How to Fix an EZGO PDS that Runs Slow
- The speed sensor may be at fault. Push the golf cart and check if you hear a beep as there is resistance to the push. ...
- Broken wires or bad connections can slow down the cart. Replacing broken wires and fixing up bad or loose connections may solve the problem.
- If the cart has 22-inch tires and a freedom chip installed, there are chances that the already fitted speed controller is too small. ...
- The J1 pin on the controller may be loose. Fixing it back tightly in place is likely to be a solution.
- There could be a problem with the solenoid. Removing it and putting another one in place may resolve the problem.
- The microswitch on the floor under the floor mat near the ITS of the cart could be stuck. Releasing it may help the golf cart pick up speed.
Why is my electric golf cart running slow?
Why your EZGO Golf Cart is Running Slow with New Batteries
- A welded solenoid may cause the golf cart to run slowly. ...
- The speed controller may have a faulty voltage comparator. ...
- The ITS switch, foot control or forward/reverse switch may be malfunctioning. ...
- Check the distilled water levels in the battery and ensure that they are always 50% or more. ...
- Check the battery connections and ensure proper series wiring. ...
Why is my golf cart stalling?
Why is my Golf Cart Backfiring?
- The adjustment of the accelerator cable at the throttle plate has changed.
- The clutch has been subject to wear and tear.
- The exhaust system has poor quality gas.
- The exhaust system has accumulated unburned fuel.
- The micro-switch gets engaged with the ignition.
Which golf carts have the best running engine?
Best Golf Carts In 2021
- EZ-Go Express S4 (Best Golf Cart Overall)
- EZ Go Freedom RXV (Runner Up 1)
- Club Car Villager 2 (Runner Up 2)
- Yamaha Drive 2 PTV (Best Gas Golf Cart)
- Club Car Onward Lifted Four Passenger (Best Golf Cart for Off-Roading)
- Club Car Onward 6 Passenger (Best 6 Seater Golf Cart)
- Garia Via (Best Premium Golf Cart)
How do you speed up an electric golf cart?
Speed Controller Functions
- Battery Current Limiter: This protects the battery from excessive discharge. ...
- Motor Current Limiter: This can protect your vehicle controller and motor from damage if overloaded or stalled.
- Thermal Protection: This can protect your controller from overheating.
- Monitors the health and charge of your battery.
How do I adjust the speed on my EZ Go golf cart?
0:237:10Simple Adjusting of an E Z Go Golf Cart Governor - YouTubeYouTubeStart of suggested clipEnd of suggested clipEngine. One Titan the governor spring located in the engine of most golf carts to adjust your cartsMoreEngine. One Titan the governor spring located in the engine of most golf carts to adjust your carts top speed.
Can you adjust the speed on an electric golf cart?
Basically, an electric speed governor can be controlled by a tiny metal rod that's located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
Is there a speed limiter on golf cart?
Golf carts are governed to go anywhere from 12 to 14 miles per hour. But if you've got a few minutes, some simple mechanical know-how, and a wrench, you can double the speed of your cart and zip through your round.
How do you slow down a gas golf cart?
0:273:57How to Adjust Governor on Yamaha G29 Drive Gas Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo on your car you take the rear inspection panel off right underneath it here. You will have aMoreSo on your car you take the rear inspection panel off right underneath it here. You will have a spring actuated governor this is actually what speeds you up and slows you down.
How do you adjust the governor on a EZGO electric golf cart?
0:545:06How to Adjust an E Z Go Golf Cart Governor - WikiVideo - YouTubeYouTubeStart of suggested clipEnd of suggested clipTake off the plastic cover and set it aside with the seats. Follow the thickest cable coming fromMoreTake off the plastic cover and set it aside with the seats. Follow the thickest cable coming from the gas pedal until your find a small spring wrapped around a metal rod. This is the governor.
What is freedom mode on ezgo golf cart?
Flip the run-tow switch back to "tow" and then "run" to escape the diagnostic setting mode. This enables freedom mode and allows the cart to reach a maximum speed of 19 mph.
Can you put a governor on a golf cart?
Luckily, you don't have to stick with these standard speeds. Golf cart speed is often controlled by a device called a governor, and you can adjust the governor on a golf cart relatively easily to make the cart faster.
How do you take the governor off a golf cart?
0:000:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this leverMoreYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this lever you want to lift up and Bend and that pulls on the cable a little more.
Is there a governor on a golf cart?
What Is a Golf Cart Governor? The speed of a Golf cart is often controlled by a device called the governor, and you can adjust it for higher speed easily on your own. You can take your cart to new heights with this handy device.
