how to replace acid in golf cart battery

Take the suspect golf cart battery or batteries and drain approximately half of the fluid into a plastic or non-volatile container. Rinse off any of the acids that remain on the case, avoiding getting any water into the cells. Use Epsom salts to make a replacement for the drained battery acid.

Full Answer

How to repair golf cart batteries?

These are the steps to attempt a repair and refurbish golf cart batteries: Lift out the front seat to access the battery compartment. Since not all of your cart battery pack will go bad at the same time, you need to identify the failing cart batteries that have under-performing battery voltage and work on the bad ones only.

Can you use lithium batteries in a golf cart?

The most common lead-acid golf cart battery is a group-size GC2/GC8 battery. Therefore, if you choose a lithium battery that is the same size, such as BSLBATT’S 48V lithium golf cart battery, it will make for a much easier installation because it fits directly into your existing battery compartments with no tray modifications needed.

Can you recharge a golf cart battery with Epsom salt?

Some cart batteries are not too far gone and can be rejuvenated using Epsom salts. Note: Electric Golf carts will have 6,8, or 12-volt batteries. These are the steps to attempt a repair and refurbish golf cart batteries:

Can you put battery acid in golf cart batteries?

Do you ever add acid to a battery? Under normal operating conditions, you never need to add acid. Distilled water is recommended but tap water works just fine if distilled water is unavailable. Once filled, a battery will only need water added periodically.

Can you revive a battery with new acid?

Attach a battery trickle charger or a computerized smart charger to your old lead acid battery, and allow charging continuously for about a week to 10 days. The extremely slow charging rates dissolve the de-sulphation that kills the battery, and revives it back to being able to hold a usable charge.

Does Epsom salt help golf cart batteries?

Well, the battery acid in your cells may end up getting old and no longer holding a charge. When this happens, you can remove about half of it – as you have done already – and replace it with an Epsom salt and water mix. Salt is an electrolyte and will distribute electricity cells.

How do you clean battery acid on a golf cart?

0:413:38Cleaning Your Golf Cart Batteries with Baking Soda and Water - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe acid on the batteries. With the baking soda and water you want to do one cup baking soda perMoreThe acid on the batteries. With the baking soda and water you want to do one cup baking soda per gallon so as you can see here I don't have a lot here so what 8 ounces.

Can I add battery acid to my battery?

It's important to note that battery owners should never add sulfuric acid to their battery. During normal operation batteries will only consume water – and not sulfuric acid. When your battery's electrolyte is observed to be low, filling the battery with water will keep the battery healthy and safe for use.

How do you fix a battery that doesn't hold a charge?

Answer provided by. If jumpstarting your car battery doesn't fix your problem, your battery might be dead. But if it's not, you may be able to repair a car battery that won't hold a charge by performing a few tests, cleaning the cells, and reconditioning the battery.

Does aspirin help golf cart batteries?

the battery. It is a reasonably safe approach and usually good for one more engine turn. Be warned that adding aspirin will shorten the battery life, as the aspirin will react with the sulfuric acid to form acetic acid. Good for a boost, but bad for the innards of the battery.

Can you put vinegar in a car battery?

The chemical components inside the battery will react with the vinegar and cause severe harm to the battery. The battery might even fail to work when the vinegar is added; thus, you should be keen not to damage the battery with your own hands. However, vinegar is useful in cleaning corrosion on alkaline batteries.

How do you rejuvenate a battery?

You will need: distilled water, voltmeter, battery charger and syringe.Remove the battery and remove the rubber that protects the caps. ... Fill a battery with the distilled water and recharge it. ... You can also try to replace the acid inside a battery and mix a new acid with the distilled water.

Why do my golf cart batteries keep corroding?

The recharging process of batteries produces gassing as a result of the breakdown of oxygen and hydrogen gas. This is the primary factor that causes corrosion on your battery cables, terminals, and other battery related metal parts.

What do you spray on golf cart battery terminals?

What Is The Best Way To Clean Corroded Battery Terminals? The best way to clean corroded battery terminals is to take a bit of baking soda and mix it with warm water. Take that mixture and pour it over the terminal. Let the terminal sit for a few minutes, and you will notice quite a bit of bubbling going on.

