If your cart is sluggish or won't start, the battery may need to be charged. If it is charged, but still not working properly, make sure the battery terminal connections are clean and secure. You can use a mixture of baking soda and water to clean the terminals by removing corrosion and other debris.
What to do if your Yamaha G16 turns over but wont start?
Yamaha G16 golf cart turns over but won’t start. If you have a Yamaha G16 golf cart that was working fine till very recently, consider. Checking if the crank case vacuum tube is lying disconnected at the back. If it’s not, then move on to the next step. Next verify if you have sufficient air and fuel lines in working condition.
What should I do if my golf cart does not start?
On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge. If there is no click when the pedal is pushed, then there is no solenoid activity.
How to fix Yamaha golf cart solenoid not clicking?
G16 Yamaha Golf Cart Solenoid Not Clicking 1 Take a jumper wire. 2 The ignition key must be in the switch and it should be in the Start position. 3 Connect the battery posts to the two posts on the solenoid, either to the positive or negative post. 4 If the cart spins over, then your solenoid is not the issue. More items...
Why is my Yamaha golf cart not spinning?
The absence of a spin in this test could mean your Yamaha golf cart’s battery pack is failing. The controller is one major component that may have to be replaced. A faulty controller can stall the cart and the click you hear must be from the solenoid. Test the solenoid to see if it is functioning properly.
Why does my Yamaha golf cart not start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
Why does my gas golf cart not start?
Fuel Issues As you can imagine, lack of fuel is the most common reason that gasoline golf carts don't start. This issue is incredibly simple to fix in most cases – just add fuel to the cart and it will start again.
Where is the reset button on a Yamaha golf cart motor?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
Why did my golf cart just stopped working?
When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
How do I reset my Yamaha golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
Do Yamaha golf carts have fuses?
Fuse Box Location on Yamaha Carts Yamaha typically places the fuses on its golf carts in the same location for each model. This choice is designed to create a uniform style between each of these models that makes it easier to work on them without running into any complications.
Where are fuses in Yamaha golf cart?
The fuse box in a 2014 Yamaha golf cart is located on the left side of the controller. The wires are tied to the roof drain. In a G2 electric cart, the fuses are present on the rear inner fender. This is on the front of the driver's side of the cart.
Where is the solenoid located on a Yamaha gas golf cart?
1:0011:27Yamaha G29 Golf Cart Solenoid Replacement - YouTubeYouTubeStart of suggested clipEnd of suggested clipComing down to here under the seat and there's two little fasteners here and you just pop them outMoreComing down to here under the seat and there's two little fasteners here and you just pop them out flat head screwdriver pull it.
How do you troubleshoot a golf cart?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.
How do I know if my golf cart solenoid is bad?
The most common side effect on a gas golf cart is the starter failing to connect, resulting in the engine not turning over and a succession of useless tapping sounds. If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure.
How do you start a Yamaha golf cart?
1:412:58Yamaha Golf Car- Consumer - Operating Basics - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition during the key switch to the on. Position slowly press the accelerator pedal to disengageMorePosition during the key switch to the on. Position slowly press the accelerator pedal to disengage the farc brake and gently apply pressure to the accelerator pedal to increase the speed.
How do I know if my golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
What starts a gas golf cart?
In a gasoline-powered golf cart, the engine starts when you step on the gas pedal, and it shuts off when you take your foot off the gas. That feature helps save gas, cuts down on emissions and helps keep the course quiet, too.
How do I know if my golf cart solenoid is bad?
The most common side effect on a gas golf cart is the starter failing to connect, resulting in the engine not turning over and a succession of useless tapping sounds. If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure.
How do you test a fuel pump on a golf cart?
A simple way to determine the fuel flow is to remove the fuel hose at the carburetor and hold over a small container. Attempt to start the engine and if all is well, the fuel should spurt out with reasonable force in pulses as the crankcase pressure varies. We hope you've enjoyed out tutorial on golf cart fuel pumps.
How do you test a ignition switch on a golf cart?
Testing a Club Car Ignition SwitchFind the back and red wires on the back of your battery pack.Connect the black wire to the negative terminal and the red to the positive.Keep the cart turned off while you work on it.Check the wires with a probe meter while the cart is off – only one wire should have a charge.More items...
