How long does a gas golf cart engine last?
However, their durability is the same as that of an electric vehicle, which is nice for those who are interested in gasoline or diesel golf carts. That said, some manufacturers claim that the average golf cart will last 30-40 years if the engine is properly maintained, repaired, or even replaced.
Can you rebuild a golf cart motor?
When the engine becomes difficult to start or you experience a loss of power and oil compression, you may need to rebuild the club car motor. By rebuilding the motor, you can avoid having to buy a new one. Disconnect the muffler, cables and any other component that attaches to the club cart motor.
What year is a G9 golf cart?
Yamaha began production of the Drive (G29) model in 2007 and continues to make the “Yamaha Drive” today....Yamaha Electric & Yamaha Gas Golf Cart Serial Numbers:Yamaha G1 to G11Yamaha's Longest Running Cart Model. The G-Series.JG5-100101G9 GAS1992JG5-200103G9 GAS1993JG5-300101G9 GAS199484 more rows
How do you clean golf cart engines?
0:502:41How to Detail a Golf Car - YouTubeYouTubeStart of suggested clipEnd of suggested clipWe recommend using a microfiber rag and mild soapy water to remove excess dirt and grit from yourMoreWe recommend using a microfiber rag and mild soapy water to remove excess dirt and grit from your windshield mirrors. And body of the golf car.
What engine is in a Yamaha golf cart?
At 357cc and 11.4 horsepower, it is Yamaha's most fuel-efficient carburetor engine. The PowerTech AC enables muscular hill climbing and a smooth ride. At 48 volts, its output is 5.0kw (6.7hp) for up to 60 minutes before recharging.
What motor is in ezgo golf cart?
Used EZGO GOLF CART 350 MCI 4 CYCLE GAS ENGINE EH352C.
What is the difference between a Yamaha G2 and G9?
The later G9 model is a virtual clone of the G2 except the G9 has a band of rubber trim around the dash compartment instead of the aluminum trim found on the G2 model. The serial number has a prefix that designates the model, starting with a 'J' followed by 1 more letter and 1 number, or just 2 numbers.
What G Series is my Yamaha golf cart?
The Yamaha G9 serial number location is underneath the seat towards the front of the golf cart. The Yamaha G11 Serial Number location is underneath the seat towards the rear of the golf cart. The Yamaha G14 & G16 serial numbers are located underneath the drivers side seat towards the front of the golf cart.
What is the difference between Yamaha drive and drive 2?
In 2017 Yamaha introduced the current model, the Drive2. The easiest way to distinguish the difference would be the White Yamaha Name on the side panels as opposed to the black Yamaha on the G29s and to look for the rear body being seperated into 3 different components.
Can you spray down a golf cart?
Wash the body of your cart Start by filling up one bucket with a water and soap mixture, followed by a second bucket with only water. Do an initial spray down of your golf cart with a hose to make sure any lose dirt is removed from the exterior of your cart.
Can I wax my golf cart?
Consider using a spray wax (we recommend Turtle's Wax and Dry) to make your cart shine. Use microfiber towels to dry your cart. Never use Windex or paper towels to clean your cart's windshield. Instead, use mild, soapy water and a microfiber towel.
Can you pressure wash a golf cart?
1:083:00Power Washing your Cart - Customcarts.ca - YouTubeYouTubeStart of suggested clipEnd of suggested clipThis area directly now washing the cover is fine but don't put the power washer nozzle right in itMoreThis area directly now washing the cover is fine but don't put the power washer nozzle right in it and just give it a good squeeze. Because you could do some damage to electrical components.
How do you remove a golf cart electric motor?
0:375:58EZGO RXV Golf Cart Motor Removal & Installation How-To - YouTubeYouTubeStart of suggested clipEnd of suggested clipTo remove this motor with us the connectors here we get it disassemble this wire to the front hereMoreTo remove this motor with us the connectors here we get it disassemble this wire to the front here we got to take off and they will just unbolt it slide it off.
How do you troubleshoot an electric EZ Go golf cart?
Things to Keep in Mind Before TroubleshootingEZGO golf cart batteries aren't perfect right away.Sticky accelerators are perfectly normal and can be fixed easily.Keep your cart stable.Make sure your charging wall socket isn't faulty.Keep your tire pressure stable.Troubleshooting the speed controller.
How do you remove a motor from a club car?
10:3013:29Replacing The Motor On a Club Car Precedent - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf you take those three bolts out and it twists like minded. Then you're ready to pull it out justMoreIf you take those three bolts out and it twists like minded. Then you're ready to pull it out just be careful don't drop it don't bang it on the end of the shaft.
