Take the golf trolley wheel off and lay it on the ground with the inner hub upwards. From there it is then possible to find out if the inner hub is rotating one way only as it should, (see photo). For a left wheel, the inner metal hub should only rotate ANTI-CLOCKWISE. and for the right wheel, it should only rotate CLOCKWISE.
Full Answer
Why is my electric golf trolley so slow?
Some of the most common problems for a slow electric golf trolley are: The battery does not have enough charge. Some of the Battery cells are at fault. Common problems for electric golf trolley keeps cutting off are: Other faults with power cutting off see golf trolley power problems A very common problem with an electric golf trolley controller;
What to do if your golf trolley has no power?
If you suspect there is power getting through to the golf trolley then the next thing to check is all the connectors. Start under the battery tray there is a rectangular housing that holds the controller box. Unplug these connections checking them and spaying them if necessary with WD40 or similar.
How do you fix a trolley that won't pull forward?
Prop the trolley up safely and put the power to slow and carefully see if you can hold GENTLY back any wheel. This will test if the power is getting to drive the trolley forward through each individual wheel clutch. THERE CAN BE MANY REASONS FOR THE GOLF TROLLEY NOT PULLING OR DRIVING CORRECTLY.
Do I need to replace my golf trolley main wire?
GOLF TROLLEY MAIN WIRE NEEDS to be REPLACED. FITTING THE WIRING CAN BE TRICKY, THE FOLLOWING IS SOME HELP.
What can go wrong with electric golf carts?
5 Common Electric Golf Cart Problems and How to Solve ThemTroubleshooting Batteries. Like any electric vehicle, the battery is often the root of the problem. ... Ignition or Motor Issues. ... Solenoid Woes. ... Faulty Direction Switch. ... No Speed Control.
What causes an electric golf cart to lose power?
If the coach goes without charge for a long time, the battery may lack the minimum voltage required to restart. Batteries also lose their efficiency with age. Golf Carts will run for approximately five years before the battery needs to be replaced or the charger will need replacement.
How do you fix a golf cart that won't start?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
How do you troubleshoot an electric club car?
2:3915:0248 Volt Club Car Diagnostics - YouTubeYouTubeStart of suggested clipEnd of suggested clipMake sure your key switch is on step on the accelerator. You should get a light here.MoreMake sure your key switch is on step on the accelerator. You should get a light here.
Why is my golf cart not holding a charge?
If you find that your golf cart won't go very far on a full charge, then you probably need new batteries. Test them to make sure that the power on them is low; if indeed it is, then you need new batteries.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do you reset an electric golf cart?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do you test an electric golf cart motor?
3:5410:28Testing 36 volt golf cart motor with 12 volt battery - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou just want to connect the two together with this again a2 to s1 with this jumper cable. And youMoreYou just want to connect the two together with this again a2 to s1 with this jumper cable. And you want to take the battery box or positive cable and put it on the s2.
Where are the fuses on a golf cart?
Locate the service panel of the golf cart. This is usually found behind the battery on the driver's side on the rear fender. Make a note of the current ratings supported for each fuse at the highest voltage.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
Where is the reset button on a Club Car golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
How long do electric golf cart motors last?
Golf Cart Motor Just like solenoids (mentioned above), your golf cart motor works HARD. When properly taken care of, the typical gas or electric golf cart motor can last many, many years (20 to 30+).
Why do you need a golf trolley?
It does all the heavy lifting for you so you can keep your strength and energy for making those long range drives and accurate chips over hazards and onto the green.
Why does my trolley stop and start?
Stopping, starting and changing speed by itself can all be indications to a fault in your trolley’s speed controller box which is causing it to output various amounts of power intermittently . While this could also be a sign of a bad battery lead, this is very unlikely to cause changes in speed and would instead just start and stop, but it may be good to check the connections and make sure they’re clean and not damaged. Both parts should disconnect and connect relatively easily without too much fiddling around.
Why is my trolley pulling to one side?
A weak wheel clutch on one side will cause the afflicted wheel to rotate slower than the one with the stronger clutch.
Why is my battery life so short?
Less power and shorter battery life can be signs of an aged battery. Over time the battery’s capacity will drop which will cause it to lose power faster and travel slower. A new battery will sort this out and you’ll find it working as good as new once it has been replaced. If a new battery doesn’t correct this then it may be a fault in the motor which could be outputting low power and excessively be draining the battery.
Why are my buttons on my control panel so worn?
The buttons on your control panel will wear over time due to normal usage. If you find that you have to press the buttons with more force but they do still respond, it may just be the overlay that needs replacing. If it isn’t responding at all, it will be the internal top board causing the issue. You can disconnect the current one by opening the handle to get inside. Once you have put the new one in, reassemble the handle and you will be good to go.
