
Figure 15 With the engine and transmission safely supported remove the two 18mm transmission mounting bolts (yellow arrows). With a friends help separate the transmission from the engine. Carefully lower the engine (approx 3-6 inches) until you can pull the transmission off and clear of the engine.
Full Answer
Can a manual transmission GTI MkIV be repaired?
One of the most common repair procedures for the manual transmission GTI MkIV is the replacement of the clutch assembly, especially if the car has been modified to make more horsepower. Unfortunately, it is a rather big process involving the removal of the transmission.
How do I change transmission fluid in a GTI mark 4?
Fortunately, changing transmission fluid in the GTI Mark 4 is actually easier than changing the oil, at least in a manual transmission car, because you don't have to change the filter as well. You simply drain the old and find a way to fill the transmission with new fluid.
How do you remove the transmission from the engine case?
You need to place the jack at an angle that will allow you to pull the transmission direct back and away from the engine case. Figure 14 Remove the cross brace from the transmission mount to the transmission (red arrows).
How do you change the transmission fluid?
You simply drain the old and find a way to fill the transmission with new fluid. It's easier to do this job if you first raise the car to a level position (the fill hole, when the car is level, serves as the indicator that the transmission has the proper amount of oil in it), and then remove the under tray.

How do you remove a automatic transmission?
0:000:54Auto Repair Tips : How to Remove an Automatic Transmission - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt doesn't come out easily. The procedure for this particular transmission is I'll have to suspendMoreIt doesn't come out easily. The procedure for this particular transmission is I'll have to suspend the engine and transmission from a special tool on the top. While I remove the subframe.
How do you remove a transmission gearbox?
1:4828:24How to Replace a Transmission (Full DIY Guide) - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd while that might seem like a lot it's really not that bad what i did is i broke it down to aMoreAnd while that might seem like a lot it's really not that bad what i did is i broke it down to a bunch of smaller easy to accomplish steps.
How much does it cost to replace a VW Golf transmission?
The cost of a new 2015 VW Golf transmission could be over $3,500 depending on the vehicle, however, transmission services such as fluid changes and a transmission fluid flush are considerably less expensive, in some cases costing less than $150.
How do you remove a manual transmission?
0:3327:00How To Pull a Manual Transmission - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd right here are four bolts that hold the motor mount or the rear motor mount and transmissionMoreAnd right here are four bolts that hold the motor mount or the rear motor mount and transmission mount to the skid plate. So you need to take these four. Off. Now everything here is in play.
Can I replace transmission myself?
When faced with a transmission rebuild or replacement, you can reduce the cost quite significantly by removing and replacing (R&R) the transmission yourself. Depending on the year, make and model of your vehicle and the shop labor costs in your area, you can expect to save between $550 to $1,250 or more.
How long does it take to remove a transmission?
The amount of time required to replace a transmission often depends on the type of transmission and the vehicle. It usually only takes a day or two to replace a transmission in most rear wheel vehicles. However, some late-model, front-wheel drive vehicles can be quite labor-intensive and take three to four days.
Is it cheaper to rebuild or replace a transmission?
A transmission replace is the most expensive option when fixing your transmission. In many cases you will hear this referred to as “re-manufactured.” Basically, the manufacturer will replace parts that have gone bad with modified parts. This is an option if the transmission is too damaged to even consider a rebuild.
Is it worth fixing a transmission?
Rebuilding a transmission can save you a lot of money over the short-term, while keeping car payments out of your monthly budget. For many, rebuilding their transmission is worth the initial cost. Rebuilding a transmission may cost you twenty-five hundred dollars or more, which is a significant chunk of change.
How much does it cost to remove and install a transmission?
The exact transmission cost will vary, based on your particular vehicle and your service department of choice, but you can expect to pay in the ballpark of $1,800 and $3,400 for brand new parts – and don't forget about the labor costs, which can run between $79 and $189.
How do you separate transmission from engine?
1:085:45Transmission Stuck to Engine! How to Separate Transmission ... - YouTubeYouTubeStart of suggested clipEnd of suggested clipWe use two jacks and the engine hoist. So basically the motor is completely free from the engineMoreWe use two jacks and the engine hoist. So basically the motor is completely free from the engine mounts. So we could move this back and forth as well as the transmission underneath.
How do you pull a transmission from a junkyard?
0:1522:03How To Pull A Transmission at the Salvage Yard - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo if you need to figure that out check out that video. So we're just going to start right here soMoreSo if you need to figure that out check out that video. So we're just going to start right here so the transfer case is what selects your four wheel drive or two wheel drive or neutral.
How do you remove a gearbox from a motor?
1:203:50Motor Installation & Removal Savings - The Regal Way - YouTubeYouTubeStart of suggested clipEnd of suggested clipOver the motor is accomplished by simply removing the four mounting bolts and sliding. The motorMoreOver the motor is accomplished by simply removing the four mounting bolts and sliding. The motor away from the gearbox. Reinstallation. Is also simple and requires installing coupling hubs sliding.
How do you change a gear box?
0:0311:45How to replace your Power Steering Gear Box! - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo get it lined up straight a good place to start from that way you know for reference if you'reMoreSo get it lined up straight a good place to start from that way you know for reference if you're closer not when you're putting it together is you need to get it. Close.
How do you pull a transmission from a junkyard?
0:1522:03How To Pull A Transmission at the Salvage Yard - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo if you need to figure that out check out that video. So we're just going to start right here soMoreSo if you need to figure that out check out that video. So we're just going to start right here so the transfer case is what selects your four wheel drive or two wheel drive or neutral.
How do you disassemble a gearbox with a motor?
1:522:51g500 - Dismounting a central thread geared motor - YouTubeYouTubeStart of suggested clipEnd of suggested clipSide once the motor is loosened enough remove the clip and the screw. You can now rotate the motorMoreSide once the motor is loosened enough remove the clip and the screw. You can now rotate the motor from the gearbox in a counterclockwise. Direction to dismount.
Where is the fill plug on a transmission?
The fill plug (yellow arrow) is on the front left side of the transmission case while the drain plug (red arrow) is on the bottom by the dog bone. Large Image | Extra-Large Image. Figure 3. As with any car always make sure you can remove the fill plug first before you remove the drain plug (red arrow).
Can you change transmission fluid on a GTI Mark 4?
Fortunately, changing transmission fluid in the GTI Mark 4 is actually easier than changing the oil, at least in a manual transmission car, because you don't have to change the filter as well. You simply drain the old and find a way to fill the transmission with new fluid. It's easier to do this job if you first raise the car to a level position ...
