 2.
What to do if battery won't take full charge?
Check the battery in the morning. If the battery still won't take a full charge, it likely cannot be saved. If the battery has taken a charge, replace the cell caps and use your cart normally.
How to clean a battery with baking soda?
Clean the battery with your paintbrush dipped in a baking soda solution as described in Step 2. Rinse your battery with plain water, making certain none of the water gets into any of the cells. Step 9. Mix 8 ounces of Epsom salts into 2 quarts of warm distilled water. Stir thoroughly.
How to get corrosion off batteries?
Wearing gloves and eye goggles for protection, mix 2 tablespoons of baking soda into 1 quart of water. Stir well. Dip your paintbrush into this mixture and then liberally paint onto all areas where there is corrosion on the batteries, especially on and around the battery terminals.
How to check if battery charger is full?
If the battery charger indicates that the battery has taken a full charge, inspect the cells and add more distilled water to any cells in which the battery plates are exposed to the air and then replace the cell caps.
What to do if battery charger does not indicate full charge?
However, if the charger does not indicate that the battery has accepted a full charge, you need to take extra measures (see Step 8). Tip the battery on its edge and allow approximately half the battery acid to run out of each cell and into a plastic container.
How to clean a battery that has a cracked case?
Wipe all surfaces of your batteries with plain water until you have cleaned away all of the corrosion. Inspect the batteries for cracks or other defects. Remove and replace any batteries that have a cracked case, especially if it appears to be leaking battery acid into the battery compartment.
What to do if golf cart battery is broken?
Again if the golf cart battery cables are broken or corroded they need to be replaced and reconnected accordingly. Also it is recommended to use some type of corrosion preventative on all terminal connections to avoid the elements eating away at your connector, cables or terminals.
What does it mean when a golf cart battery is bad?
So being if the golf cart battery cable lug connector or connection between two batteries is bad the cart will usually not work, drive or charge. So check all the connections and cables for signs of corrosion or wear or completely broken off battery.
How does a 12 volt battery charger work?
So being in a pinch a 12 volt battery charger will work to get some energy back into your dead golf cart batteries and revive them. The sole purpose here is to just get some energy back into the batteries so the golf cart battery charger itself can do the brunt of the charging and charge the batteries properly.
Why does my golf cart beep?
If you can get enough voltage and energy back into the batteries to make the golf cart move, beep or lights to work usually means there is enough voltage present at this point for the original golf cart battery charger to be plugged in and it will turn on to charge the batteries completely.
How many volts does a golf cart battery need?
Others require a little less. So for example a 36 volt battery charger would require approx. 25-30 volts to activate, whereas a 48 volt charger would require 30-35 or even 40 volts present to activate.
Why is my golf cart battery charger not working?
Ok…. So the first guess or main reason why your golf cart battery charger is not working right now is because the batteries in your golf cart are completely dead. ( Not always but usually 90% of the time) This is because the federal government years ago made it mandatory that all manufacturers ...
Can you baby sit your golf cart batteries?
Though due to recent advances in charging technology you can now purchase a Smart charger for your golf cart that will basically baby sit your batteries while you are away on vacation for the summer or whenever.
How to tell if a golf cart battery is bad?
Symptoms of a failing battery or batteries could include the following: 1 You may notice the battery power and range decreasing over time. The range should be about 2 rounds of golf after charging back to the advertised voltage using a full trickle charge cycle. 2 A “Shutter” feels like you are running across a corduroy road or someone is tapping the brake rapidly. This is a classic sign of low voltage. If this is experienced, your cart may be low on charge, the charger may not be functioning properly or you may have a battery issue. Use a volt meter to measure each battery individually to isolate individual battery health. 3 On electric golf carts, the cart refusing to move at all on a charged set of batteries could be the speed controller not engaging, a faulty maintenance switch, or when the voltage falls below a preset value. 4 A deep cycle battery charge time takes twice as long to charge your batteries as it did when you first had a battery bank installed. As the battery bank ages, it will not hold a charge as well as it used to. The automatic charger has no way to know this and will continue to charge the battery bank trying to get to a full charge – meaning it will take a longer charge time for the batteries than normal.
What to do if battery is cracked?
If a battery is cracked and leaking acid, it should be replaced. With the cell caps removed, check the water level and ensure the battery plates in each battery cell are covered and not exposed. Add distilled water to any that are low. Replace the battery caps. Step 4.
How to clean battery terminals?
