(VIDEO) How to Change Your Golf Cart Batteries – A Step by Step Guide
- Disconnect Charger and Turn Key to OFF. Make certain the cart key is in the off position and the charger is not connected. ...
- Take a Picture and Make a Sketch. Remove the seat to get to the battery bay and then make a sketch that clearly labels the position and polarity of ...
- Disconnect Main Negative and Positive Cables. Disconnect the main negative terminal first, then the main positive. ...
- Remove Remaining Cables. Remove the remaining cables, careful to make sure the wrench doesn’t touch the terminals and give you a shocking new hairstyle.
- Remove Golf Cart Batteries. Using the battery strap remove each old battery. They are very heavy, so be careful when doing so. ...
- Clean the Battery Bay. First place some cardboard covered with a towel under the battery bay. Battery acid can permanently mark concrete and almost anything else.
- Install New Golf Cart Batteries
- Reconnect Battery Cables. Start reconnecting all the battery cables and we recommend using lock washers when doing so to prevent cables from loosening over time.
- Test Test Test. With everything done correctly you should test the operation of the lights and other electronics and verify that the cart will operate in forward and reverse ...
- Charge the New Golf Cart Batteries. Give the new batteries a full charge before using the cart and you’ll be back on the fairways/roads at full power.
Can you replace just one battery on a golf cart?
There will be times when it is appropriate to change only one or two batteries, but they occur only after you have replaced all of the batteries first. Replacing just one or two batteries in your golf cart battery pack can result in difficulties with charging and a shorter lifespan for the new ones you just purchased.
How to refurbish a golf cart battery step by step?
How to Repair Golf Cart Batteries
- Place safety first by wearing safety glasses and gloves when working with lead acid batteries. The acid is very corrosive and can cause serious chemical burns.
- Disconnect the battery cables using a crescent wrench and remove the battery from the golf cart. ...
- Mix a solution of 4 oz. ...
- Use a three-phase battery charger to recharge the battery. ...
How to rejuvenate your old golf cart batteries?
Step-by-Step Guide: Golf Cart Battery Reconditioning
- Safety goggles
- Rubber gloves
- Apron
- Distilled water
- Epsom salt
- Bucket
- Baking soda
- Flathead screw
- Wrench
- Battery Reconditioning Chargers
How to replace battery in a 48 volt golf cart?
Steps to Determine the Voltage of a Golf Cart:
- Raise the seat of your golf cart upwards and find out where the battery compartment is located.
- Now that you have identified the location, check how many holes or cells there are on a battery. ...
- Now, multiply this number by 2 to get the golf cart battery voltage. ...
- Multiply the golf cart battery voltage by the total number of golf cart batteries. ...
How do you change the batteries in a golf cart?
Now, follow these step-by-step directions and you'll be patting yourself on the back for a job well done.1) Disconnect Charger and Turn Key to OFF. ... 2) Take a Picture and Make a Sketch. ... 3) Disconnect Main Negative and Positive Cables. ... 4) Remove Remaining Cables. ... 5) Remove Golf Cart Batteries. ... 6) Clean the Battery Bay.More items...•
Do you have to change all golf cart batteries at the same time?
Let's discuss in detail. When it comes to changing the golf cart batteries, technically, you can change just one at a time. However, this is not advisable as it can cause permanent damage to each battery. When a battery has gone bad, you should change all of the batteries.
How much does it cost to replace the batteries in a golf cart?
Average Price of Golf Cart Batteries The average price of a golf cart battery replacement is going to be in the $800 to $1,500 range. Depending on the type of battery, it could even be in the $2,000 ballpark because powerful golf carts like a 72V need more expensive batteries installed.
What order do you disconnect golf cart batteries?
3:179:14How to Replace Your Golf Cart Batteries - YouTubeYouTubeStart of suggested clipEnd of suggested clipBut it can be depending on your brand it could be anywhere. The next step is to disconnect the mainMoreBut it can be depending on your brand it could be anywhere. The next step is to disconnect the main negative main positive and any accessories that are connected. You will be able to distinguish the
How can you tell if golf cart batteries are bad?
