Taking off a Club Car golf cart gas tank is a bit more involved than it is with E-Z-GO models and requires the following steps:
- Put your movement switch in the neutral and service positions. Turn the shut-off valve to off.
- Run the cart until all of the fuel is used to remove it from the fuel lines, pump, and carburetor.
- Remove the negative cable from your battery.
- Drain fuel from the carburetor drain screw with a pan.
- Turn the key off and carefully remove the black and orange wires on the fuel level sending unit.
- Remove the fuel line and vent tube from the tank.
- Carefully loosen the screws on the straps holding the tank on the cart.
- Take the tank out of your golf cart.
How to remove gas tank from club car DS Golf cart?
Once you have removed the body, you can take off the gas tank by unfastening a few bolts. You will have to remove the rear body and seat of the Club Car golf cart to remove the gas tank from the cart. The steps given below tell you how to remove the fuel tank from the Club Car DS golf cart after taking off the seat and rear body.
How do you drain the gas tank on an electric golf cart?
You can drain the gas tank of your golf cart using a simple siphoning action. This becomes essential if you plan to clean the tank. The siphoning can be done using a hose and air blow gun in an EZGO cart. Insert a hose down into the fuel tank as far as it will go.
How do you remove a fuel tank from a Yamaha golf cart?
Take off the fuel line and vent tube from the fuel tank. Loosen the straps holding the fuel tank in place by taking off the screws on the speed nuts. Lift the fuel tank from its position out of the vehicle. Removing the gas tank from the Yamaha golf cart is a relatively simple process.
What is the capacity of a golf cart gas tank?
The 1992 Club Car gas tank has a capacity of seven gallons. However, you should get started with six gallons if your cart has a sled engine to avoid fuel leakage through the vented cap. The 2000 Club Car DS gasoline model gas tank has a capacity of seven gallons. The Yamaha fleet gas golf cart gas tank has a capacity of 5.8 gallons.
How do you remove the gas tank from a club car?
Locate the knob at the bottom of the tank and unscrew it. Remove the engine and seat from the golf cart. Take out the fuel filter inside the tank. Pull the tank out of the cart.
How do you get old gas out of a golf cart?
0:481:33How to siphon old gas out of an ezgo marathon golf cart gas tank - YouTubeYouTubeStart of suggested clipEnd of suggested clipDown while it squeezes the trigger. You see the gas is lifting out into the siphoning into theMoreDown while it squeezes the trigger. You see the gas is lifting out into the siphoning into the bottle there you have it.
How big is a gas tank on a golf cart?
5 and 6 gallonDepending on the manufacturer, most gas golf carts have between a 5 and 6 gallon gas tank and get about 40 miles to the gallon. Electric golf carts with fully charged batteries in perfect condition get about 35 miles to the full charge.
How can I make my club car gas go faster?
0:061:31Club Car Precedent Speed Increase SUPER EASY!!! - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf you turn it that way to the right or what appears to be counterclockwise. It slows it down. AndMoreIf you turn it that way to the right or what appears to be counterclockwise. It slows it down. And if you turn it that way or clockwise it speeds things up. Very.
How do you store a gas golf cart for the winter?
Winter Storage Tips for Your Golf CartClean the vehicle. Before storing, it is imperative that you clean your golf cart, inside and out. ... Drain the fuel. Drain the gas from your cart. ... Perform a full check up. ... Prepare the battery. ... Inflate the tires. ... Ensure the cart won't move. ... Park the vehicle in the proper position.
Do golf carts have titles?
The bottom line is that standard golf carts do not have titles. But, if they are modified to become an LSV then you must obtain a certificate of title.
What is the average lifespan of a golf cart?
For example, some experts estimate that the average golf cart has a useful life range of about 5-7 years. That said, golf carts can still be used for 10 years or more depending on how well they are maintained and how much money a buyer wants to put into their vehicle.
How many miles does a gas golf cart last?
How you'll use a golf cart: Desired range: An electric cart's range is typically 15 to 25 miles, depending on the type of battery. With a 4 to 6 gallon fuel tank, you'll average 100 to 180 miles with a gas cart.
How much horsepower does a gas golf cart have?
Gas powered golf carts use regular unleaded gasoline. The average gas powered carts have 10 to 12 horsepower. These engines operate similar to that of a car which means that their maintenance will be similar to that of a car.
How do I get more power out of my Club Car golf cart?
6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.
Why is my gas golf cart slow?
Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
How fast does a Club Car golf cart go?
The fastest electric golf cart that Club Car has on offer is the Villager 2+2 LSV that goes 23 mph. The fastest gasoline Club Car only goes 19 mph. And the fastest electric EZGO is the 2Five that goes 25 mph. And the fastest EZGO gasoline golf cart also only goes 19 mph.
How to drain gas in a golf cart?
You can drain the gas tank of your golf cart using a simple siphoning action. This becomes essential if you plan to clean the tank. The siphoning can be done using a hose and air blow gun in an EZGO cart. Insert a hose down into the fuel tank as far as it will go.
How to get gas out of a gas tank?
Stick a five-foot-long 5/8-inch heater hose into the gas tank. Make sure it goes down as much as possible. Place a catch pan on the floor. Cover the opening of the gas tank using a rag. Insert an air blow gun into the tank through the rag. Push the air inwards until the gas begins to flow out of the hose.
How many gallons of gas in 1992 Club Car?
The 1992 Club Car gas tank has a capacity of seven gallons. However, you should get started with six gallons if your cart has a sled engine to avoid fuel leakage through the vented cap.
How to remove gas tank from 1987 G2?
The steps given below will guide you on how to remove the gas tank from the 1987 Yamaha G2 golf cart. Remove the engine and seat from the golf cart. Remove the three bolts holding the fuel tank in place. Unscrew the knob present at the bottom of the tank. This helps to detach the fuel line from the fuel tank.
How to collect drained gas from a gas tank?
Place a rag over the opening of the tank and a catch pan on the floor to collect the drained fuel. Blow air into the tank using the air blow gun until the gas flows downwards through the hose. Collect the drained fuel in the catch pan or any other vessel that has been approved for this purpose.
How to clean a gas grill?
Clean the outside of the gas tank with a degreaser that is used to clean grills. Siphon out the old gas fuel from the tank as mentioned above. Spray some of the siphoned fuel along with a little carb cleaner into the tank. Put a lint-free towel over a coat hanger and use it to wipe the inside of the tank.
How to get rid of water in gas tank?
Put some water and cleaning agents into the tank. Use the air flow gun once again to circulate the cleaning agents to all parts of the gas tank. You may need to run the air for about 20 minutes. Pump out the water to get the tank dry. Use simple green or shop vac to get rid of the water that doesn’t get pumped out.
