go to the local vw dealer or jobber who specializes in german parts. you need the rocker arm and the cover plate for the end of the tranny. remove the clutch cable from the arm, remove the end plate and you'll see the rocker arm, unclip the shaft, remove old rocker arm, and replace. should cost a maximum of $30-40 (can)
Full Answer
How long does it take to change a clutch on a VW Golf?
I've had quotes prior to DIY replacement and they were anywhere from 7-8 hours. I did it in less time than that.
How much does it cost to replace clutch in golf?
The average clutch replacement can start around $500 and increase to $1000 or more, depending on the type of clutch kit used and your driving style.
How do you remove and replace a clutch to a stand engine?
8:2832:00How to Replace a Clutch in your Car or Truck (Full DIY Guide) - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd then unscrewing it the rest of the way by hand finally break that last bolt free but don'tMoreAnd then unscrewing it the rest of the way by hand finally break that last bolt free but don't unscrew it all the way remove this wrench. And then we want to loosen the bolt about halfway.
How do you change a clutch on a golf 1?
7:0815:53Clutch Replacement Guide | Golf MK1 Build - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe topx mark on the flywheel then there's the groove and there's the arrow going into the groove.MoreThe topx mark on the flywheel then there's the groove and there's the arrow going into the groove. Then you know the timing is on point. And now we're free to take out the gearbox.
How much does a clutch cost VW Golf?
Summary. The average UK clutch replacement cost is around £500 - £600, but it can range from £450 to £1,000+. It's a complex repair because all the parts are buried deep within the engine, including the flywheel which often needs replacing at the same time.
How much does VW clutch replacement cost?
The Best in Auto Repair The average cost for a Volkswagen Jetta clutch replacement is between $660 and $833. Labor costs are estimated between $660 and $833.
Can I change my clutch myself?
If you are sure that your clutch has worn out beyond repair then you can potentially replace the clutch yourself at home. It is possible, but it is a relatively lengthy and complicated procedure. There are several fiddly steps where there is a wide scope for things to go wrong.
Can you install a clutch without an alignment tool?
Installing a clutch with a clutch alignment tool is definitely preferred, and in some cases may be required. But for many installs, a little ingenuity is all you need to install your clutch without relying on tools you don't need.
How difficult is replacing a clutch?
2:234:03How to Replace a Clutch in Your Car - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt right in the clutch part so that it fits in snugly. And tighten all the bolts on the clutch. AndMoreIt right in the clutch part so that it fits in snugly. And tighten all the bolts on the clutch. And now comes the hard part you got a wiggle the transmission to fit on it can be a real pain.
Which side of clutch goes toward flywheel?
It is always the more 'flat' side of the disc that goes against the flywheel. The PP has more of a cavity in the middle for the spring section on the disc. If you try to put it in backwards the spring section of the disc will contact the flywheel before the disc friction material does.
How do you remove a golf gearbox?
13:1120:36How To Remove Transmission on VW GOLF JETTA MK3. Part ... - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd to remove turned do the transaxle. From the engine. There is a couple bolts on top of theMoreAnd to remove turned do the transaxle. From the engine. There is a couple bolts on top of the transmission housing as you remember well ready remove the starter. And it's another two longboats.
How does VW clutch work?
1:366:47Clutch, How does it work? - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf an external force presses against the clutch disc the clutch disc also will turn with theMoreIf an external force presses against the clutch disc the clutch disc also will turn with the flywheel due to the frictional force the input shaft of the transmission is connected to the disc.
Ed Paje
If you're asking this question, I two assumptions 1) that it's your first time because clutch replacement procedure is generally the same as any make of vehicle. It requires allen and 12pt bits (spline drive) so you can remove the starter, bell housing, CV joints and specially a 30mm x 6pt x 1/2 deep socket.
Anonymous
There is a light cover in front of the battery... take this off and then look for the metal clamps holding the light housing in. (I say clamps, but they're more like glorified paper clips on either side of the fixture.) Press in on each side, pushing the clamps towards each other and pull the fixture out.
Anonymous
On the inside trim, you can remove screws that are by the door handle, arm rest, under door and side of door and then gently pull back on the panel as there will also be retaining clips attached and you don't want to break them. You'll need to lift the door panel upwards in order to get it off the window ledge.
Anonymous
"2 safe" means that your radio was in safe mode, and then the code was improperly entered 2 times. you either need to disconnect your battery and leave it for up to 4 hours (i've been told), or leave your key in the ignition for around an hour. once it comes out of "2 safe" mode, then it will just say SAFE and give you the numbers 1-0-0-0.
Colin Stickland
if it works leave well alone,lots of cars appear noisey in reverse with a manual gearbox