Is there a maintenance kit for a Yamaha golf cart?
This Yamaha Golf Cart Maintenance Kit is designed for ALL GAS YAMAHA GOLF CARTS. Need to do some annual maintenance on your Yamaha golf cart? This tune-up kit has just what you need to keep your cart running smoothly for years to come.
What to do if your Yamaha golf cart is not moving?
You can move the belt a little in its groove and do the test again. The starter bushes can also be the reason for the golf cart not moving. Check the controller if you find that your Yamaha golf cart’s solenoid is not clicking after you have installed a new set of batteries.
How do I troubleshoot the 2008 Yamaha golf cart controller?
You can troubleshoot the 2008 Yamaha golf cart controller using the following steps: Press the accelerator and check whether the voltage increases up to the full voltage of the battery. If it does not increase, then there is a problem with the controller or the batteries. Examine the batteries and check if they are dead.
What to do if your G9 Yamaha golf cart won’t start?
Check the fuses and the fuse holder as well, to be doubly sure. If you find your G9 Yamaha golf cart not starting nor clicking, check the key components for damage. If you find the parts to in good condition, check the brushes in the starter/generator.
How do you put a golf cart in service mode?
0:151:07PRO TIP - Putting a Club Car DS Golf cart (Gas) into Maintenance ModeYouTubeStart of suggested clipEnd of suggested clipOkay here's a quick tip anytime you're working on a club car especially on the on the club card DXMoreOkay here's a quick tip anytime you're working on a club car especially on the on the club card DX there's a little yellow switch. Right here see when this is in neutral you push the gas.
How do you fix a gas golf cart that won't start?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
Why is my Yamaha golf cart not working?
If your cart is sluggish or won't start, the battery may need to be charged. If it is charged, but still not working properly, make sure the battery terminal connections are clean and secure. You can use a mixture of baking soda and water to clean the terminals by removing corrosion and other debris.
How do I make my golf cart idle?
Push the throttle cable toward the throttle valve body on the engine from the gas pedal position. Screw the throttle cable back in place on both the gas pedal and the throttle valve body on the engine. The golf cart will idle rather than shut off.
Where is the reset button on a Yamaha golf cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
What causes a gas golf cart to stop running?
Your golf cart may stop frequently while running in case of a faulty spark plug, defective TCI/carburetor, or improperly seated internal baffles and airbox lid. Sometimes, an empty or close-to-empty fuel filler, low battery charge, a binding linkage, or a bad fuel pump can cause a golf cart to stop running.
How do you fix a golf cart that won't move?
When the cart won't move, you have to be sure that the batteries are sending sufficient power to the circuit. You must check the fuse. Use the voltmeter to check the voltage at the key switch. In a cart with batteries rated at 48V, it must show 48V at the key switch.
How do you start a Yamaha electric golf cart?
1:412:58Yamaha Golf Car- Consumer - Operating Basics - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition during the key switch to the on. Position slowly press the accelerator pedal to disengageMorePosition during the key switch to the on. Position slowly press the accelerator pedal to disengage the farc brake and gently apply pressure to the accelerator pedal to increase the speed.
How do you know if your golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How can I make my gas golf cart go faster?
How to Make Your Gas-Powdered Golf Cart Faster [Updated, 2022]1 Use A Better Golf Cart Battery.2 Increase Torque.3 Upgrade the Golf Cart Motor.4 Install a Torque Converter.5 Install a Higher-Performance Clutch.6 Tweak The Governor.7 Install A Cold Air Intake.8 Get Bigger Golf Cart Tires.More items...
How do you bypass a micro switch on a golf cart?
You can bypass the reed switch in an EZGO golf cart by connecting the red wire of the reed switch to the white wire from the charger receptacles and to the red wire from the FRN micro switch.
How do you adjust the throttle on a gas golf cart?
Pull the spring that is present around the plastic piece located behind the shifter. Spin it until it falls back. Loosen the throttle cable present in the cable box to adjust the extent to which you can take it out of the housing. Press the accelerator so that the golf cart starts up and begins to idle.
Why is it important to maintain a golf cart?
When you own a golf cart, it's important to keep it maintained for a smoother and trouble-free ride. Regular golf cart maintenance will keep your golf cart running for a long time without any issues.
How to keep golf cart tires from wearing out?
Check Tires Pressure. Make sure to check the air pressure in your golf cart tires every week or so. If you inspect that air pressure is low, fill air in your tires right away. By doing this, you'll protect your golf cart tires from wearing out.
How to know if golf cart batteries are fully charged?
This way, you will always know your batteries are fully charged. 2. Check the Water Levels in Batteries. Keep a close eye on the water level in your batteries. If the water level is too low, you'll need to add water to bring them back up.
What do you need to know about street legal golf carts?
Inspect Lights and Mirrors. Street legal golf carts are equipped with a street legal light package and side mirrors. If your cart is street legal, do not forget to check turn signals, brake lights, headlights, and mirrors. If any of your lights are not working, read out the owner's manual to find the fuse location. 9.
Can you replace golf cart batteries?
