The throttle cable will have two nuts on it. Loosen those out so that you have about a cm left of thread on the end of the cable. Push the cable back down in the slot and tighten up the second nut so that the cable is held in place. Put the cover and floor mat back in place and take her out for a spin and enjoy your much speedier cart.
How do you speed up a golf cart?
There is a quick and relatively easy way to speed up your golf cart to make the holes fly by. Locate the engine. Club Car engines are housed under the passenger seat and can be accessed by simply pulling up on the seat and putting the seat into the foot well.
How fast can a golf cart go on the street?
Most people do not know that it is illegal for your golf cart to travel on the street at speeds over 25 MPH depending on the laws in the state. Check out our list of golf cart state laws to help determine what is and is not acceptable. Most Golf Carts are manufactured to go a max of 19.9 MPH with an average top speed of 14-15 MPH.
How to increase gear ratio in a gas powered golf cart?
If your cart has a differential, then the same physics apply, you can regear the differential to allow for a gear ratio that better suits you. When increasing power in your gas powered golf cart, it’s best to think of your gas motor as an air pump. The more efficiently it moves air, the more power it has.
How can I increase the speed of my club car?
If the Club Car is an IQ cart, you can get it upgraded to Speed Code 4 to get the maximum speed for the cart. It’s worth noting that the motor and controller may also have to be upgraded if it’s a series cart. The other option to increase the speed for an IQ cart is to get a new magnet installed below the speed controller.
How do you remove the speed limiter on a Club Car golf cart?
0:040:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this leverMoreYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this lever you want to lift up and Bend and that pulls on the cable a little more.
Why is my gas golf cart running slow?
Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
Why is my Club Car golf cart so slow?
The main reasons for a Club Car Precedent running slow is because of a weak battery, or faults with the MCOR, solenoid and throttle cable. Some of the other reasons the cart may slow down are: Solenoid contacts can get jammed as they wear out; experts call this 'welded solenoid'. The MCOR could be an issue.
What controls the speed on a gas golf cart?
The controller meters out current and voltage on your battery based on user input, whether that be a gas pedal, a throttle, or even pedals on a bicycle. With the controller you are able to control your acceleration and deceleration, as well as the speed at which your vehicle moves.
How do I make my Club Car faster?
6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.
How can I make my golf cart gas faster?
How to Make Your Gas-Powdered Golf Cart Faster [Updated, 2022]2.1 Upgrade the Golf Cart Motor.2.2 Install a Torque Converter.2.3 Install a Higher-Performance Clutch.2.4 Tweak The Governor.2.5 Install A Cold Air Intake.
How do you adjust the speed on a golf cart?
Tighten the governor spring located in the engine of most golf carts to adjust your cart's top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly.
Why does my gas golf cart go slow uphill?
A fully charged battery can create up to 24 volts. With a voltmeter, determine how much current you need by checking if your cart will move on flat ground with a dead battery. If your golf cart's speed drops significantly as it ascends an incline, your batteries may be weak and need replacement.
Where is the speed sensor located on a Club Car golf cart?
The speed sensor in a Club Car Precedent golf cart is located on the back of the motor. To remove the sensor, unplug the cables behind the motor. You can use a 5/16-inch socket to remove the pigtail connector and pop off the plastic housing that encases the speed sensor.
How do you adjust the governor on a gas club golf cart?
This governor can be adjusted by adjusting the cable nut which holds the cable to the throttle lever. By making the cable longer, you effectively prevent it from pulling back the throttle lever, producing a higher top speed for your golf cart.
Where is the governor on a club car?
0:061:28Where Is a Golf Cart Governor Located? - YouTubeYouTubeStart of suggested clipEnd of suggested clipWell a golf cart's governor located is actually down in the motor. Compartment. Some of them theseMoreWell a golf cart's governor located is actually down in the motor. Compartment. Some of them these electric ones nowadays. Actually the governor isn't a true governor. It is a control speed.
How do you change the governor on a club car?
If you find this rod, then your governor can be easily adjusted by accessing the cart's inner workings. Simply adjust the cable coming from this metal protrusion, turning the nut counterclockwise to make the cable longer, effectively adjusting the cart's governance to increase the overall speed.