Insert the replacement lock cylinder into the door and secure it with its clip. Reattach the clips that connect the latch to the lock and the outer door handle. Paste the water shield back on the door using its own adhesive.
Full Answer
How do I replace the lock on my door lock?
The easiest way to replace the lock it to dill out the small rivet (red arrow) holding it to the plastic bracket mounted to the door. Release the small snap clip (yellow arrow) to fee the lock from the bracket.
Are there any problems with the Mk4 Golf door lock?
In some cases, a sticky micro-switch may cause issues with the MK4 Golf, GTI, GLI, Jetta, or B5 Passat door locks. If you’re overly angry about the door lock and smack the door – or slam it shut – things may suddenly start working. This would typically indicate a sticky micro-switch. However, it appears less common than the main culprit.
Are there any problems with the door lock on a Volkswagen?
A lot of Volkswagen’s that experience the door lock issues are in the 1999-2001 era. However, the issues aren’t limited to only those years. As explained in the introduction, it’s not just one problem like the doors not locking. There are all sorts of odd issues with the MK4 door locks.
Where is the door lock module located on a Mk4?
The door lock mechanism resides inside the door hidden behind the inner door panel and window regulator carrier. These parts will need to be removed in order to reach the MK4 door lock module. Initially, many suspected the door lock module issues were caused by sticky micro-switches inside the electronics portion of the module.
How do you fix a cylinder lock on a door?
0:221:44DIY - How to Change a Barrel or Cylinder Lock - YouTubeYouTubeStart of suggested clipEnd of suggested clipNext push the cylinder lock from behind while pulling from the front with the key. The key should beMoreNext push the cylinder lock from behind while pulling from the front with the key. The key should be turned slightly towards the opening position.
How do you open a Volkswagen door that won't open?
2:5410:06How to open VW door which won't open from inside and outsideYouTubeStart of suggested clipEnd of suggested clipSo either small screwdriver or the pic or whatever you want to use you need to lift this tab. ThisMoreSo either small screwdriver or the pic or whatever you want to use you need to lift this tab. This way that will release the cable.
How do you manually lock a VW Golf?
0:122:06How To Do Emergency Door Locking on a VW Golf MK5 - YouTubeYouTubeStart of suggested clipEnd of suggested clipThere we go. Now i'm going to zoom right in just in here we're going to place the key there's aMoreThere we go. Now i'm going to zoom right in just in here we're going to place the key there's a little red bit of plastic that we need to push in and that will actually lock the door.
How do you reset the central lock on a VW Golf?
1:122:37How to reset/re-program VW remote key, or change the battery (Audi ...YouTubeStart of suggested clipEnd of suggested clipAnd then under this plastic and reveal the key oh so what you do you press the Open button to openMoreAnd then under this plastic and reveal the key oh so what you do you press the Open button to open the door and then within a minute you saw opening the door with the key.
How do you open a VW rear door that is locked and won't open at all?
1:584:24How to open a VW door that won't open from inside OR outsideYouTubeStart of suggested clipEnd of suggested clipPosition just remove the cap the plastic cap covering the lock itself. Then pull the door open. AndMorePosition just remove the cap the plastic cap covering the lock itself. Then pull the door open. And you should be able to see that the black plug based on the end of the cable.
How do you fix a broken car door latch?
0:322:24How To Fix A Car Door That Won't Close Or Latch - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe way you'll get it to open up is you just grab the outside door handle right here and you pull itMoreThe way you'll get it to open up is you just grab the outside door handle right here and you pull it and you put your screwdriver right here and you push the screwdriver. Towards the vehicle this way.
How do I lock my VW Golf without a key?
Locking your Volkswagen without having to use the key is just as easy. Located on the door handle you should notice a small dimple. Just press it to lock the vehicle using Volkswagen Keyless Access.
Why is my Volkswagen not locking?
While there are many different things that can cause your power door locks to fail, the most common causes are: A bad door lock actuator/door lock solenoid. A bad door lock switch. A bad key fob (remote)
How do you open a golf door manually?
0:001:06Opening a VW Volkswagen GOLF via the hidden key hole lock - YouTubeYouTubeStart of suggested clipEnd of suggested clipBut when you put your key into the ignition then that will stop and then to put it back on. Again.MoreBut when you put your key into the ignition then that will stop and then to put it back on. Again. You just put it on from the top and then just clip it into place.
If you need to replace the door lock or door handle backing plate, you will need to first remove the door handle and door skin
Please see our articles on door handle removal and door skin removal for further assistance.
Project Photos
Figure 1 This photo illustrates the door skin off. Make sure the window is all the way up before beginning work. This will allow you to access the backing plate and lock (red arrow).
What is a VW MKIV door lock?
Unlike a basic mechanical door lock the VW MKIV uses an electro-mechanical device called a door-lock module or mechanism. It’s pretty standard tech on modern day cars, but it was relatively new during the MK4’s production. The door lock mechanism resides inside the door hidden behind the inner door panel and window regulator carrier.
Where are the micro switches on a MK4 door lock?
The above image shows three of the four micro-switches. The fourth is found within the mechanical portion of the door lock module. The part numbers for the MKIV micro-switches are as follows:
Is the MK4 door lock localized?
There are all sorts of odd issues with the MK4 door locks. It’s also not localized to one specific door, but rather may occur to any or multiple doors.
Is a door lock module too expensive?
The door lock modules really aren’t too expensive individually. However, the cost may add up if you’re needing to fix multiple doors, especially if you go to a repair shop. For the DIY crowd, you may simply follow the above linked instructions for removing and replacing the door lock module. The parts are as follows:
