Insert the key in the cart’s keyhole and turn it to the right to start it. If you notice that the vehicle’s engine is cold, engage the choke knob by pulling it out. Hold it in the engaged position till the vehicle comes to life, then push the choke knob back.
Full Answer
How to start a Yamaha G2 golf cart?
A good spark, air and gas is usually sufficient to get a Yamaha G2 golf cart started. But if it’s not, then check out for a crack in the spacer of the carburetor. Next check if the ignition coils are connected to the two wires that are there. Then check for spark. Check for a faulty starter.
Why is my Yamaha G1 golf cart spewing out gas?
Spark plug taken out turns really fast and spews out gas: If your Yamaha G1 golf cart is spewing out gas, you can be sure that it is getting an adequate gas supply, so no need to worry about that. You can check the oil for a possible contamination of gas. It may be a problem of hydro lock, that is, you are getting way too much gas than required.
How to start a golf cart with a bad ignition?
Find the ignition wire on your golf cart. This runs from your ignition switch to the starter solenoid. Check this over for corrosion on either end and make sure you’ve got a tight connection. If the connections use a spade lug, pull the connection loose, wipe off the terminal, and plug it back in again. Try to start the cart now.
How to test a Yamaha G9 golf cart starter?
To test this, you have to put the key in the starting position and crank up the Yamaha G9 golf cart engine; the solenoid should provide power to both the terminals. This will now supply power to the starter. To check whether the starter turns, you have to jump the starter by using a screwdriver.
How do you start a Yamaha gas golf cart?
1:412:58Yamaha Golf Car- Consumer - Operating Basics - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition during the key switch to the on. Position slowly press the accelerator pedal to disengageMorePosition during the key switch to the on. Position slowly press the accelerator pedal to disengage the farc brake and gently apply pressure to the accelerator pedal to increase the speed.
How do you bypass the ignition on a Yamaha golf cart?
This process includes these steps:Turn off the ignition switch to minimize your risk of electrocution. ... Locate the wires for your cart's ignition switch. ... Use wire snips to cut these wires away from their connectors. ... Touch the engines together carefully to bypass the ignition switch and send power to your engine.More items...
How do you start an old Yamaha golf cart?
0:112:13How To Start a Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou hear it usually makes a sound and then you go in reverse. So again it is now on we're not goingMoreYou hear it usually makes a sound and then you go in reverse. So again it is now on we're not going anywhere when you step on the gas. It takes a minute to really start going.
How do you keep a Yamaha gas golf cart running?
Yamaha G9 golf cart won't stay runningCheck for dirt or dust accumulation in the air filter and if so, clean it. ... Inspect the airbox and check if it has come off loose. ... Check for cracks or leaks in the plastic carb spacer. ... Make sure that the gas is not adulterated with ethanol or water and doesn't have condensation.
How do you hotwire a Yamaha golf cart?
1:164:28How To Start A Golf Cart Without A Key - YouTubeYouTubeStart of suggested clipEnd of suggested clipI'm going to use a paperclip. And a small screwdriver to try this one it involves just moving theMoreI'm going to use a paperclip. And a small screwdriver to try this one it involves just moving the tumblers up while you're applying pressure to the cylinder.
How do you start a golf cart with a screwdriver?
Insert the tip of your screwdriver in the ignition switch's slot. Move the screwdriver up and down gently but firmly until you can turn the tool around the same way you would turn a key. This should fire up the cart.
Why does my Yamaha golf cart not start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
Where is the choke on a Yamaha golf cart?
Choke Cable – Yamaha G22 is a brand new choke cable that mounts to the front of the rear body on a Yamaha G22 gas golf cart. It's an absolutely essential part that's needed to get the engine started. Pull it out to choke the carburetor and release it when the engine begins to run.
Where is the reset button on a Yamaha golf cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do you take the governor off a Yamaha golf cart?
General InstructionsDetach the cable from the carburetor. The cable is about the width of a straw. ... Follow the disconnected cable up to the governor. ... Disconnect the gas pedal cable from the governor and reroute it to the carburetor. ... Using your wrench, remove the bolt on the gas pedal shaft.
How do I make my Yamaha golf cart idle?
0:523:44How to get your club car to idle - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe black wires gonna be on the bottom half down here you can't see it but just disconnect it onceMoreThe black wires gonna be on the bottom half down here you can't see it but just disconnect it once you disconnect that you're gonna have to get your flat-head screwdriver and turn up the idle.
How do I make my Yamaha gas golf cart go faster?