When you need to replace your golf cart batteries, it is best to replace all of the batteries simultaneously. If you put a new battery with an older pack of batteries, then the older batteries will reduce the new battery's life. The older batteries take a longer time to charge than the new ones, and eventually, you will destroy the new ones by overcharging.
Do golf carts need lubrication?
Like other vehicles, golf carts also require regular suspension lubrication. The steering wheel rack and pinion also need to be greased regularly. The frequency of lubricating varies by model, so be sure to read the owner's manual for the required timeframe. If you ever notice oil on the ground near or around your golf cart, get underneath your cart and inspect or just connect with a mechanic.
What is solenoid in golf cart?
The solenoid is a wire acting as a magnet when carrying an electric current and is primarily found in gas powered golf carts rather than electric. This ignition is key – literally – for starting your engine.
Is it illegal to drive a golf cart with a mirror?
The mirrors to your golf cart seem unnecessary due to such little traffic on the golf lanes, but it is illegal to operate the vehicle with non-working mirrors. Observe the side mirrors and wing mirrors on the windshield, as well as making sure the thumbscrews are tightened so no visible obstruction is present.
Why is my Yamaha golf cart controller so hot?
The primary reason why a Yamaha golf cart controller gets too hot is because of overuse. When the golf cart is used for long periods of time, the controller can start overheating. The driving surface might also be a cause of heating. If driving on a straight and soft surface, the problem of heating should not occur.
Why is it important to troubleshoot a golf cart controller?
Troubleshooting the controller is extremely important for the golf cart’s smooth functioning. Generally, controllers face major issues only when there is a problem with wires or defects on the controller itself, such as marks or cracks.
What to do if your golf cart controller does not increase?
If it does not increase, then there is a problem with the controller or the batteries. Examine the batteries and check if they are dead. If dead, replace them. Examine the controller, as discussed in the previous sections. Remember to always consult a mechanic to have your golf cart controller repaired.
What are the problems with a Yamaha G22?
Yamaha G22 also faces similar problems like G9 and G16. Overheating, battery faults, wiring issues, voltage issues are some problems that might occur with your Yamaha G22. To avoid these problems, test the golf cart’s major components connected to the controller regularly.
How to test Yamaha G16?
To test the Yamaha g16’s speed controller, check the voltage reading while pressing the accelerator. Test other components such as the batteries, the charger, and the solenoid for their smooth functioning. If any of these components do not work as expected, then you need to replace them.
How to troubleshoot a G9 controller?
Here are some easy steps for troubleshooting the G9 controller: Check the controller’s body to locate any major defects such as cracks, scratches, or black marks. If these are found, then replace the controller immediately. If no major defects are found, then check the wiring.
Why is my golf cart not heating?
If driving on a straight and soft surface, the problem of heating should not occur. But, if driven on uneven or steep surfaces , there are chances of heating. Another reason could be the brakes. It is essential to check if the brakes are dragging while the golf cart controller is driven.
Why is my Yamaha golf cart not moving?
The main cause of a Yamaha golf cart clicking but not moving, is a faulty controller or solenoid. The battery has to be checked first to see if it’s delivering the right voltage while in the idle state as well as when the pedal is pressed. There can be other reasons for the Yamaha golf cart not moving though you hear the click.
How to check solenoid on G9 Yamaha?
The solenoid can be checked using an old screwdriver to jump the terminals. Your G9 Yamaha golf cart’s key must be in the start position. If the starter turns when you do this, your solenoid needs to be replaced. You must be careful while doing this crude test; there could be sparks when the two terminals touch.
What is a faulty controller?
The controller is one major component that may have to be replaced. A faulty controller can stall the cart and the click you hear must be from the solenoid. Test the solenoid to see if it is functioning properly. You will require a multimeter, preferably a digital one, or a DVM for this.
What to do if your G9 golf cart is not clicking?
If you find your G9 Yamaha golf cart not starting nor clicking, check the key components for damage. If you find the parts to in good condition, check the brushes in the starter/generator.
What are the settings on the M3?
The variable settings on the M3 allow a player to adjust the loft, lie, and face angles of the club, as well as create a variable fade or draw bias. Which can correct many swing or hit issues...
Why do you need a wiring diagram?
A clear wiring diagram will help in ensuring that the cables are properly reconnected if you remove them for testing. In the solenoid, for example, the contacts inside can get jammed over a period. These have to be checked, cleaned, and re-fixed. If it still doesn’t work it has to be replaced.
How fast can a Yamaha golf cart go?
With the right know-how, you can make your Yamaha cart go as fast as 20 to 25 miles per hour and find yourself zooming around the course after your tee shots. Remove any extra accessories or unnecessary pieces from your golf cart. These can include racks, windshields, roof accessories and baskets. These weigh the cart down and can restrict speed.
How to clean a cart?
Power clean your cart with a hose and soapy water. Be sure to remove any dirt and grime from the outside of the cart and especially from the tires. This will allow the cart to move at its most efficient. Check the gas pedal for a restricting bar.
How to stop a cart from compressing?
Check the gas pedal for a restricting bar. These are often placed under the pedal to stop you from compressing it totally and gaining maximum speed. These can be removed with a wrench or screwdriver. Place larger tires on your cart.