Use a T20 Torx (red arrow) and remove the three screws. Figure 10 Use a large trim removal tool (red arrow) and gently pry the door panel away from the door. With the panel free lift it up and out from the channel along the top of the door.
Full Answer
How do you take the door panel off?
Your door panel is still tethered to the door itself by wires connected to the window, the light, and the lock. On the drivers side door there are more connections to be aware of. Make sure you disconnect all of the little connectors (simple clips) before yanking the door panel off.
How do you remove the side of a car door handle?
Use a flat head screwdriver, or pocket knife, protected by a cloth so as not to damage the handle, to wedge a gap in between the two pieces of the handle. The side facing into the car will now pop off (picture 1), and reveal a couple Philips head screws.
Why would you remove the interior door panel?
The most common reason to remove the interior door panel is to replace the stereo speakers or reupholster the door cards. You also have to remove the door panel to replace a cracked wiring harness in the door hinge area. It can break from use. It's also needed to repair a broken window regulator.
How do you install a door panel on a window seal?
During installation, connect the inner plugs and door handle wire first. Then hook the top of the door card into the window seal. The tweeter trim is a good indicator of if the top of the door card is aligned. After the panel is in place, hit the door panel over the clips to pop them back into place.
How do you remove the interior door panel on a VW Golf?
0:103:40VW Golf Driver's Side Inner Door Trim Removal - YouTubeYouTubeStart of suggested clipEnd of suggested clipAway let's put a screwdriver underneath the easy way of doing it. That's the grip the panel itselfMoreAway let's put a screwdriver underneath the easy way of doing it. That's the grip the panel itself and i'll pop. Out.
How do you take a door panel off a Volkswagen?
Remove the trim near the top of the door panel by pulling it out and towards the back. Remove the third T30 bolt that is now exposed. Use a dash trim removal kit to pry out the door panel. Lift the door panel and pull it away from the door.
How do you open a 4 door Golf panel?
0:001:38VW Golf MK 4 - how to remove door card drivers side - YouTubeYouTubeStart of suggested clipEnd of suggested clipJust about to show you how to remove a driver's side door card on the golf mark 4 first of allMoreJust about to show you how to remove a driver's side door card on the golf mark 4 first of all remove this Phillips drill here and the three t20 Torx screws on the bottom.
How do you take the door panel off a 2001 Volkswagen Jetta?
0:564:14How To Remove Front Door Panel 00-05 VW Jetta - YouTubeYouTubeStart of suggested clipEnd of suggested clipThose. And then just remove this Phillips screw up here in the top corner if you go you reach-inMoreThose. And then just remove this Phillips screw up here in the top corner if you go you reach-in behind the door panel and just pull out release the clips.
How do you remove the door panel on a 2003 Volkswagen Beetle?
0:334:14How To Remove Door Panel 98-10 VW Volkswagen Beetle - YouTubeYouTubeStart of suggested clipEnd of suggested clipDown along the bottom of the door panel there are three t20 Torx drivers our Torx screws let'sMoreDown along the bottom of the door panel there are three t20 Torx drivers our Torx screws let's remove. Those. You and now you want to just pull out on the panel just around the edges.How To Remove Door Panel 98-10 VW Volkswagen Beetle - YouTubehttps://www.youtube.com › watchhttps://www.youtube.com › watchSearch for: How do you remove the door panel on a 2003 Volkswagen Beetle?
How do you remove the door panel on a 2004 Volkswagen Passat?
1:336:46How To Remove Front Door Panel 96-05 Volkswagen Passat - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd then underneath the t25 Torx screws that hold the bottom of the panel to the door. And once youMoreAnd then underneath the t25 Torx screws that hold the bottom of the panel to the door. And once you have those screws. Out. Pull the bottom a little bit.How To Remove Front Door Panel 96-05 Volkswagen Passat - YouTubehttps://www.youtube.com › watchhttps://www.youtube.com › watchSearch for: How do you remove the door panel on a 2004 Volkswagen Passat?
Volkswagen Door Panel Removal
This guide provides step-by-step instructions on how to remove the door panel on a Volkswagen. The video and pictures are from a 2016 VW Jetta, but the steps below will help you remove or replace the door panel on a VW Bora, Golf, Passat, GTI, Polo, EOS, etc.
How to Remove VW Door Panel
Remove the door panel on a VW is easy and takes about 15 minutes. How to remove a VW door panel.
Vehicle
Volkswagen Door Panel Removal This guide provides step-by-step instructions on how to remove the door panel on a Volkswagen.
Over the life of your GTI MkIV, the doors will take a tremendous amount of abuse and sooner or later something will fail
If you need to service your doors mechanicals or want to freshen up the appearance with new trim you will need to remove the door panel.
Project Photos
Figure 1 There are three main components that need to be removed to remove the door panel. The door pull (red arrow), the Philips head screw by the triangular trim piece (yellow arrow) and the three T20 Torx screws alone the lower door trim (green arrows).
Step 1: Remove the Inside Door Handle
This car is built with plastic snaps that keep together a majority of the plastic panels, handles, and latches. The part you grab on the passenger side door has a ridge running down the middle. Use a flat head screwdriver, or pocket knife, protected by a cloth so as not to damage the handle, to wedge a gap in between the two pieces of the handle.
Step 2: Remove Door Panel Screws
You will need a T20 Torx bit to remove 3 screws at the bottom of the door panel, hidden under the edge as pictured. There is also one other sneaky screw on the inside edge of the door, near the top. You will need to open the door as far as possible, and still may have trouble getting an angle at the screw.
Step 3: Mind the Tricky Parts
Once the door panel is completely off and disconnected, do whatever you took the door panel off to do. (DUH)
Step 4: Reassembly
To put your door back together, first reconnect all of the electrical components. Then make sure the door latch hook is put back in the hole in the inside of the inner door latch. Raise the door panel over the locking mechanism such that it lines up with the hole. This is easiest to do while holding the lock steady from under the panel.