Clean the battery terminals posts using 2 tablespoons of baking soda mixed with a 1 quart of water. A Wire scratch brush does the job nicely (it looks like a metal bristle toothbrush). Do not allow any of the baking soda water to enter the battery. Rinse the battery thoroughly and air dry or use a paper towel.
What does it mean when your cart is low on charge?
This is a classic sign of low voltage. If this is experienced, your cart may be low on charge, the charger may not be functioning properly or you may have a battery issue.
How long does a deep cycle battery last?
Battery charging is performed when you are parked for the day. With proper maintenance, a deep cycle battery only lasts a set number of years before the plates get corroded over and are no longer efficient. Some cart batteries are not too far gone and can be rejuvenated using Epsom salts.
How many volts should a 6 volt battery charge?
If you do not have a hydrometer, use a multimeter instead. Measure across the terminals on each individual battery. On 6-volt batteries, you should have a battery charge of slightly over 6 volts, like 6.1 to 6.3. If you get a reading of something like 4.1, then one of the battery cells in this unit is bad or shorted.
What color is a fully charged battery?
Observe also the electrolyte color. A gray or brown coloration shows that the end of your battery life is nearing. If you do not have a hydrometer, use a multimeter instead.
How to deal with golf cart batteries?
The better way to deal with them is to rejuvenate golf cart batteries as it will save a lot of costs and is also an environmentally friendly way to live. There are simple steps in which the golf cart batteries are rebuilt. These steps should be followed in the same sequence to gain the right amount of revived battery power.
What is the difference between golf cart batteries and other vehicles?
The difference between the batteries of golf cars and that of other vehicles is that they do not need a lot of power. It just needs enough to work on smooth roads but for a longer time. The batteries used in the golf carts are mostly 6-volt lead batteries or 12-volt lead batteries.
How to clean a battery that is corroded?
First, put on the gloves and the goggles and mix two tablespoons of baking soda into water. Stir the mixture well. Now, use a paintbrush and dip it in the mix. Use this brush and solution to paint all over the battery where there are signs of corrosion.
How to clean a sandbag cart?
Step 1: The battery should be removed. Most of the cart batteries are placed under the front seat, and you will have to lift the seat up to remove the battery. This could be different for some other cart models who have a hinged seat which can be lifted straight to take the battery out. Step 2: Start with cleaning the battery.
How to charge a battery with a negative pole?
Connect to charge. Carefully connect the positive wire to the positive pole on the battery and the negative charge to the negative pole on the battery. Plug it in and then switch it on for charging after it is safely connected to the battery. Step 7: Leave it for the night. Check the charging level in the morning.
Can you walk too far with a golf cart?
If you are, then you must also use the golf cart to get around the course easily. No one wants to walk too far with all the heavy golf equipment at hand. Golf carts make it easy for golfers to navigate their way all over the course.
How to maintain a golf cart battery?
You should check things out on a regular basis to ensure that everything’s working as it should. Also, you must clean your cart’s components so that oil and other liquids can flow through easily. Add cleaning your golf cart to your monthly lists of chores.
Is it hard to take care of a golf cart?
Taking care of your golf cart isn’t that difficult. All you need is common sense to ensure your ride doesn’t meet an early demise. Here are a few things you can do to make life simpler:
Does driving affect battery life?
Believe it or not, the way you drive can impact your battery’s lifespan. The more reckless you are, the more energy your cart uses. Be smart while you’re on the course. Not only will your battery last longer, but it’s also safer for everyone in your path.
More items to explore
Thermoil Battery De-sulfator Battery Additive 12 Fluid Ounces Refurbishes & Repairs Your Sulfated Batteries. Rejuvenate Your Batteries with Battery De-Sulfator. Proven Protection and So Much More!
Customers who viewed this item also viewed
Thermoil Battery De-sulfator Battery Additive 12 Fluid Ounces Refurbishes & Repairs Your Sulfated Batteries. Rejuvenate Your Batteries with Battery De-Sulfator. Proven Protection and So Much More!
Special offers and product promotions
Amazon Business: Make the most of your Amazon Business account with exclusive tools and savings. Login now
Product description
Our 6 bottles of Liquid refurbish are the best option to fix your poor preforming golf cart batteries...all you need to do is add 1 bottle per battery and then wait 10 days this solution will prove to be very valuable in improving overall power run time and shorten charge time! Others try to copy but our product was the number one product tested by golf cart magazine in 2020 and shown to be the best product that helps older poor preforming batteries !.
Customers who bought this item also bought
Pages with related products. See and discover other items: golf cars, golf cart club car, golf cart club car, golf cart kit, golf cart kit, golf cart repair
