How to upgrade club car DS speed?
How to Upgrade Club Car DS Speed 1 Get high-speed gears fitted in the golf cart at the rear end. 2 Replace the existing tires with bigger sized ones. 3 Upgrade the stock controller to a 400-amp controller. 4 Install a new motor with 2ga cables and a stock solenoid. 5 Fit copper bars on the F/R.
When did the club car DS Golf cart come out?
Club Car DS made in the years 1982 - 2000.5 will look like the golf cart pictured above. Club Car DS made in the years 2000.5 - present will look like the golf cart pictured above.
What does a DS Golf cart look like?
Club Car DS made in the years 1982 - 2000.5 will look like the golf cart pictured above. Two separate seat backs Uses a rubber coated pipe as seat armrests Silver aluminum roof supports
What are the speed codes on a golf cart?
What are Golf Cart Speed Codes? Code Number Effect on Golf Cart Speed Code 1 The lowest speed code that comes set by ... Speed Code 2 Increases the speed of the cart from def ... Speed Code 3 Increases the speed of the cart from eit ... Speed Code 4 Moves the cart at 19.7mph by raising the ... 1 more rows ...
Where is the speed sensor on a Club Car DS?
The speed sensor in a Club Car Precedent golf cart is located on the back of the motor. To remove the sensor, unplug the cables behind the motor. You can use a 5/16-inch socket to remove the pigtail connector and pop off the plastic housing that encases the speed sensor.
How do I change my Club Car DS speed code?
If you want to change your speed code, you will need to find a local golf cart dealer to change this speed setting for you. You could try to do this yourself, but would need an expensive Curtis handheld programmer. They usually charge a fee that can range from $75-$100.
Where is speed sensor on golf cart?
Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.
How do you remove the speed limiter on a Club Car?
0:040:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this leverMoreYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this lever you want to lift up and Bend and that pulls on the cable a little more.
How do you turn up the speed on a Club Car golf cart?
0:061:31Club Car Precedent Speed Increase SUPER EASY!!! - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf you turn it that way to the right or what appears to be counterclockwise. It slows it down. AndMoreIf you turn it that way to the right or what appears to be counterclockwise. It slows it down. And if you turn it that way or clockwise it speeds things up. Very.
Where is the speed magnet on a golf cart?
0:223:45How to make your Club Car go faster with a faster speed magnet - YouTubeYouTubeStart of suggested clipEnd of suggested clipOn this one. And we're going to make sure that's on the outer side where the magnets magnet's goingMoreOn this one. And we're going to make sure that's on the outer side where the magnets magnet's going to be so where your speed sensor is at uh make sure your golf cart is unplugged.
How do I test my club car speed controller?
How to Test Club Car Precedent Controller? To test a club car precedent controller, connect a voltmeter between the negative terminal of your cart's battery and the M terminal on the controller. Then push the pedal down and look for a clicking noise from the solenoid. Your batteries should read as full.
Why is my DS Club Car Slow?
The main reasons for a Club Car Precedent running slow is because of a weak battery, or faults with the MCOR, solenoid and throttle cable. Some of the other reasons the cart may slow down are: Solenoid contacts can get jammed as they wear out; experts call this 'welded solenoid'. The MCOR could be an issue.
How does a speed sensor work on a golf cart?
Magnetic Style Many golf cart motor speed sensors employ an electromagnetic power to “read” the motor rpm. Generally, there is a magnet present in the closed end of the motor as well as the sensor itself which reads how the magnet is reacting with the magnetic field inside the motor.
How do I turn off speed governor?
0:102:00How to remove your car's speed limiter como sacar limitacion de ...YouTubeStart of suggested clipEnd of suggested clipUp. So go to program vehicle strategy tune and then it'll ask you to turn the car on press ContinueMoreUp. So go to program vehicle strategy tune and then it'll ask you to turn the car on press Continue turn the car off press Continue remember that's not starting the car just turning it to ignition.
How do you remove the governor on a Club Car tempo?
Look behind the governor to find a small metal rod that's permanently attached to the club car and stretch your rubber band enough to connect it to that metal rod. Screw the plastic plate back in place. Once the plate is back in place, the governor is disabled.