What to do if golf cart doesn't start?
If you find any moisture, you have to replace the plug. If the golf cart doesn’t start, you will want to clean the carburetor with some cleaning fluid. You can also take a look at the fuel bowl to check if it’s empty. If not, open and drain it.
Why won't my golf cart start?
Faulty brakes: Very often, faulty brakes are the reason why a golf cart won’t start. You should be able to adjust the breaks at home. However for more complicated repairs, it is better to pay a visit to your nearest professional mechanic.
What happens when a spark plug is taken out on a Yamaha golf cart?
You can check the oil for a possible contamination of gas.
Why does my golf cart keep turning but not starting?
Solenoid problems: A solenoid can wear out after using your golf cart regularly. A faulty solenoid can cause your golf cart to turnover but not start. Your golf cart solenoid is a coil of wire cylindrical in shape, but in reality it functions as magnet carrying electricity.
Why won't my Club Car Precedent Golf Cart start?
Club Car Precedent golf cart turns over but won’t start. A faulty spark plug, bad battery or low compression levels are the main reasons why a Club Car Precedent golf cart will turn over but not start. Lack of spark in the coil: in this case, you have to replace the coil if it doesn’t spark. Spark plug: Also look whether ...
Why is my golf cart starting with a key switch?
Key switch problems: Keyswitch issues is a common cause of golf cart starting problems as the key switch will wear out over time. You have to check the keyswitch area for any loose or broken piece of wiring. Be very careful while doing this since you might get a nasty shock.
Can a Yamaha G2 golf cart start?
Yamaha G2 golf cart turning over but not starting. A good spark, air and gas is usually sufficient to get a Yamaha G2 golf cart started. But if it’s not, then check out for a crack in the spacer of the carburetor. Next check if the ignition coils are connected to the two wires that are there. Then check for spark.
How to tell if a golf cart won't start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops ...
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
What causes a car to start when the spark plug is replaced?
If it sputters and tries to start, then the likely culprit is the fuel pump followed by the carburetor. The fuel pump on most gasoline powered carts usually has three hoses going to it.
How to tell if a battery is leaking?
It can begin with the batteries taking longer and longer to charge, and the charge they take, they don’t keep very long. Physical signs can include bulging sides, cracks or, in extreme cases, leaking battery acid. If the engine or motor turns over slowly, get out a multimeter and make this quick test.
How to check if a gas cart battery is charged?
First, you turn the key, press the pedal, and listen for a click. If nothing happens, it’s most likely an electrical issue. On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge.
What to do if a gas cart key switch fails?
There should be a reading or continuity between any combination. If this is a gasoline cart, set the switch to “ON” and take a reading between the terminals. There should be continuity. If the key switch fails any of these tests, it’s worn out and should be replaced.
Why is my Yamaha golf cart not moving?
The main cause of a Yamaha golf cart clicking but not moving, is a faulty controller or solenoid. The battery has to be checked first to see if it’s delivering the right voltage while in the idle state as well as when the pedal is pressed. There can be other reasons for the Yamaha golf cart not moving though you hear the click.
What to do if your G9 golf cart is not clicking?
If you find your G9 Yamaha golf cart not starting nor clicking, check the key components for damage. If you find the parts to in good condition, check the brushes in the starter/generator.
What is a faulty controller?
The controller is one major component that may have to be replaced. A faulty controller can stall the cart and the click you hear must be from the solenoid. Test the solenoid to see if it is functioning properly. You will require a multimeter, preferably a digital one, or a DVM for this.
How to check solenoid on G9 Yamaha?
The solenoid can be checked using an old screwdriver to jump the terminals. Your G9 Yamaha golf cart’s key must be in the start position. If the starter turns when you do this, your solenoid needs to be replaced. You must be careful while doing this crude test; there could be sparks when the two terminals touch.
Why is my solenoid not clicking?
The reason why the solenoid is not clicking could be that it is faulty or has no grounding. Experts recommend checking all wiring and cable connections to rule out this possibility. Batteries on your G16 Yamaha golf carts should raise sufficient power to reach the solenoid and the starter/generator.
