Check the gas gauge to make sure that the club car has enough fuel in the tank to start. Fill the fuel tank with 1 gallon of gasoline to get the Club Car to start. Change the air filter inside the Club Car.
Full Answer
How do you start a club car with gas?
Turn the ignition key in the Club Car’s ignition. Check the gas gauge to make sure that the club car has enough fuel in the tank to start. Fill the fuel tank with 1 gallon of gasoline to get the Club Car to start. Change the air filter inside the Club Car.
Why won’t my golf cart start?
Keyswitch issues is a common cause of golf cart starting problems as the key switch will wear out over time You have to check the keyswitch area for any loose or broken piece of wiring.
How do you start a gas powered golf cart?
Golf carts are simple to use, and gas-powered golf carts are easy to start. Check to be sure the parking brake is engaged and switch the drive select lever to either forward or reverse, depending on which direction you want the gas-powered golf cart to go. Turn the key to the golf cart's "On" position.
How to troubleshoot a gasoline golf cart?
How Do You Troubleshoot a Gasoline Golf Cart? Spark Plugs. Let’s start with the spark plug. ... Is it all oily, fouled, or the gap bridged in any way? If this all... Fuel. Okay, the electrical system checks out and the engine still won’t start. Before screwing the spark plug back into... Air. Check ...
How do you fix a gas golf cart that won't start?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
Where is the motor reset button on a club car?
First, you'll want to reset your motor. Get out your handy screw driver and work to uncover the motor itself. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor.
How do you start a gas Club Car golf cart?
0:112:14How To Start a Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipForward neutral and reverse okay so what we do is we take the key. We move it to on we don't goMoreForward neutral and reverse okay so what we do is we take the key. We move it to on we don't go anywhere we're actually on a slight hill.
Is there a reset button on a Club Car golf cart?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
How do you know if your Club Car motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
Where are the fuses in a Club Car golf cart?
Club Car Golf Cart Fuse Box Location The fuse box in a 1997 Club Car can be found in the black electrical component box that is near the battery. In a 2004 Club Car Precedent, the fuses are located in two black plastic fuse holders that come with a molded support hole extension.
How do you bypass the ignition switch on a golf cart?
This process includes these steps:Turn off the ignition switch to minimize your risk of electrocution. ... Locate the wires for your cart's ignition switch. ... Use wire snips to cut these wires away from their connectors. ... Touch the engines together carefully to bypass the ignition switch and send power to your engine.More items...
How do you turn on a Club Car golf cart?
1:1310:29Consumer Golf Cart Operation and Maintenance Basics - YouTubeYouTubeStart of suggested clipEnd of suggested clipTo start the vehicle turn the key to the on position. And make sure nothing is in your immediate.MoreTo start the vehicle turn the key to the on position. And make sure nothing is in your immediate. Path. Check the vehicles direction by placing the forward reverse switch in the desired.
What do you do if your golf cart won't go?
Press the button and put your cart back together before hooking it up to charge. In many cases, this will solve the problem. If it doesn't, try removing the motor and testing it with a separate, fully charged battery. If nothing happens, the motor is probably burned out.
How do you bypass a computer on a Club Car?
2:544:33How to Bypass On Board Computer | Club Car Precedent Golf Cart | OBCYouTubeStart of suggested clipEnd of suggested clipWe can cut it. Real close to the OBC. And then put a ring terminal. As. I think that's a 5/16 holeMoreWe can cut it. Real close to the OBC. And then put a ring terminal. As. I think that's a 5/16 hole in it so it goes right over this tournament either way we've got to get this wire.
What do the lights mean on a Club Car charger?
The light begins flashing when the battery state of charge falls below 10%. Charging Confirmation. • The light will flash three times and the reverse buzzer simultaneously will sound three times to. indicate a battery charging session has begun.
How do you test a Club Car on a DS motor?
13:1937:53Club Car 48 Volt Powerdrive Testing 1995-2013 - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition place the red positive probe on the speed controller M minus terminal place the blackMorePosition place the red positive probe on the speed controller M minus terminal place the black negative probe on the s2 motor terminal your vom should display continuity.
What to do if your club car won't start?
If the Club Car will still will not start, use a battery tester to test the battery. Connect the positive and negative terminals of the battery tester to the positive and negative terminals on the battery. Look at the battery tester’s reading. The battery tester should read 12V on the display.
How to start a club car?
Fill the fuel tank with 1 gallon of gasoline to get the Club Car to start. Change the air filter inside the Club Car. This is located next to the engine. Use your fingers to pull the air filter out of the housing. Replace the air filter with a new one and try to start the Club Car. Dirty air filters can block the oxygen intake on the engine.
How to find the battery on a club car?
Lift the hood of the Club Car to find the battery. The battery has two terminal cables coming from it. The first terminal cable will be red and the other will be black. Make sure that the battery cables are connected properly. The red cord (positive) should be connected to the positive connection on the battery.
Why won't my golf cart start?
Your golf cart won’t start if there is a problem with the fuel, airflow, or electrical system. Any one of these areas can cause your golf cart to fail to start. Try these steps to troubleshoot and pinpoint the exact failure point.
How Do You Troubleshoot a Gasoline Golf Cart?
Check the fuel level, regardless of what the gauge says. I have seen a stuck fuel tank float baffle a mechanic for three hours while looking for a reason for a “full” tank not delivering the fuel.
How Do You Know When Golf Cart Batteries Are Going Bad?
