Golf-FAQ.com

how to repair a golf cart motor that puts positive voltage to the frame

by Prof. Emil Ullrich Published 3 years ago Updated 2 years ago

How to fix a faulty voltage regulator on a golf cart?

Use a jumper and connect it from the ground of the cart to the stud of the starter generator. If the voltage is 15VDC or more, then the voltage regulator is faulty. Remove the drive belt from the golf cart. You can also consider turning off the engine of the cart so that there is no movement.

How do you increase the voltage on a golf cart?

Connect a voltmeter to the poles of the battery and start the engine of the golf cart. Make sure that there is no spin. The voltage should typically be 12.6 volts. Raise the speed of the golf cart engine. The voltage will also increase accordingly until the speed is nearly 1,000RPM.

How to check a golf cart battery voltage?

Connect the voltmeter to the battery and get the golf cart running. You can consider applying the hand brake to prevent rolling. Check if the voltage rating is between 14 volts and 16 volts. If it’s less than this range, remove the wire above the starter generator after stopping the cart.

Why won’t my electric golf cart move?

Obviously, for electric golf carts, the battery is what provides power to your motor. If your batteries start to quit on you, the golf cart won’t move, or will drastically decrease in range. With a gas motor, the battery is what starts the motor and keeps it running by providing electricity to the spark plugs.

What does the voltage regulator do on a golf cart?

The voltage regulator is responsible for limiting or regulating the amount of power sent back to the battery for recharge. When your golf cart is started, the starter generator acts as a starter motor to start the engine to spin.

How do you reset a golf cart electric motor?

First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!

How do you troubleshoot an electric golf cart motor?

Ignition or Motor Issues Look for a small red button located near the main power supply. Press the button and put your cart back together before hooking it up to charge. In many cases, this will solve the problem. If it doesn't, try removing the motor and testing it with a separate, fully charged battery.

Is there a voltage regulator on a electric golf cart?

A golf car voltage regulator is one of the most important parts of a golf cart. The voltage regulator helps to limit and regulate the power that is sent to a golf cart battery for its recharge. When you start your golf cart, the starter generator performs the role of a starter motor and causes the engine to start.

Do all electric golf cart motors have a reset button?

Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.

Where is the reset button on an electric Club Car golf cart?

Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.

How do you reset the motor on a EZ Go golf cart?

Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button. Push the button to reset the motor. Put the panel in place and secure it with the screws.

How do I know if my golf cart solenoid is bad?

If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.

How do I reset my Club Car motor?

Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...

How do I know if my voltage regulator is bad on my golf cart?

How to Check If the Voltage Regulator Is FaultyMajor electrical components such as the dashboard or lights will start fluctuating or dimming. ... The battery becomes drained, even though no electrical component was left on. ... The engine will start experiencing problems such as stalling or a lack of constant acceleration.More items...

Where is the voltage regulator located?

On most vehicles, the voltage regulator is either located inside of the alternator or mounted to it. But vintage vehicles often have an external voltage regulator, which may be mounted to the fender well, firewall, etc. It's also important to note that some modern vehicles do not have a voltage regulator at all.

How do you test a golf cart voltage regulator?

2:433:39How to test a ezgo voltage regulator - YouTubeYouTubeStart of suggested clipEnd of suggested clipThat's how it was running before which this battery over here got boiled and it is an old batteryMoreThat's how it was running before which this battery over here got boiled and it is an old battery anyway but still. So if you have a problem with your batteries sweating like fluid coming out of it or

How do I reset my club car motor?

Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...

Where is the reset button on an EZGO electric golf cart?

Locate the motor Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.

Why won't my electric golf cart go forward or reverse?

The problem could be with either the Run/Tow switch or Forward/Reverse switch or both. Check the switches to ensure that they aren't stuck midway. If they are, getting them released should help. However, if they show signs of wear and tear, you must get them replaced.

How do you fix a golf cart that won't move?

When the cart won't move, you have to be sure that the batteries are sending sufficient power to the circuit. You must check the fuse. Use the voltmeter to check the voltage at the key switch. In a cart with batteries rated at 48V, it must show 48V at the key switch.

A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9