What do you spray golf cart batteries with?

Grab some baking soda, and mix it with warm water. You don't want the mixture to be pasty, nor should it be pure liquid – somewhere in between is ideal. You will also need a toothbrush and a hose. Put your hose on a light setting, and start spraying off your batteries.

How do you bring a battery back to life?

Prepare a mixture of baking soda mixed in distilled water and by use of a funnel pour the solution into the cells of the battery. Once they are full, close the lids and shake the battery for a minute or two. The solution will cleanse the inside of the batteries. Once done empty the solution into another clean bucket.

How do you refurbish a lead acid battery?

Lead Acid Battery Reconditioning (Step-By-Step Guide)Mix the cleaning solution.Clean the battery of corrosion.Empty the battery cells.Clean the battery cells.Replace the battery electrolyte.Recharge the battery.Test battery voltage and loading.

How do you bring a dead sealed battery back to life?

0:0017:01How to Revive a dead 12V Sealed Lead Acid Battery - YouTubeYouTubeStart of suggested clipEnd of suggested clipToday we show you how to revive a sealed lead-acid battery. Using simple methods and some tricks.MoreToday we show you how to revive a sealed lead-acid battery. Using simple methods and some tricks.

How does Epsom salt fix a car battery?

Replace battery cell solution – Mix 4 cups of water with 4 ounces of Epsom salt. Stir until the water is clear. Boiled water speeds up the process but isn't necessary. With the funnel, refill the cells with the new electrolyte solution.

How to keep golf cart batteries charged?

Another good thing to have for your golf cart batteries is a watering system. Make sure you check the water level in your golf cart batteries monthly to make sure they are still saturated. ( always do this after your batteries are fully charged because if you check them and fill them before you charge them 100% you could over fill them and acid will leak out the top of the batteries while they charge and get all over your cart and in the garage or where ever you store the golf cart. Which is not good because battery acid will eat away at your concrete floor in the garage. Checkout Pete’s great deals on a new One point golf cart watering system to avoid over filling them and making a mess or getting battery acid on your cart, clothes or garage floor and do it with ease. ( In minutes – not an hour or more… weekends are meant to be spent with the family or watching the game not in the garage filling batteries… so get yours today!)

What to do if your golf cart battery hasn't taken a full charge?

If the battery has taken a charge, replace the cell caps and use your golf cart for a long ride and see how long the charge lasts.

How to clean a battery with acid?

Step 1: Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. Clean the battery with your paintbrush dipped in a baking soda solution. Rinse your battery with plain water, making certain none of the water gets into any of the cells.

Can you replace a golf cart battery?

If the ride and power is short lived it is still likely you will need to replace your golf cart battery. It is also quite possible that your golf cart battery charger is not charging properly. You will need a volt meter to check the power output of your battery charger.

How to tell if a golf cart battery is bad?

Symptoms of a failing battery or batteries could include the following: 1 You may notice the battery power and range decreasing over time. The range should be about 2 rounds of golf after charging back to the advertised voltage using a full trickle charge cycle. 2 A “Shutter” feels like you are running across a corduroy road or someone is tapping the brake rapidly. This is a classic sign of low voltage. If this is experienced, your cart may be low on charge, the charger may not be functioning properly or you may have a battery issue. Use a volt meter to measure each battery individually to isolate individual battery health. 3 On electric golf carts, the cart refusing to move at all on a charged set of batteries could be the speed controller not engaging, a faulty maintenance switch, or when the voltage falls below a preset value. 4 A deep cycle battery charge time takes twice as long to charge your batteries as it did when you first had a battery bank installed. As the battery bank ages, it will not hold a charge as well as it used to. The automatic charger has no way to know this and will continue to charge the battery bank trying to get to a full charge – meaning it will take a longer charge time for the batteries than normal.

What to do if battery is cracked?

If a battery is cracked and leaking acid, it should be replaced. With the cell caps removed, check the water level and ensure the battery plates in each battery cell are covered and not exposed. Add distilled water to any that are low. Replace the battery caps. Step 4.

