Your golf cart may be stuck in either forward, reverse, or in neutral and will start and rev the motor, but it will either not go anywhere, or only go in forward or reverse. How to Fix it Remove the seat and move the shift lever. If the lever isn’t broken, look at your cable where it switches gears in the transmission.
Full Answer
How to fix a golf cart clutch not engaging?
Fixing the battery will usually help you resolve the issue of your golf cart clutch not engaging. If you find that the issue does not lie with the battery, then you might have to remove the back cover and take a look at the system to figure out what the issue is. With the rear end jacked up, try throttling the cart.
Why is my golf cart transmission not smooth?
When you’re driving up a hill or even on a flat surface and notice that the cart transmission is not smooth, then it clearly indicates that the issue lies with the clutch system. Another common problem a lot of people face is a jerky start. The cart while starting up might give out a few jerky movements.
How to fix a golf cart that won’t go forward?
You can try out the following steps to help solve the issue. Check the Forward/Reverse switch of your golf cart for loose connections. If the connections are intact, interchange the top and bottom wires at the rear. If the cart now goes in reverse but not forward, the problem is with the switch. You have to just change the switch in this case.
Are there any electrical problems with a gas golf cart?
While you might own a gas golf cart, there are still a number of electrical components that can malfunction. Here are a few of the main electrical problems that can occur with your gas golf cart. The ignition switch on your cart is known to have problems. Wires can become loose, or ground out which causes your golf cart to not fully operate.
How do you fix a golf cart that won't move?
When the cart won't move, you have to be sure that the batteries are sending sufficient power to the circuit. You must check the fuse. Use the voltmeter to check the voltage at the key switch. In a cart with batteries rated at 48V, it must show 48V at the key switch.
What would cause a golf cart not to move?
Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
Why won't my golf cart go forward or reverse?
The problem could be with either the Run/Tow switch or Forward/Reverse switch or both. Check the switches to ensure that they aren't stuck midway. If they are, getting them released should help. However, if they show signs of wear and tear, you must get them replaced.
What causes a golf cart to jerk while driving?
A Club Car golf cart jerking from the front end of the golf cart occurs due to poor quality of tires. If the tires are worn out or loose, the golf car can start jerking. The uneven height of your front tires can also cause jerking.
Why does my golf cart click but not move?
A Club Car golf cart can start clicking but not move, due to dust accumulating inside the battery ports. Opening the battery ports and checking whether there is any dust accumulation can tell you if this is the case. Cleaning it thoroughly with a cloth can resolve the problem.
Why does my golf cart not accelerate?
Bad Solenoid If your golf cart does not accelerate, there is a possibility of the damaged solenoid. The solenoid is basically an electrical switch that enables the battery's flow from the battery into the motor. Check out the signs of the bad solenoid.
How do I test a golf cart solenoid?
Turn on the engine of the cart and press the pedal downwards. If you hear a clicking sound, then it means that the low side voltage is working. But, if there is no such sound, it means that either there is no low side voltage or there is a problem with the solenoid. Use a voltmeter and engage the solenoid.
Why would a golf cart only work in reverse?
If your golf cart is only moving in reverse, there could be an issue with the contacts in the forward and reverse switch. What is this? This can be checked by swapping the two wires present in the swivel terminals in the center.
How do you make a golf cart go forward?
0:5911:38Golf Cart Forward Reverse Switch - YouTubeYouTubeStart of suggested clipEnd of suggested clipMost likely that your forward reverse switch. Which is located right there. This is what makes yourMoreMost likely that your forward reverse switch. Which is located right there. This is what makes your golf cart go forward or reverse.
What causes jerking during acceleration?
Dirty fuel injectors are among the most common reasons for why an accelerator becomes jerky. The dirty injector leads to your car losing power when you attempt to accelerate while at a stop and when you try to drive at a consistent speed. This is the result of an engine misfire.
Why does my golf cart shake when I accelerate?
The common cause of golf cart vibrates when accelerating due to damaged inner CV joints, broken motor mounts, unbalanced tires or a bent driveshaft. To fix this issue, you should check the CV joints of your golf cart. Check the driveshaft, whether this is in good condition or not. The CV joints should be well greased.
What does it mean when your car struggles to accelerate?
Among the causes of poor acceleration are clogged fuel injectors and/or inadequate fuel pressure/volume. When an injector is clogged it can degrade the performance of the vehicle and the car may accelerate slowly or feel that it does not have enough power.
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
Where is the reset button on a Club Car golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
How do I know if my golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
Why won't my clutch engage in a cart?
This could be because the clutch is slipping from its designated position.
Why is my golf cart jerky?
After a while, it could become smooth, but this problem is caused due to some issues with the clutch system.
How to stop a clutch from squeaking?
You could also try lubricating the system with a good quality lubricant. This might free up the clutch and thus prevent the squeaking noise.
How to stop clutch from coming apart?
Gently place the crowbar behind the clutch and apply pressure. The clutch might slide off and come apart. Make sure to add even pressure at the same intervals otherwise you might end up breaking a part. If none of these techniques work, you can try cutting some relief on the clutch.
What to do if clutch doesn't engage?
If the clutch still refuses to engage, you might have to get it checked by a service center. They will be able to identify the issue easily and help fix it.
Why is my clutch not engaging?
Sometimes a belt that does not have the correct tension and is loose may cause the clutch to not engage properly. It might help to clean out any rust on the clutch system as this could also be the cause of this issue. Rectifying these problems could help resolve the clutch issue.
What is CVT in golf carts?
Golf carts have a special technology called CVT which stands for Continuous Variable Technology . This technology allows the user a smooth drive without having to worry too much about changing gears. Every golf cart will have a clutch consisting of two parts namely the primary clutch and the secondary clutch.
