Unbolt A/C condenser from radiator and support condenser with wire or heavy duty tie wraps Note: Do not discharge the A/C refrigerant. Support the A/C condenser with wire and avoid stretching or kinking the hoses. Remove radiator mounting bolts from both sides and slide radiator slightly to the rear
Full Answer
How hard is it to replace a radiator on a GTI?
Replacing the radiator on the GTI 4 is a fairly involved job that requires removing a lot of components on the car including basically the entire front section. If you take your time and begin by working on a cool car you will be fine.
How do you remove the a/C from the radiator?
In the lower left corner of the radiator disconnect the three electrical connections. Next remove the T30 Torx screw holding the A/C bracket to the radiator. Move back to the top side of the engine and disconnect the electrical connection on the right front of the lock carrier.
How do you drain the radiator on a Toyota Corolla?
Drain the radiator completely. Open the fluid reservoir to assist in draining. Disconnect the hose from the lower right side of the radiator. This is a quick disconnect fitting. Lift up the retaining pin and wiggle the connection off the radiator outlet. Make sure you replace the gasket inside before reattaching.
How do you remove a VW Golf radiator?
6:0311:59VW Golf MK4 2.0 Radiator Removal and Replacement - YouTubeYouTubeStart of suggested clipEnd of suggested clipOne two three and four fasteners. And we can go ahead and pull out the light and disconnect theMoreOne two three and four fasteners. And we can go ahead and pull out the light and disconnect the harness we pull the light out you got to undo the harness on the back.
How much does it cost to replace radiator in golf?
Remove and replace the radiator. Fill radiator with proper mixture of 50/50 coolant....Car2014 Volkswagen GolfL4-2.0L Turbo DieselServiceService typeCar Radiator ReplacementEstimateEstimate$1072.85Shop/Dealer PriceShop/Dealer Price$1293.00 - $1874.587 more columns
How much does it cost to replace a Volkswagen radiator?
The Best in Auto Repair The average cost for a Volkswagen Jetta radiator replacement is between $601 and $687. Labor costs are estimated between $329 and $415 while parts are priced at $272.
Does a VW Golf have a radiator?
Your Volkswagen Golf Radiator is situated in the front of the motor and makes use of cool air passing through the grille to lower the temperature of the liquid coolant.
How long does it take to replace a radiator?
The time it takes to replace a radiator varies from person to person. A professional mechanic should be able to get it done in 2 to 3 hours. A person doing it for the first time may have trouble locating the bolts and other parts, so, it could take up to 8 hours to do the job.
How do I fix a leaking car radiator?
2:083:12How to Fix a Leak in Your Car (Radiator) - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd in this case the next day it stopped leaking entirely no more drips the leaks fixed. So the nextMoreAnd in this case the next day it stopped leaking entirely no more drips the leaks fixed. So the next time your car starts dripping all over the place why not fix it yourself.
Can you replace a radiator yourself?
Replacing a radiator can take most of a day, but, with care and patience, it is is doable. In order to replace a radiator, you'll need to drain the old radiator, detach any the parts keeping it in place, remove it, install a new radiator, re-install any parts that were removed, and add coolant.
Is it worth fixing a radiator?
The radiator hoses, core and housing can develop small holes and broken sections if not maintained properly. Because the cooling system is vital to the health of your automobile, it is advisable to repair it yourself or get an auto mechanic to repair it for you as soon as possible when there are problems.
Can a radiator leak be repaired?
If it seems to be coming from a loose clamp, you can simply tighten it to stop the leak. And if it's coming from a radiator hose, you can replace it. But if it's clear the leak is in the radiator itself, you can typically fix it within minutes.
How much does a VW radiator cost?
VW radiator typically cost between $59.99 and $219.99.
How do you clean a VW radiator?
0:002:07How to Flush a Radiator - YouTubeYouTubeStart of suggested clipEnd of suggested clipPlace a drainage pan or other container beneath the drain cock opening on your radiator. And useMorePlace a drainage pan or other container beneath the drain cock opening on your radiator. And use gloves or pliers to open the drain cock on the bottom of your car's radiator.
Where is the radiator drain plug?
With the tray removed you will see the radiator drain plug on the lower left front of the car. Place a catch bucket or tray under the plug and open the drain plug. The fluid drains out a small spigot facing downward. Drain the radiator completely. Open the fluid reservoir to assist in draining.
How to cool down a cooling system?
Allow cooling system to cool down. Open the cap of cooling system slowly; turn a conventional coolant cap as far as the first detent and turn a screwed coolant cap approx. 1/2 turn and release the pressure. Wear protective gloves, protective clothing and eye protection.
Can you pour coolant into a bottle?
Wear protective gloves, protective clothing and eye protection. NEVER pour coolant into beverage bottles, cups, etc... Someone might accidentally pick that cup up and start to drink. If the coolant in the car is new there is no reason to replace it as long as you drain it into a clean container.
Can I replace a radiator hose on a GTI 4?
It will be easier and cheaper to replace a radiator hose or clamp than replacing the whole radiator. Replacing the radiator on the GTI 4 is a fairly involved job that requires removing a lot of components on the car including basically the entire front section.
Do you have to separate the fan and radiator when you remove the lock carrier?
The A/C lines are still connected so you will have to be prepared to support the A/C condenser and radiator when you remove the lock carrier. You will now be able to separate the fan, shroud and radiator from the condenser, leaving the condenser attached to the vehicle.