Golf-FAQ.com

how to repair a golf cart battery

by Winifred Gutkowski Published 3 years ago Updated 2 years ago
image

How to refurbish a golf cart battery step by step?

 · DIY, repair of a Golf Cart Battery with wrong styled posts, that was used in an Electric Car.

How do you refurbish golf cart batteries?

Clean the battery terminals posts using 2 tablespoons of baking soda mixed with a 1 quart of water. A Wire scratch brush does the job nicely (it looks like a metal bristle toothbrush). Do not allow any of the baking soda water to enter the battery. Rinse the battery thoroughly and air dry or use a paper towel.

How to recondition golf cart battery in 10 Easy Steps?

 · Using This Simple Guide, You Can Repair Your Golf Cart Batteries. Close and clean the Battery Compartment. Wash the Paintbrush and dip it into water. Open and clean the Battery Compartment. Check the battery’s condition. Discard the plastic caps. charge the battery. check the battery’s charge.

How to restore old golf cart batteries?

Get a 100% free education on Golf cart and electric forklift battery reconditioning and save yourself or your company a fortune. Our site contains many free...

image

Can golf cart batteries be repaired?

Can you refurbish Golf cart batteries? Yes, it is reasonably possible to recondition your golf cart batteries. But, there will be a condition for that. If the battery is not fully dead and you can charge it up to a certain extent, it will be possible to refurbish it.

How do I bring my golf cart batteries back to life?

Step 1: Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. ... Step 2: Mix 8 ounces of Epsom salts into 2 quarts of warm distilled water: Stir thoroughly. ... Step 3: Put the battery or batteries on a charger.

How do you revive golf cart batteries with Epsom salt?

Mix 4 ounces of Epsom salts into a quart of warm distilled water and stir. Using a turkey baster fill each battery cell slightly over the lead plates. Do this for a cycle of 4 charges so the Epsom Salts remove the deposits on the battery plates.

How do you revive a battery that won't charge?

1:514:23How to get dead batteries working again: EASY HACK - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd the wire from the negative on the bad battery or the good battery i should say to a negative onMoreAnd the wire from the negative on the bad battery or the good battery i should say to a negative on the bad battery give it a little boost.

How to tell if a golf cart battery is bad?

Symptoms of a failing battery or batteries could include the following: 1 You may notice the battery power and range decreasing over time. The range should be about 2 rounds of golf after charging back to the advertised voltage using a full trickle charge cycle. 2 A “Shutter” feels like you are running across a corduroy road or someone is tapping the brake rapidly. This is a classic sign of low voltage. If this is experienced, your cart may be low on charge, the charger may not be functioning properly or you may have a battery issue. Use a volt meter to measure each battery individually to isolate individual battery health. 3 On electric golf carts, the cart refusing to move at all on a charged set of batteries could be the speed controller not engaging, a faulty maintenance switch, or when the voltage falls below a preset value. 4 A deep cycle battery charge time takes twice as long to charge your batteries as it did when you first had a battery bank installed. As the battery bank ages, it will not hold a charge as well as it used to. The automatic charger has no way to know this and will continue to charge the battery bank trying to get to a full charge – meaning it will take a longer charge time for the batteries than normal.

What to do if battery is cracked?

If a battery is cracked and leaking acid, it should be replaced. With the cell caps removed, check the water level and ensure the battery plates in each battery cell are covered and not exposed. Add distilled water to any that are low. Replace the battery caps. Step 4.

How to clean battery terminals?

Clean the battery terminals posts using 2 tablespoons of baking soda mixed with a 1 quart of water. A Wire scratch brush does the job nicely (it looks like a metal bristle toothbrush). Do not allow any of the baking soda water to enter the battery. Rinse the battery thoroughly and air dry or use a paper towel.

Why is my golf cart not moving?

On electric golf carts, the cart refusing to move at all on a charged set of batteries could be the speed controller not engaging, a faulty maintenance switch, or when the voltage falls below a preset value.

What does it mean when your cart is low on charge?

This is a classic sign of low voltage. If this is experienced, your cart may be low on charge, the charger may not be functioning properly or you may have a battery issue.

How to replace battery acid?

Use Epsom salts to make a replacement for the drained battery acid. The ratio should be 1 quart of distilled water with 2 tablespoons of Epsom salts. Fill Each cell with this mixture to the proper fill level. The goal here is to dissolve deposits that have formed on the plates and restore the surface area to a usable state.

How long does a deep cycle battery last?

Battery charging is performed when you are parked for the day. With proper maintenance, a deep cycle battery only lasts a set number of years before the plates get corroded over and are no longer efficient. Some cart batteries are not too far gone and can be rejuvenated using Epsom salts.

How to deal with golf cart batteries?

The better way to deal with them is to rejuvenate golf cart batteries as it will save a lot of costs and is also an environmentally friendly way to live. There are simple steps in which the golf cart batteries are rebuilt. These steps should be followed in the same sequence to gain the right amount of revived battery power.

What is the difference between golf cart batteries and other vehicles?

The difference between the batteries of golf cars and that of other vehicles is that they do not need a lot of power. It just needs enough to work on smooth roads but for a longer time. The batteries used in the golf carts are mostly 6-volt lead batteries or 12-volt lead batteries.

How to clean a battery that is corroded?

First, put on the gloves and the goggles and mix two tablespoons of baking soda into water. Stir the mixture well. Now, use a paintbrush and dip it in the mix. Use this brush and solution to paint all over the battery where there are signs of corrosion.

How to clean a sandbag cart?

Step 1: The battery should be removed. Most of the cart batteries are placed under the front seat, and you will have to lift the seat up to remove the battery. This could be different for some other cart models who have a hinged seat which can be lifted straight to take the battery out. Step 2: Start with cleaning the battery.

How to charge a battery with a negative pole?

Connect to charge. Carefully connect the positive wire to the positive pole on the battery and the negative charge to the negative pole on the battery. Plug it in and then switch it on for charging after it is safely connected to the battery. Step 7: Leave it for the night. Check the charging level in the morning.

Do you need a golf cart to play golf?

Are you fond of playing golf? If you are, then you must also use the golf cart to get around the course easily. No one wants to walk too far with all the heavy golf equipment at hand.

Can you throw away a dead golf cart battery?

Isn’t that just inconvenient? If you think the battery is dead, don’t throw it away just yet. We’ll teach you how to recondition golf cart batteries in no time, so you don’t have to spend money buying a new one.

What do you need to recondition a golf cart battery?

Golf cart batteries are lead-acid types, so you need to wear your safety gear before doing the reconditioning process. The safety gear you need are goggles, rubber gloves, and apron.

Why can't you dispose of golf cart batteries?

You cannot readily dispose of these kinds of waste because it contains chemicals detrimental to the environment.

How many volts does a golf cart battery need to charge?

For automatic chargers intended for golf cart cells, it cannot charge if the battery is completely dead. If you have 36 volts for your golf cart battery set, then it must have at least 20V to 25V, for your automatic charger to recharge it back. For a 48-volt golf cart battery set, it must retain 30V to 35V for your automatic charger to recharge it.

How to know if a battery charger is not working?

To know if the charger is not working, you can test it with another cell. To examine if each cell has the right voltage capacity, use a voltmeter. Charge your battery to full capacity before reading its voltage with a voltmeter.

How many volts does a golf cart have?

In that case, you probably own a personal golf cart. It usually has 4, 6, or 8 6-volt lead -acid batteries – a lower capacity but similar cell to the ones used in standard lead-acid car batteries. There will come a time that your golf cart batteries will die out or reduce its charge capacity. Replacing all those 4 to 8 power packs would cost you ...

What type of batteries are used in golf carts?

There is a lot of confusion about golf cart batteries. There are three types of lead-acid batteries: flooded, gel and AGM. Golf carts use flooded or AGM-type batteries.

Can you refill a golf cart if it is not full?

Check for the water level of your golf cart cells. If it is not at full level, do not refill unless you are done charging it to 100 percent full capacity. Filling the water at a full level before charging can cause spillage during the charging process.

How deep should I drill a battery terminal?

Only drill 1/2 to 3/4 of an inch at the most. I won't go into to much detail on how the terminal is shaped, I will say it necks down in size as it enters the case. If you are off center and drill too deep you will end up with a battery that leaks battery acid from the terminal, so stay straight as possible and only drill 1/2 to 3/4 of an inch at MOST..

Can you use a bolt on lead?

The New threads.... DO NOT USE A BOLT! Only use a Socket Set Screw or similar stud. Lead is very soft and will strip the threads very easily.

Can thread locking compound be used on golf cart studs?

Thread locking compound can be used on the stud but if you do try to use the type that can be disassemble d if needed. (Blue loc-tite.). End result.... A brand new terminal ready for use. You can also do this if you need extra connections for golf cart accessories.

What to do if your golf cart battery hasn't taken a full charge?

If the battery has taken a charge, replace the cell caps and use your golf cart for a long ride and see how long the charge lasts.

How to keep golf cart batteries charged?

Another good thing to have for your golf cart batteries is a watering system. Make sure you check the water level in your golf cart batteries monthly to make sure they are still saturated. ( always do this after your batteries are fully charged because if you check them and fill them before you charge them 100% you could over fill them and acid will leak out the top of the batteries while they charge and get all over your cart and in the garage or where ever you store the golf cart. Which is not good because battery acid will eat away at your concrete floor in the garage. Checkout Pete’s great deals on a new One point golf cart watering system to avoid over filling them and making a mess or getting battery acid on your cart, clothes or garage floor and do it with ease. ( In minutes – not an hour or more… weekends are meant to be spent with the family or watching the game not in the garage filling batteries… so get yours today!)

How to clean a battery with acid?

Step 1: Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. Clean the battery with your paintbrush dipped in a baking soda solution. Rinse your battery with plain water, making certain none of the water gets into any of the cells.

Can you replace a golf cart battery?

If the ride and power is short lived it is still likely you will need to replace your golf cart battery. It is also quite possible that your golf cart battery charger is not charging properly. You will need a volt meter to check the power output of your battery charger.

image
A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9