Yamaha G16-A Golf Cart Service Repair Manual
This is the Highly Detailed factory service repair manual for theYAMAHA G16-A GOLF CART, this Service Manual has detailed illustrations as well as step by step instructions,It is 100 percents complete and intact.
Yamaha Rear Axle and Differential Parts - Golf Cart Repair
Buy Yamaha Rear Axle and Differential Parts from Performance Plus Carts the Golf Cart Experts here for you! FREE SHIPPING ON ORDERS OVER $99 | Details. ... Rear Axle Retaining Ring for Yamaha - G8-G22 Golf Cart. $12.95. ... Transmission Bearing for Yamaha -G2, G8, G9, G11, G14 Golf Cart - #6203. MSRP: $19.95 More ›
Yamaha Golf Cart Parts
Yamaha Golf Cart Parts. Home > Golf Cart Parts > Yamaha. Yamaha Access Panels. Yamaha Axle Covers. Yamaha Floor Covers. Yamaha Front Axles. Yamaha Grill Covers. Yamaha Kick Plates. Yamaha Rocker Panels. More ›
Yamaha Recalls Golf Cars Due to Crash Hazard (Recall Alert ..
Consumers should immediately stop using the recalled Yamaha Golf Cars and contact a Yamaha Golf car dealer to schedule a free repair. Yamaha is contacting all registered owners directly.
Yamaha Parts - Page 1 - cartparts.com
Cart Parts is your online supplier of replacement golf cart parts for your Yamaha golf cart. Our Yamaha golf cart parts meet or exceed OEM quality standards. We even carry both OEM and Aftermarket parts for Yamaha G1, G2, G3, G5, G8, G9, G11, G14, G16, G19, G20,, G21, G23, G22 and the popular Yamaha Drive. Compare. More ›
Yamaha G1 Golf Car Service Repair Manual
Yamaha G1 Golf Car Service Repair Manual 1. YAMAHA SERVICE MANUAL 2. @YAMAHA GOLF CAR GI-AM3 3. EXHAUST VALVE Fig. 1 1. Cylinder 2. Piston 3. Ring nut ass'y 4. Shaft View in direct~onof A 5. Butterfly exhaust valve 6. Exhaust plpe 7. Plug 8. Bear~ng 9. Gasket 10. Gasket cover 11. Lever 12. Locknut 13. Exhaust pipe spring 14. More ›
Shop Yamaha Golf Cart Parts and Accessories at Golf Cart King
No matter why you're needing Yamaha golf cart parts - for luxury, safety or simply repair and maintenance - Golf Cart King has both Yamaha gas golf cart parts and Yamaha electric golf cart parts. We carry golf cart parts and accessories for the following Yamaha cart models: Yamaha Drive and Drive PTV. Yamaha 2013 Adventurer Sport 2+2. More ›
What Kinds of Problems Can a Golf Cart Clutch Have?
Your golf cart's ability to climb uphill — an essential skill to have on South Carolina terrain — depends on how well your primary and secondary clutches work as a unit. If one or both clutches begin to fail, your ability to get your golf cart from point A to point B will begin to fail as well.
How to tell if a golf cart is bad?
Watch out for these telltale signs of a malfunctioning golf cart CVT that is in need of repair or replacement: 1 A sudden inability to maintain even slow speeds when heading uphill or changing elevation 2 Slowing down to a crawl, then speeding up, then slowing again, seemingly without reason 3 Jolting during startup 4 A 'cranking' sound when starting up the golf cart
What does CVT mean in golf carts?
The golf cart clutch or CVT (which stands for Continuously Variable Transmission) may be easy enough for you if you're used to stick-shift driving with your regular vehicle. However, because many people these days don't drive stick-shift, they have a difficult time adjusting to the clutch when they purchase a new or preowned gas-powered golf cart.
What does it mean when a golf cart starts jolting?
Slowing down to a crawl, then speeding up, then slowing again, seemingly without reason. Jolting during startup. A 'cranking' sound when starting up the golf cart.
What is CVT clutch?
The CVT is comprised of two separate clutches that are connected by a thick drive belt. When we refer to the clutch or CVT, we're referring to two components — the drive clutch (or primary clutch) and the driven clutch (or secondary).
What happens if a golf cart solenoid is defective?
When defective, the solenoid fails to transfer current from the battery to other parts of your golf cart.
Why is my EZGO golf cart stuck in reverse?
An EZGO golf cart gets stuck in reverse in case of a faulty Forward/Reverse switch, defective microswitches, or a shorted solenoid bracket.
Why won’t my EZGO golf cart go forward or reverse?
A EZGO golf cart may not go forward or reverse because of a malfunctioning microswitch, solenoid, or ignition switch. Loose or corroded cable connections or a faulty controller can also cause the golf cart to not move.
Why EZGO gas golf cart will not reverse?
A EZGO gas golf cart will not go in reverse if there is a faulty transmission system, improper cable adjustment, a defective microswitch present inside the Forward/Reverse controller, or a malfunctioning neutral limit switch.
Why EZGO goes in reverse but not forward?
Your EZGO may go in reverse but not forward due to a problem in the F&R contacts, faulty high amperage cables, or swapped motor wires.
Why does my golf cart make a clicking sound when I press the gas pedal?
If you don’t, this indicates a problem in the KSI circuit that causes the KSI microswitch to not make contact. Getting the KSI circuit redone correctly should get the golf cart moving in both directions.
Why is my Ezgo Marathon not in reverse?
An EZGO Marathon golf cart goes forward but has not in the reverse if the Forward/Reverse switch contacts fail to make contact in the reverse position or the KSI microswitch doesn’t make any contact when the Forward/Reverse switch is in the reverse mode. Sometimes, reverse microswitch may be defective and not engaging. You may have to do one or both of the following steps to rectify the problem.