Here are six signs to look for when batteries need replacing.Charge Times Are Out of Hand. Just like any rechargeable battery, the repeated cycles of draining and charging your battery can take a toll on it. ... No “Get Up and Go” ... You See Visual Signs. ... Driving Until They Die. ... People Are Always Running The Radio.
How many years will golf cart batteries last?
That all being said, properly maintained battery packs in fleet carts tend to last about 4-6 years while private owners tend to get about 6-10 years out of their battery packs. Other major factors include the type of options on the cart that may increase the draw from the battery pack.
How much water do I put in a golf cart battery?
After charging your battery is when you want to add water. Adding water after charging prevents acid from spilling over. You'll want to add water to 1/2 inch from the top of the battery.
How many batteries does a golf cart take?
How many batteries are in the average golf cart? The average golf cart needs 4 to 6 batteries to operate correctly. In rare cases, you'll find 8 batteries in a golf cart. Golf carts are powered by a total of either 36 volts or 48 volt.
What kind of batteries does a golf cart use?
The majority of golf carts driven today use a 6-volt golf cart battery, which is why most online searches for golf cart batteries tend to take you straight to 6v options.
Do I need to reset car after changing battery?
Yes. You will need to reset your settings. Usually the dealer can do it free of charge but no promises. If you take a battery off and put a new one on, if there was anything hooked up the the battery, i.e. the hose you are speaking of, reinstall it.
How do you hook up 4 12-volt golf cart batteries?
0:423:39Using 12v Batteries in a 48v Golf Cart, instead of 8 / 6 volt ... - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd then positive to negative positive to negative positive to negative and then positive to theMoreAnd then positive to negative positive to negative positive to negative and then positive to the motor and by hooking them up in series you simply add up the volts.
Do I need to disconnect both battery terminals?
What is this? It is a good practice to always disconnect your negative battery terminal first, to minimize the risk of sparks that can lead to car electronics damage and battery explosion. Once you have located the negative terminal, use the wrench to free the nut that tightens the terminal.
Do you have to replace all batteries at once?
Do I have to change all the batteries at the same time? A. We do recommend changing all batteries in a unit at the same time. A partially used battery will drain energy from a new one, reducing the total amount of battery power available.
Can you mix new golf cart batteries with old ones?
Generally, mixing old and new batteries is not recommended due to possible issues with performance and safety. No matter what type of battery you use and the brand manufacturer, all batteries will eventually lose their electrical capacity as they age.
Can you charge one battery at a time on a golf cart?
Ideally, your charger will match your batteries individual voltage and you can charge them one at a time, just like so. There is no need to disconnect battery cables, you'll simply be sending low amp voltage into one battery at a time.
How often do I need to put water in my golf cart batteries?
Always fill the batteries after charging. The typical schedule is about once every 30 days, but this may vary by several days depending on your specific situation. When filling the batteries, add just enough water to bring it 1/4 inch to 1/8 inch shy of the indicator ring to prevent overfilling.
What color is corrosion block?
The best on the market for any alloy is called exactly that “Corrosion Block”. It comes in a tail narrow aerosol can that is blue, silver and white in color. After you thoroughly apply to the frame rails that come in contact with the golf cart batteries you are ready to install the new batteries.
Do golf cart batteries need to be replaced?
Golf cart batteries are heavy, so the less you have to handle them the better. You may need to replace the golf cart battery hold downs as they tend to rot out from years of battery acid leaking on them.
Does Battery Pete take pictures?
Even Battery Pete’s team takes pictures before a project like this. It is so easy to forget where “that wire” goes, especially if you get side tracked once you start this job. Everyone on the planet walks around with a camera in their hand these days – use it! You will thank yourself later when you need to reference something during the install.
How To Change A Golf Cart Battery
In this article, we’re going to provide a detailed guide about how to install a golf cart battery safely. don’t worry It’s a very easy task and even a beginner can do it without any difficulty.
Tools Required For Replacing Cart Battery
To replace your golf cart battery, you’ll need some of these basic tools:
A Step-by-Step Guide About How To Change A Golf Cart Battery
Follow each of these steps carefully and install your batteries. In the end, you’ll be patting yourself for performing this job efficiently.
