how to reset golf cart motor

by Ebony Nitzsche Published 3 years ago Updated 2 years ago

The Simple Motor Reset Process.

Park your golf cart in an area where you feel comfortable working.
Turn off the cart and put it in park mode to keep it in place.
If you want, you can place cinder blocks in front of and behind the front wheels to prevent movement.
Locate the motor cover for your cart, which is usually at the back on many models.
Use a screwdriver to carefully open up the cover and expose it for easier workability.
Identify your main battery supply (usually the largest battery) on your motor.
Check around this supply for a small red button that may or may not be labeled “ Reset ”.

First, you'll want to reset your motor.

It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!Feb 12, 2018

Full Answer

How do I Reset my Electric golf cart?

Dec 13, 2020 · Otherwise, you can easily reset your engine by following these simple steps, which, thankfully, are pretty standard for most models: Park your golf cart in an area where you feel comfortable working. Turn off the cart and put it in park mode to keep it in place. If you want, you can place cinder ...

How do you reset a potentiometer on a golf cart?

Feb 11, 2022 · Take out your handy screw driver and begin working on removing the motor from its enclosure. In the vicinity of the primary battery supply, there should be a little reset button (which is often red in color). Press the reset button, and then replace the cover on the motor to complete the process.

How to fix a golf cart that won’t turn on?

Put the tow/run switch to run. Put forward/reverse switch to reverse. Put key switch to on. Lock the throttle pedal down with a second set of hands or object. The reverse buzzer will sound and go off in approximately 30 seconds. Leave the cart like that for 5 min to cause the OBC to reset.

How do you remove the motor from a golf cart?

Jun 29, 2017 · 6 volt golf cart batteries are on average – 220 Ah rated , 8 volt golf cart batteries are 165-170 Ah rated, and 12 volt golf cart batteries are 140-155Ah rated ( All based on the 20hr rate) …. so regardless how many batteries you wire together in a series… whatever the operation voltage of the battery bank it will be the Ah rating of the ...

Do all electric golf cart motors have a reset button?

Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.

Where is the reset button on my golf cart?

Locate the motor

Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.Jan 20, 2011

How do you reset the motor on a club cart?

Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.Nov 19, 2016

How do you troubleshoot a golf cart motor?

Ignition or Motor Issues

Look for a small red button located near the main power supply. Press the button and put your cart back together before hooking it up to charge. In many cases, this will solve the problem. If it doesn't, try removing the motor and testing it with a separate, fully charged battery.

How do you fix a golf cart that won't start?

First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.Feb 24, 2016

Where are the fuses located on a Club Car golf cart?

Finally, there is the 400-amp fuse, which is almost always located as near the power source or the battery as possible on your cart. Often, it is located on the positive or negative terminal of a battery to make it easier to access.

Why does my electric golf cart not move?

Battery is Dead

That's because battery failure is the most common cause of golf cart operational issues. The battery may be strong enough to “click” the starter but may not be enough to provide power for the rest of your travel. Place your battery on a charger for an appropriate time and remove it.

How long does an electric golf cart motor last?

How Long Does A Golf Cart Motor Last? A typical gas or electric golf cart motor is designed to last about 20 – 30 years if cared for properly. Despite this, many people do not take care of their golf cart motors.Feb 20, 2022

What can go wrong with an electric golf cart?

What Are the Most Common Problems With Electric Golf Carts?

Batteries That Break Down or Lose Charge. If your golf cart won't start, the first thing we suggest it checking your battery! ...
Solenoid Breakdowns. ...
Issues With the Ignition. ...
Speed Controller. ...
Direction Switch.

Aug 17, 2017

How do you fix a golf cart that won't move?

Reconnect or tighten any wires on your MCOR connection which may have worked loose—doing so may be enough to get your cart to start turning over. Look for any damage to wires on your MCOR connection—this damage can occur over time and may cause your cart to fail to turn over. Replace any damaged components or wires.

Why did my golf cart stop working?

When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.Apr 4, 2018

Can you reset an electric golf cart?

The motor is the last in a series of components that could fail. After determining that the cart’s batteries and charger are working properly, you can reset the motor to see if it runs. You must replace the motor if it has burnt out.

Why does my motor not spin?

If the motor does not spin, it might be burnt-out. Motor burn-out can result from excessive resistance from weight, grade, or poor traction. Uninstall the motor and inspect it for damaged bearings, field coils, or worn brushes. These parts can be replaced with right tools and some patience.

What is a golf cart potentiometer?

Inspect Potentiometer. The potentiometer is a small switch that controls the speed of the golf cart. Make sure that the potentiometer is not cracked and that the connections are secure.

What is a series motor?

A series motor has field and armature windings that have the power fed to them from the same source, either in series or parallel. A SePex motor, as the name indicates, is a motor that has a separately excited field and armature windings. These two motor functions are sent to the PDS or DCS giving greater control over the motor.

What to do if battery is too low?

If your batteries are too low for the charger to detect and it will not switch on, you’ll need to individually charge the batteries with a standard 12-volt battery charger. Once the batteries are at the minimum that the charger needs to see, there should be no problem charging them normally.

What is a golf cart?

Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... link to Club Car DS Wiring Diagrams 1981 To 2002.

Golf-FAQ.com