How do you make a club car go slower?
Keep the Run/Tow switch to the 'Run' position. Now push the car manually. In a Club Car golf cart in which the speed sensor is working fine, it will slow the cart down.
What motor is in ezgo gas golf cart?
Engine Type For all models of the E-Z-Go, the engine is air cooled and produces 9 horsepower. The engine is a twin-cylinder unit, displacing 18 cubic inches.
How fast does an ezgo golf cart go?
And the fastest electric EZGO is the 2Five that goes 25 mph. And the fastest EZGO gasoline golf cart also only goes 19 mph.
What is an EZ Go golf cart?
EZ Go golf carts are designed for comfort and safety. Newer carts are powered by quiet electric motors and have a controller/sensor that regulates the speed of the cart. Many older carts have gasoline engines with a carburetor and throttle linkage. Aside from using the accelerator pedal to go faster or slower, you have a variety of options for adjusting the speed of EZ Go golf carts.
How to increase octane on EZ Go golf cart?
One way to increase the speed of a gasoline-powered EZ Go golf cart is to add an octane booster when you fill the gas tank. The cart will have more pickup and possibly gain as much as 5 mph. Another approach is to remove the throttle linkage governor on the side of the carburetor, allowing the accelerator pedal to depress farther. But this type of adjustment is limited because golf cart engines have an electronic cutoff that shuts the engine down at a certain rpm. Considering the short turning radius of golf carts, bypassing the cutoff feature on a gasoline-powered cart might compromise personal safety in some instances.
How fast can a golf cart go?
In addition, you notice a cart that’s powered by a 48-volt motor can reach speeds just below 20 mph. With the possible exception of a private cart race, most people prefer leisurely cart rides when playing a round of golf.
What happens when you stop a golf cart?
When you stop, a sensor in the controller automatically minimizes the flow of current to the motor. When you apply full throttle, the sensor allows the motor to receive the amperage that’s necessary for top speed. You can obtain a speed controller with a higher output through a golf cart accessory outlet. The overall gain in speed will vary ...
How to adjust EZ Go cart governor?
To adjust an EZ Go Cart Governor engine, start by removing the seat so that you can access the engine. Once the seat is off, remove the screws from the black plastic cover at the rear of the seat and then set the cover aside.
How to make a golf cart go faster?
Loosen the small nut and tighten the larger nut. The more you tighten the larger nut, the faster your cart will go. Start slowly, only tightening the nut a quarter turn to start. You can over-stress the engine if you try to run it too quickly, and it will skip and potentially burn out if you are too eager.
How to get a cart to move faster?
1. Remove the seat and plastic covering over the engine. Sometimes you'll need to remove screws while some models have seats that pop right out. Expose the engine so that you can get to work adjusting the motor. If you don't have a central governor spring, you can still get your cart to move a little faster.
How fast can a golf cart go?
Adjusting the governor can make your golf cart go 5–10 mph (8 .0–16.1 km/h) faster. If you do this to an E-Z-GO golf cart, you might be able to go from 15 mph (24 km/h) to 22 mph (35 km/h). It will only take about 5 minutes to do it. Steps.
How many screws are in a golf cart engine?
There should be five screws in most models. The engine is in the front of golf carts, underneath this panel. Take off the plastic cover and set it aside with the seats. ...
How to change the speed of a car?
Locate your clutch pedal and line. The clutch is the pedal (sometimes a handle near your knee) that you use to put the car into reverse or change speeds. You can adjust the clutch to send more gas to your engine, moving you faster. ...
How to raise the top speed of a golf cart?
To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly. If you cannot find this spring, you likely have a newer model that is more difficult to adjust, though this is rare. Lift up the seat. Remove the seat cousins, which hide the engine.
Why is my Ezgo golf cart so slow?
A EZGO golf cart can run slow on new batteries because of a faulty solenoid or insufficient water levels in the battery. A welded solenoid may cause the golf cart to run slowly. The cart will run properly when the solenoid is replaced. The speed controller may have a faulty voltage comparator. The entire speed controller will have to be changed ...
Why does my golf cart slow down?
If the cart takes off at normal speed and slows down even if it has new batteries, there may be a malfunctioning bearing encoder. Replacing the old one with a new encoder can serve as a fix to the problem. The golf cart might have a bad ITS that is indicated by a low battery pack voltage.
Why does my golf cart beep?
Push the golf cart and check if you hear a beep as there is resistance to the push. If you don’t, the sensor is faulty and calls for a replacement. You may want to first check that the battery pack voltage is correct under load is correct. Broken wires or bad connections can slow down the cart.