How To Make Batteries Last Longer?
There are a number of ways by which you can take care of the battery of your golf cart. Below we’ve mentioned some tips and basic rules to keep your battery safe and efficient for a long time.
FAQs – Frequently Asked Questions
For seeking optimal longevity, a battery with a high ampere capacity will hold a long charge. If you keep it clean and maintained, then its lifespan can be at least five years.
How many volts does a golf cart battery have?
Now, just because a battery pack displays 48 volts or more after a full charge does not mean they’re good. The real test would be to test them after they have been used for a few miles. The reason is that a deep cycle golf cart battery will not exhibit signs of needing replacement until after they are fully discharged.
How many volts does a battery pack have?
Typically, a charged battery pack will have 2-3 volts higher on a charger than its rated voltage. For example, a 48 volt system will have 51 to 52 volts after a full charge. We can test this by using a Volt Meter. Now, just because a battery pack displays 48 volts or more after a full charge does not mean they’re good.
Why is my electric golf cart not going fast?
3) Your Golf Cart does not accelerate as fast as it used to. Electric Golf Carts are known for being fast and having acceleration power. However, the day you start to feel your electric golf cart being slower to reach top speed is typically a sign of your batteries needing to be replaced. Also, another sign may be that it has trouble climbing hills ...
How far can a golf cart go on a single charge?
Most Golf Carts can travel at least 7 miles or more on a single charge. However, if you are used to playing golf with no battery charge issues, but then one day you start to notice you can barely finish nine holes without having to limp home, then this could very easily be a sign of weak batteries.
What happens if a battery goes bad?
Batteries that are going bad will expand and have bulges on the battery cases themselves. Also, batteries will be prone to leaking acid out of the case when they are on their last leg.
Is it good to test a battery pack?
So once the batteries are fully discharged (used for several miles of driving), it is good to test the total battery voltage and each individual battery. A weak battery pack can sometimes be indicative of one individual battery being bad.
Do batteries hold a charge?
As the batteries age, they will not hold a charge as well as they used to. Unfortunately the charger will not know that, so the charger will continue to charge the batteries thinking they will eventually get to a full charge which means it will take longer to charge the batteries than normal.
Why does my golf cart have a low speed?
Once your batteries begin to age and start lose their power and the amount they can exert for your golf cart, this can cause a decrease in acceleration and in speed. Your golf cart requires a certain amount of “juice” aka amperage in order to produce the amount of speed you have grown accustomed to; older batteries will be unable to produce this power due to the amount of resistance placed on the batteries, resulting in a slower golf cart. You may be experiencing a decrease in your acceleration if:
What to do if your golf cart has a battery leak?
If you suspect you have a battery acid leak, it is extremely important to replace all of the batteries and clean the acid away from any component of your golf cart it may have leaked on.
Why does my golf cart lag?
You are likely to experience a lag in acceleration and an underwhelming amount of speed if your batteries are imbalanced . If you have replaced all of the batteries and you are still noticing an imbalance in the power of your golf cart and the batteries, a voltage test can be done to pick out the specific battery that is causing the issue.
Why do batteries leak?
With age, even in your batteries, comes expansion and sometimes leaking. As your batteries wear down and age they will expand within their casings. This expansion will allow the acid from the batteries to leak out through the cracks in the casings or caps. If you begin to notice liquid around your battery pack or in that general area, it could certainly be battery acid and time to change your batteries. Battery acid also has its dangers and should be taken seriously; these include but are not limited to:
How long does it take for a golf cart to charge?
For instance, if your golf cart normally takes 5 hours to fully charge and now it is taking 8 hours or 10 hours, it is most likely time for new batteries.
Why do newer batteries burn out?
Due to the charging issues that result from just replacing the batteries that “need” it , the newer batteries will accept the charge and finish faster than the older batteries, resulting in the newer batteries overcharging and burning out long before they should.
Why do older batteries take longer to charge?
Older batteries will experience an increase in the amount of time it takes for them to reach a full charge. The charger cannot differentiate between new batteries and old batteries and will continuously charge until the batteries have reached their full charge, resulting in a longer charge time for older batteries.