How to clean battery terminals?

Clean the battery terminals posts using 2 tablespoons of baking soda mixed with a 1 quart of water. A Wire scratch brush does the job nicely (it looks like a metal bristle toothbrush). Do not allow any of the baking soda water to enter the battery. Rinse the battery thoroughly and air dry or use a paper towel.

What does it mean when your cart is low on charge?

This is a classic sign of low voltage. If this is experienced, your cart may be low on charge, the charger may not be functioning properly or you may have a battery issue.

How long does a deep cycle battery last?

Battery charging is performed when you are parked for the day. With proper maintenance, a deep cycle battery only lasts a set number of years before the plates get corroded over and are no longer efficient. Some cart batteries are not too far gone and can be rejuvenated using Epsom salts.

How many volts should a 6 volt battery charge?

If you do not have a hydrometer, use a multimeter instead. Measure across the terminals on each individual battery. On 6-volt batteries, you should have a battery charge of slightly over 6 volts, like 6.1 to 6.3. If you get a reading of something like 4.1, then one of the battery cells in this unit is bad or shorted.

What color is a fully charged battery?

Observe also the electrolyte color. A gray or brown coloration shows that the end of your battery life is nearing. If you do not have a hydrometer, use a multimeter instead.

How to deal with golf cart batteries?

The better way to deal with them is to rejuvenate golf cart batteries as it will save a lot of costs and is also an environmentally friendly way to live. There are simple steps in which the golf cart batteries are rebuilt. These steps should be followed in the same sequence to gain the right amount of revived battery power.

What is the difference between golf cart batteries and other vehicles?

The difference between the batteries of golf cars and that of other vehicles is that they do not need a lot of power. It just needs enough to work on smooth roads but for a longer time. The batteries used in the golf carts are mostly 6-volt lead batteries or 12-volt lead batteries.

How to clean a battery that is corroded?

First, put on the gloves and the goggles and mix two tablespoons of baking soda into water. Stir the mixture well. Now, use a paintbrush and dip it in the mix. Use this brush and solution to paint all over the battery where there are signs of corrosion.

How to clean a sandbag cart?

Step 1: The battery should be removed. Most of the cart batteries are placed under the front seat, and you will have to lift the seat up to remove the battery. This could be different for some other cart models who have a hinged seat which can be lifted straight to take the battery out. Step 2: Start with cleaning the battery.

How to charge a battery with a negative pole?

Connect to charge. Carefully connect the positive wire to the positive pole on the battery and the negative charge to the negative pole on the battery. Plug it in and then switch it on for charging after it is safely connected to the battery. Step 7: Leave it for the night. Check the charging level in the morning.

Can you walk too far with a golf cart?

If you are, then you must also use the golf cart to get around the course easily. No one wants to walk too far with all the heavy golf equipment at hand. Golf carts make it easy for golfers to navigate their way all over the course.

What type of battery do I need to run my golf cart?

Most electric golf carts operate with any deep cycle 36-volt or 48-volt battery system. Most golf carts arrive from the factory with lead acid 6 volt, 8 volt, or 12 volt batteries wired in series * to make a 36V or 48V system.

Step 2: Choose the same voltage of Dakota Lithium batteries

To upgrade your system to lithium choose the same voltage in Dakota Lithium. Your vehicle’s motor is happy with any voltage as long as it is the same. For example if your golf cart has been running on 36V built out of 6 X 6V lead acid golf cart batteries you can replace it with 3 X 12V Dakota Lithium Plus 60Ah batteries to make 36V.

Step 3: Determine the amperage rating on your motor controller

Please note: most golf cart owners can skip this step by using 12V DL+ 60 Ah batteries wired in series to make 36V or 48V battery systems ( golf cart wiring kit is available here ).

Step 4: What batteries do I need for my golf cart?

Now that you’ve got your voltage and motor controller rating handy, we can determine what batteries will best fit your vehicle.

Be The First to Know

Get access to exclusive deals, hear about new products before anyone else, and enjoy tips, tricks, and DIY hacks from our community of experts.