How to change rear springs / rear coil springs on VW GOLF 4 (1J1)
[TUTORIAL AUTODOC]- Step 1. Secure the wheels with chocks.
- Step 2. Loosen the wheel mounting bolts.Use wheel impact socket
- 17.
- Step 3. Raise the rear of the car and secure on supports.
- Step 4. Unscrew the wheel bolts. To avoid injury, hold the wheel while unscrewing the fastening bolts. ...
Full Answer
Can I replace a coil spring myself?
Remove the coil spring. You may need to push or pry down on the control arm to do so. Remove the old coil from the compressor and compress the new spring. Install the new spring in its pocket, making sure both upper and lower “tails" are properly seated.
How do you replace rear springs?
0:063:04How to DIY replace the rear springs - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou have to counter hold it from the rear. And then zip it up. Once it's loosened you can pull itMoreYou have to counter hold it from the rear. And then zip it up. Once it's loosened you can pull it out now if it's under tension that means that it's being pressed on by the lower control arm.
How do you change a coil spring?
0:3812:33How to Replace a Broken Coil Spring - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo we're gonna have to remove it and pop this shock absorber out in order to release the tensionMoreSo we're gonna have to remove it and pop this shock absorber out in order to release the tension here just spray that down with some PB. Blaster. Now in order to get the tension off the shock.
How much does it cost to replace a coil spring on a car UK?
Coil springs are always replaced per axle. Prices start at £27 per piece, but installation costs for labour and skill to install these properly usually falls between £80 – £150 range for one side.
How hard is it to change a coil spring?
We found the average front coil spring replacement job can take anywhere from 1 to 3 hours, and on average take 2 hours. Rear coil springs tend to take between 1 to 1.5 hours.
Can I drive with a broken rear coil spring?
No. It is not recommended. A damaged or collapsed spring can cause sagging and noise and affect alignment angles. While you can still drive, the ride will be rough and the car will be difficult to control in an emergency.
How do you change a coil spring without a compressor?
1:057:26How to Replace Coil Springs Without Compressors | Ford F150 - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo you'll either want to put your jack stand and Jack under your other beam here and or underneathMoreSo you'll either want to put your jack stand and Jack under your other beam here and or underneath one of the frame rails in the back but as long as it's not the way this you should be fine.
How do you remove a coil spring?
6:1510:28How to Remove / Replace a Coil Spring on a Coil Over Suspension ...YouTubeStart of suggested clipEnd of suggested clipSo to remove these clamps from the coil spring you would basically just do the reverse of what youMoreSo to remove these clamps from the coil spring you would basically just do the reverse of what you did to compress it so just work from side to side slackening them gradually.
Is it hard to replace springs?
Installing lowering springs refers to the process of customizing your car's suspension, enabling it to ride closer to the ground. The process is not difficult, so anyone with garage access and a little know-how can accomplish this modification.
Is a broken coil spring an MOT failure?
The coil spring should be rejected if it is cracked, fractured, or corroded such that the cross sectional area is reduced and the spring seriously weakened. If the spring mounting is cracked, fractured, loose, or seriously weakened by damage or corrosion, it should be rejected.New UK MOT Regulations - Kilenhttps://www.kilensprings.com › news › _news_detailhttps://www.kilensprings.com › news › _news_detailSearch for: Is a broken coil spring an MOT failure?
What causes rear coil springs to break?
Even perfectly-manufactured rear springs weaken over time from doing their job–flexing while bearing loads. Flaws in manufacturing and the fatiguing process greatly accelerate the normal process, causing rear coil springs to break.Why Do My Audi, BMW, Mercedes, Volvo Coil Springs Break?https://atlanticmotorcar.com › casestudies › why-do-my-a...https://atlanticmotorcar.com › casestudies › why-do-my-a...Search for: What causes rear coil springs to break?
How do I know if my coil spring is broken?
If your car has a broken coil spring you'll probably hear clunking, knocking noises when you drive over rough or uneven ground. A broken coil causes mis-alignment, meaning your car's suspension angles of travel are altered, causing components to scrape or knock against each other.Broken coil spring causes can I still drive my car | startrescue.co.ukhttps://www.startrescue.co.uk › car-servicing-and-repairshttps://www.startrescue.co.uk › car-servicing-and-repairsSearch for: How do I know if my coil spring is broken?