How fast can a golf cart go without a governor?
A typical electric cart without an upgraded speed control tops out around 12 mph.
How fast can a PDS go?
This speed can be increased to 23mph by swapping the cable. The speed can go up to around 24 to 25mph with bigger tires.
What is a golf cart speed chip?
As the name indicates, golf cart speed chips increase the speed of the cart. They help the cart to go at a speed faster than its pre-programmed speed limit set in the electronic system. These speed chips can be used with only certain cart models and can be installed easily without any tool.
How to disable a governor?
Disable the governor by drilling its arm out and get the cart fitted with stock tires. Alternatively, manipulate the governor by pulling it tight and putting a zip tie over it or tightening the 10mm nut.
How to make a golf cart go faster?
The best way to make your golf cart go faster is by upgrading to larger tires, increasing the RPM, or by using speed chips and magnets. Most golf carts today are used for not just the game alone, but also activities like farming, racing, camping, hunting and a lot more. These activities require the carts ...
Why is my speed magnet not working on my golf cart?
One reason that the speed magnet may not be working on the golf cart is that it has been turned the wrong way. Another reason is that it could be functioning as a standard magnet . This can be confirmed by checking it with another magnet to determine the number of poles it has.
How fast is a magnet?
It can be installed in five to ten minutes without any adjustment to the controller or other parts. The magnet boosts the current speed by 6 to 7mph. Carts with Speed 3 setting will have a revised speed of 20 to 26mph while those with Speed 4 setting show an increased speed of 26 to 28mph.
What is the speed chip on a 2000 golf cart?
The EZ-Go speed chip or freedom chip can be used with 2000 model golf carts or later with electric power drive systems. This helps to increase the speed of the cart from 13.5mph to 19mph.
Description
Note: Please follow the directions below and provide your cart vin number and controller serial number. If the controller is not original to the cart we will absolutely need that new controller serial number. The code we send is based on that. Thank you.
Club Car Speed Code
Note: Please follow the directions below and provide your cart vin number and controller serial number. If the controller is not original to the cart we will absolutely need that new controller serial number. The code we send is based on that. Thank you.
How to get more speed out of golf cart?
Upgrading tires and increasing your tire size is by far one of the most economical and easiest ways to get more speed out of your golf cart. Equally applied, this is a great solution for both gas and electric golf carts. If you install a tire with a larger diameter on your golf cart, the end result is a higher top speed.
How fast can a golf cart go?
Most new and used golf carts are made to go a top speed of around 15 miles per hour . Although that is the perfect speed for most folks, there is an equal amount (if not more) of folks out there who are looking to increase their golf cart top speed and go faster than 20 MPH let's say.
How does a new battery work on a golf cart?
Simply put, most types of golf carts are designed to work with a range of different batteries. A new battery will increase a golf cart’s motor output. The result of the motor output increase is higher speed. Purchasing new batteries with a higher voltage maximum will increase your golf cart’s speed dramatically.
What is a series wound DC motor?
Series Wound DC Torque Motors are made with a larger field coil inside. A larger field coil inside of the motor , allows a larger magnetic field generation and holds the armature much more securely, thus producing greater torque. This is an excellent option if you're looking for more torque in your Club Car, EZGO or Yamaha golf cart, but are not so concerned about the speed.
What is torque in motors?
You know what 'speed' is, of course, but what is torque? Torque is the pulling power of the motor and is a function of current. So, basically, the higher the current, the more torque.
Do you need a lift kit for a golf cart?
Note: Depending on the size of the tire and the make/model of your golf cart, some golf carts will require a lift kit to accommodate the size of the new tires. If you are unsure whether you need a lift kit for your golf cart before replacing them, we have an excellent Resource that discusses this topic in more depth.
Is there a catch all solution to increasing golf cart speed?
A golf-cart weighed down by unnecessary clutter and debris is not a happy golf-cart! In closing, something to keep in mind is: There is no "catch-all" solution to increasing golf cart speed / golf cart power. There are many factors to consider such as, how the parts, pieces and changes interact with your golf cart.