What is the horsepower of a Yamaha G19 motor?
Yamaha G19 & G22 Electric Motors. 505-1 19 spline motor, @ 48V 3250 RPM, Peak HP 7. Stock Speeds around 14 HP. 170-505-0001 505-1 19 spline motor, @ 48V 3250 RPM, Peak HP 7.
How to rebuild a Yamaha golf cart engine?
Replace the old pieces of the Yamaha golf cart with the new ones in the engine-rebuild kit. These pieces are the piston and its rings, the valves, carburetor parts, gaskets and the bearing and seals that are located around these pieces. Follow the instructions that come with the rebuild kit exactly.
How do you remove the motor from an electric golf cart?
Once all wires have been removed from the electric golf cart motor, you are ready to remove the motor. There are usually three or four small bolts holding the motor onto the differential. They are inserted outboard of the mounting flange through holes and then screw into the threads cut into holes around the motor case.
What is wrong with my 2000 Yamaha model g19e?
I need some help if anyone has any knowledge of a 2000 Yamaha Model G19E. Issue is when the cart is on it is not moving. First thought was batteries. Check voltage for each battery before and after charge cycle. all are average 8.2V per, the whole circuit is 48.4V. Even when key is off, same when key is on.
How do you remove the motor from a Yamaha golf cart?
1:473:39Yamaha G29 Golf Cart Controller and Motor replacement - YouTubeYouTubeStart of suggested clipEnd of suggested clipI was using a 10 millimeter closed. And wrench to take those off and this motor is a 7-horsepowerMoreI was using a 10 millimeter closed. And wrench to take those off and this motor is a 7-horsepower clearly labeled with the f1 f2 a1 a2 and you'll see on the wires match up however.
How do you change a electric motor on a golf cart?
3:169:45EZGO High Torque Electric Motor Swap | How To Install Golf Cart MotorYouTubeStart of suggested clipEnd of suggested clipOff while it's up in the air let's go ahead and we want to loosen and remove the rear shock thatMoreOff while it's up in the air let's go ahead and we want to loosen and remove the rear shock that gives you direct access. So you can unbolt it loosen everything and put it right out the side.
What kind of motor is in a Yamaha golf cart?
At 357cc and 11.4 horsepower, it is Yamaha's most fuel-efficient carburetor engine. The PowerTech AC enables muscular hill climbing and a smooth ride. At 48 volts, its output is 5.0kw (6.7hp) for up to 60 minutes before recharging.
Where is the reset button on Yamaha electric golf cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do I make my Yamaha electric golf cart go faster?
6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.
How do I know what engine is in my Yamaha golf cart?
It is likely located:Under the rear bumper on the frame; or.Under the seat where the floor board meets the motor compartment; or.Under driver side glove box.
How much horsepower does a Yamaha golf cart have?
11.4 horsepowerOur Yamaha-built engine brings you over 60 years of proven performance featuring a filterless oil system for ease of maintenance. At 357cc's, producing 11.4 horsepower, it's the most fuel efficient carbureted engine in the industry with all the great features built into the Drive2 line of cars.
How do I know what model my Yamaha golf cart is?
Usually found under the seat, under the driver side glove box area or on the chassis towards the rear of the golf cart. Under the bumper area usually. Once you have located this you can use the chart below to cross-reference those numbers and determine the year and model of your Yamaha Golf Cart.
Where are the fuses on a Yamaha electric golf cart?
Yamaha Golf Cart Fuse Box Location The fuse box in a 2014 Yamaha golf cart is located on the left side of the controller. The wires are tied to the roof drain. In a G2 electric cart, the fuses are present on the rear inner fender. This is on the front of the driver's side of the cart.
Where is the solenoid located on a Yamaha electric golf cart?
0:095:38Replace Solenoid in Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipCart um your solenoid could be located in a bunch of different places but almost always underneathMoreCart um your solenoid could be located in a bunch of different places but almost always underneath the seat.
How do you test an electric golf cart motor?
3:5410:28Testing 36 volt golf cart motor with 12 volt battery - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou just want to connect the two together with this again a2 to s1 with this jumper cable. And youMoreYou just want to connect the two together with this again a2 to s1 with this jumper cable. And you want to take the battery box or positive cable and put it on the s2.
How to put a car engine back together?
This will help you put the engine back together. Start by unscrewing the top portion which consists of the air filter, carburetor and the pieces around them. Unscrew the valves and the fuel pump next. Afterward, disconnect the rest of the engine pieces, including the crankshaft with the connecting rod.
How to deconstruct a car engine?
Strip the engine down to its basic components. Use an adjustable wrench to remove the bolts and a screwdriver to remove the screws. Take photos of the deconstruction of the engine with a digital camera. This will help you put the engine back together. Start by unscrewing the top portion which consists of the air filter, carburetor and the pieces around them. Unscrew the valves and the fuel pump next. Afterward, disconnect the rest of the engine pieces, including the crankshaft with the connecting rod.
Does a Yamaha golf cart break down?
Just like cars and motorcycles, Yamaha golf cart engines break down after extensive use. An engine rebuild kit is available for Yamaha golf carts, allowing you to replace the parts that need replacing when the engine fails.