What to check for when replacing gas lines?
Gas Lines. You are also going to want to check all the fuel lines coming from the gas tank and going into the engine. Check for leaks, brittleness, and holes. If these lines have issues, you will need to replace them. This is easy to do as they are held on with clamps.
What happens if your car oil is too dirty?
If it gets too dirty it can cause your engine to not get enough air and stall out. Check the oil level and make sure you have enough and that the color is light and not black. If the oil is blackened or dark, you need to change it. Get a new oil filter and enough oil to refill the engine.
Do you need to troubleshoot a golf cart?
If you have a golf cart you will eventually need to troubleshoot the golf cart motor. This is an easy thing to do quickly. Remember, it is a gas-powered engine that is not much different than your lawn mower or car. You are going to go through some of the same steps to troubleshoot the motor.
How to cool down a golf cart?
Procedure. Turn off the golf cart engine and allow it to cool for a couple of hours before you start working. This cooling down prevents damage to the cart and injury to yourself when you’re at work. Turn off the fuel-supply valve and remove the fuel line to prevent flooding of the fuel and other complications.
How to adjust carburetor on golf cart?
In most cases, you’ll need to adjust the jet pilot screw, perform a valve clearance adjustment and then clean the carburetor.
How to replace carburetor float?
Remove the carburetor and turn it upside down. Remove the nut that is used to secure the bowl on. Check the float for a puncture as this prevents the activation of the fuel cut-off needle valve. Replace the float if there is a puncture. Check for dirt accumulation in the needle valve.
Why does an EFI carb require more maintenance than an EFI?
The carb requires more maintenance than an EFI because of the cleaning and rebuilding of the carburetor involved.
Why does my carburetor flood on my golf cart?
The reason why a carburetor floods on a golf cart is usually due to a faulty fuel pump. The pump must be repaired or replaced accordingly. Seek professional assistance if required. This is usually due to the proximity of the fuel line to an exhaust manifold, a radiator hose or a heat source.
Where is the main jet on a 2 cycle engine?
The main jet in the carburetor diagram of a 4-cycle engine is located below the carburetor while the pilot jet is present on top of it. The needle valve and float pin are also housed under the carburetor.
How to remove cable from carburetor?
Remove the cable from the carburetor and cover its sheath opening using duct tape. To do this, make a small funnel with the tape and ensure that the wire sticks out from its middle. Loosen the nut that fixes the cable on to the mount housed on the motor just before its entry into the carburetor.
What happens if a golf cart runs out of gas?
If your golf carts runs out of gas, the engine will stop running. This in turn stalls the cart and makes it difficult to control the braking and steering. The fuel line will be filled with air causing the fuel injectors to get clogged or the fuel pump to get damaged.
How to test a golf cart fuel pump?
How to Test a Fuel Pump on a Golf Cart. Check the vacuum and fuel lines if the carburetor fails to get sufficient fuel. These lines are made of rubber and tend to deteriorate over time. Gas leaks or gas odors are signs of faulty fuel lines.
How many diaphragms are there in a gas engine?
There are two diaphragms that separate the inlet, outlet and pulse from one another. When the diaphragms start pulsing, the fuel is moved from the gas tank to the inlet chamber. From here, the fuel gets transferred to the outlet chamber and then to the other parts of the engine.
Do golf carts need fuel?
However, golf carts that are used extensively, carry heavy loads or operate in high altitudes may require a higher-octane fuel. But this can be detrimental to the life of the golf cart as mentioned above. To overcome the problems, you can consider fitting a fuel stabilizer to the golf cart.
Can you put an electric fuel pump on a golf cart?
Yes, it’s possible to install an electric fuel pump on a golf cart. The fuel pump must be powered from that side of the solenoid, which features the starter motor. In other words, it must be connected from the large post of the solenoid that goes towards the starter. This ensures that the pump operates only when the starter gets running.
Can you fix a golf cart on your own?
Under NO circumstances should you attempt to fix your golf cart on your own. Doing so is dangerous and could result in serious bodily harm. The information on this website has not been verified for accuracy and should only be used for general information purposes only. Use this information at your own risk. The author (s) and owner of of golfstorageguide.com are NOT trained electricians, mechanics or technicians. The webmaster of golfstorageguide.com and the author (s) is not responsible for any loss in damages, financial loss, personal injury, or death. By using the content on this website, you agree to the terms outlined in this disclaimer.