As batteries start to lose their health and take longer to accelerate, you find that you can’t hit the top speed anymore or have problems climbing hills.
Why Does The Golf Cart Battery Drain When Everything Is Off?
Disconnect the negative battery cable ground wire and connect your multimeter set to measure the voltage between the battery terminal and the ground wire. If you’ve turned everything off and are still getting a reading, then you have a faulty component in the electrical system. At this point, we’ll need to start pulling fuses and disconnecting things one of the time to find out what is draining the battery.
How Do I Know If My Golf Cart Solenoid Is Bad?
Older golf carts used a series of solenoids to drive the cart forward and backward and set the speed of that motion.
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
How to move a gas golf cart?
Press down on the accelerator pedal, and the gas-powered golf cart will move.
Who can operate a golf cart?
Allow only qualified people, usually those with valid driver's licenses, to operate your golf cart.
What golf carts have parking brakes?
In many models of gas-powered golf carts, like the Yamaha YTF2, the parking brake releases automatically when you push the accelerator pedal.
Why do people use golf carts?
Because they are designed with enough cargo room to transport at least a couple of golf bags, some people even use them to haul small items. Golf carts are simple to use, and gas-powered golf carts are easy to start.
Can a golf cart jolt?
The golf cart may jolt unexpectedly. Never turn the drive select lever from forward to reverse while the cart is moving. You could damage the transmission. Do not operate your golf cart at night without using the headlights.
What is the key switch on a golf cart?
The key switch is the connector between the starter and the battery. Heavy use of the switch will eventually wear it out, so it's worth checking the key switch specifically if you're having issues getting your golf cart started. Check the area for loose wires or any broken pieces.
What to do if you can't hear clicking on your cart?
If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up. If the level is low, you'll need to add distilled water, until the plates inside the battery are fully covered.
What to do if your battery is low?
If the level is low, you'll need to add distilled water, until the plates inside the battery are fully covered. Other battery issues, such as off-kilter wiring or corrosion and melted wires could be causing your ignition. If you find a leak, you'll need to replace the battery itself.
Can you replace a forward and reverse switch on a golf cart?
This is an easy fix — replacing the forward/reverse switch is a generally inexpensive and quick repair . You'll want to make sure you have an experienced golf cart service professional do so, though, as the use of electric wires could give you a pretty bad shock if you're not careful.
Can Garrett's Golf Cars do engine tune ups?
Sometimes a major problem looks minor on the outside, so don't start your DIY repairs without speaking to an expert first. At Garrett's Discount Golf Cars, we can handle it all — engine tune ups, oil changes, battery work, tire replacement, joint lubrication, even installing new custom parts to make your golf cart truly your own. Whether you're interested in new or pre-owned golf carts, we're ready to show you the very best.
Do golf carts need to be repaired?
While golf carts are great for getting around your neighborhood, the golf course, down at the beach, or during a family or corporate event, they do have one serious downside — they will, just like any vehicle, eventually need repairs.
Can you repair golf cart brakes at home?
Many of the smaller repairs, such as adjustment or cleaning, can be done at home with what you already have in your tool box. You'll want to give us a call to make sure you order the right brakes for your particular brand and model of cart. Big repairs, like brake replacement, should probably involve bringing your golf cart in to be seen by one ...
What happens if water is in carbs?
Well if there is/was water in the system it will also be in the float bowl on the carb, there may be a drain on the bowl or you'll need to remove it and pour out what's in it.
Does a 5 year old cart engine need rings?
A 5 yr old cart engine that needs rings is sure not common, must have lived a hard life. The compression numbers can change a lot by how the test is implemented, [throttle butterfly needs to be held all the way open by hand] oil added to the cylinder during the test would show weather or not the rings are bad. Sounds like he is stabbing in the dark in my opinion.
Where does the 2 vacuum hoses run to from the carburetor on a 1991 Gas Club Car Golf Cart?
It looks like they are not vacuum hoses, but overflows and vents. 1991 was when the model changed.
What could be causing my golf cart to lose power? In the morning, it barely goes up the hills. It seems to run normally at night, but when I hit the gas pedal the lights go completely out
Have the battery checked. Especially make sure they do a shunt regulator test on the cells. Sounds light a shorted cell in the battery.
I'm not getting any spark out of the plug to start the club cart (1994)
Is this a golf cart? Single plug? Test for current getting to coil when ignition switched to ON. If yes, either bad ignition module or bad coil. If NO, check ignition switch and related wiring.
Club car golf cart will turn over but won't run
I have a 2008 club car precedent it only starts when I feather The Excelerator or gas pedal
Golf cart starting
There is a custom Golf Cart that looks like a Jeep and is considered an electric club car. If you get a chance there is a show called Barter Kings and one of the shows actually shows one. They are not cheap.
1986 golf blows fuse for the brake lights every time I depress the brake pedal. It is not the brake switch. Running lights stay lit
You might try removing the brake light bulbs from each light including the third brake light and see if the fuse still blows. If it does not then replace the bulbs one at a time until it does. You will then have an area to look for the short that is causing your problem.
THE VAN STARTED RIGHT UP AND I PUT IT IN REVERSE AND STARTED TO MOVE AND THEN THE VAN WENT DEAD. HEAD LIGHTS ARE OUT, DOME LIGHT IS OUT. BREAK LIGHTS WORK AND SOME DASH LIGHTS WORK. THE VEHICLE HAS ENOUGH..
I would guess that you either blew a main ignition fuse or the ignition switch melted.