What to do if your golf cart is a resistor?
If the golf cart is a resistor cart, an upgrade to the resistor setup will often help to achieve the desired speed. The battery cables or other wires that are connected to the motor and other parts of the cart may be getting overheated. Consider making the appropriate cable or wire replacement with higher gauge wires.
Can a golf cart solenoid be replaced?
For such a case, the solenoid must be replaced. A low ampacity controller, small or faulty cables or weak batteries can slow down the golf cart. Checking them and replacing the defective components is likely to help you regain the speed of your golf cart.
How to make an EZGO golf cart go faster?
You can make your EZGO golf cart go much faster by adding more torque, upgrading the motor of or increasing the voltage of the batteries. Add more torque. Upgrade the motor. Increase the battery voltage. Decrease the load.
Why does my EZGO cart slow down?
Any engine that has been used for a long time will definitely slow down due to the dust and grime build-up on it. Cleaning the engine of your EZGO cart will help you regain the lost speed. This is a cost-effective and efficient method of boosting speed.
How to increase torque on EZGO golf cart?
Increasing the torque of your EZGO golf cart will automatically increase its speed. To increase the torque, you will have to increase the RPM of the motor. You can do this in 2 ways. Increase the voltage of your motor to get more RPM. Replace the motor with one which has a higher RPM.
How to make a 36V EZGO go faster?
You can make the 36V EZGO go faster by removing and replacing worn-out parts, replacing the tires and removing additional weight from the cart. Cleaning the engine can also increase the speed of the cart.
How to clean a golf cart?
Perform a power wash for the golf cart. Scrub the cart thoroughly to remove dirt and grime. Grime accumulated over a span of time can make your cart go slowly. Check for grime and small stones under the pedal and wash them off. Remove the stones using a screwdriver or a pair of pliers.
What happens when a cart is overloaded?
Every cart is designed to carry a certain load of weight. When the cart is overloaded, it will move at a slower pace. Try to keep the cart light and without much weight. This will definitely enhance the speed.
What are the main components of a golf cart?
Batteries are one of the main components of the cart. Old or corroded batteries can lower the performance of a golf cart. Hence it’s important to maintain them in the right condition.
Why your EZ GO Golf Cart Runs Slower than Normal?
When you’re EZ Go RXV or TXT golf cart starts running slow, it is usually because of a faulty speed sensor or battery issues. I have compiled a couple of these reasons below. They include the following:
How to Boost the Speed of Your Electric EZ Go Golf Cart
There are several methods for you to make your EZ Go electric golf cart go faster. I have detailed these methods in this section.
Conclusion
Having a faster golf cart can get you from point A to B a lot quicker. Whether you want to upgrade your cart from stock, or just fix the speed you have lost due to faulty batteries or add on parts, this is something that can easily be done.
How to Make EZ Go Electric Golf Cart Faster
Are you looking for a way to make your golf cart go faster? Do you have an issue with your current electric golf carts, such as the battery not holding enough charge or the speed sensor failing to pick up your speed accurately? Or perhaps you’ve added accessories such as a rear seat or custom rims to your golf cart and you’re finding that it is much slower than when it was brand new..
Why Does The EZ GO Golf Cart Run Slow?
When you trying to move away from a parking lot and your golf cart is not running at the normal speed, it may be one of these reasons.
Final Words
A golf cart can become faster in a lot of different ways, but these are the best ways by far. By doing one of the things on this list, no matter what it is you can get yourself a faster golf cart. These are ways to make your golf cart go faster without spending a lot of money or wasting a lot of time and doing it by yourself.
Gasoline Engines
Electric Motors
- Looking at the specifications for EZ Go electric golf carts, you notice a cart with a 36-volt motor is capable of 12 to 14 mph top speed. In addition, you notice a cart that’s powered by a 48-volt motor can reach speeds just below 20 mph. With the possible exception of a private cart race, most people prefer leisurely cart rides when playing a round of golf. At the risk of voiding the ma…
Speed Controllers
- Speed controllers regulate the output of the electric motor on a cart. The controller works similar to a voltage regulator by maintaining a specific supply of electrical current at all times. When you stop, a sensor in the controller automatically minimizes the flow of current to the motor. When you apply full throttle, the sensor allows the motor to receive the amperage that’s necessary for t…
Gearing and Chips
- If you drive the golf cart on sidewalks or streets, you might want a cart that’s capable of speeds not otherwise attainable by modifying the motor or speed controller. Changing the gear ratio by installing a higher gear and including a special electronic chip might produce speeds that have your passenger holding on. Again, the short turning radius typical of golf carts presents safety ri…