0:005:15Yamaha G29 Drive Golf Cart Governor Adjustment - MORE SPEED!!YouTubeStart of suggested clipEnd of suggested clipItself by tightening this nut down you're putting more pressure on the spring. So that the governorMoreItself by tightening this nut down you're putting more pressure on the spring. So that the governor has to work harder to pull back on the throttle.
Why won't my golf cart start up?
Golf carts that run on gas refuse to start up if you idle them away for long periods. Gas becomes unstable when you store it away for long. Once the last trip of the golf cart before winter is done, mix fuel stabilizer to the gas tank to stabilize the gas while the vehicle idles away.
How to start a golf cart in neutral mode?
To start your cart in neutral or maintenance mode, follow these steps: Reach to the backside of the Forward/ Reverse switch of your golf cart. You’ll find a yellow cam with spring on the rear.
What is the ignition on a golf cart?
The ignition in your golf cart is nothing but a circuit. The switch on the ignition closes the circuit which in turn gets the ignition going. By employing this method, you’re essentially jumping the circuit, hence turning it into a closed connection.
How to know if your golf cart is rusting?
If you find rust on the wires, make sure to wear gloves before you wipe the rust off. Once you’re done placing the wires in their correct positions, test drive the cart to check if it runs.
What happens if you don't engage the switch on a golf cart?
If you do not engage the switch, your batteries will drain at a faster rate owing to the charge used by the controller. Solution 2: In the event of complete discharge of your batteries, your golf cart charger might not be able to recharge them.
Why does my golf cart stop?
Such uneven and jumpy tracks can mess up your ignition wires and displace them. This can cause your cart to stop in the middle of a run. This is a good place to first look when your golf cart dies suddenly.
What is worse than hopping on a golf cart on a Sunday morning?
Nothing is worse than hopping on your golf cart on a Sunday morning all excited for a round of golf, only to find your golf cart not starting! If you’re a golf cart owner, there will come a point where you find you and your cart stuck on the golf course. There will come a day where you lose your golf cart key; yet still want to start your golf cart.
What does it mean when your engine idles?
This means that you wont be using much (if any) of your factory wiring and your engine will idle/stay running after it has been started or until you turn it off. This also means that you will likely have to "wire" your new engine from scratch or buy a pre-made wiring harness.
Can a GX390 be pedal start?
The engines idle screw is backed out so the engine will not idle. This method does not require any additional wiring but typically the only engines that will be pedal start are the smaller GX390/Clone engines and the factory engine. Most other aftermarket engines are too large to also incorporate the Starter/Gen and retain the pedal start.
What happens when a spark plug is taken out on a Yamaha golf cart?
You can check the oil for a possible contamination of gas.
What to do if golf cart doesn't start?
If you find any moisture, you have to replace the plug. If the golf cart doesn’t start, you will want to clean the carburetor with some cleaning fluid. You can also take a look at the fuel bowl to check if it’s empty. If not, open and drain it.
Why does my golf cart keep turning but not starting?
Solenoid problems: A solenoid can wear out after using your golf cart regularly. A faulty solenoid can cause your golf cart to turnover but not start. Your golf cart solenoid is a coil of wire cylindrical in shape, but in reality it functions as magnet carrying electricity.
Why won't my Club Car Precedent Golf Cart start?
Club Car Precedent golf cart turns over but won’t start. A faulty spark plug, bad battery or low compression levels are the main reasons why a Club Car Precedent golf cart will turn over but not start. Lack of spark in the coil: in this case, you have to replace the coil if it doesn’t spark. Spark plug: Also look whether ...
Why is my golf cart starting with a key switch?
Key switch problems: Keyswitch issues is a common cause of golf cart starting problems as the key switch will wear out over time. You have to check the keyswitch area for any loose or broken piece of wiring. Be very careful while doing this since you might get a nasty shock.
Why won't my golf cart start?
Faulty brakes: Very often, faulty brakes are the reason why a golf cart won’t start. You should be able to adjust the breaks at home. However for more complicated repairs, it is better to pay a visit to your nearest professional mechanic.
Can a Yamaha G2 golf cart start?
Yamaha G2 golf cart turning over but not starting. A good spark, air and gas is usually sufficient to get a Yamaha G2 golf cart started. But if it’s not, then check out for a crack in the spacer of the carburetor. Next check if the ignition coils are connected to the two wires that are there. Then check for spark.
How to tell if a golf cart won't start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops ...
How to check if a gas cart battery is charged?
First, you turn the key, press the pedal, and listen for a click. If nothing happens, it’s most likely an electrical issue. On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge.
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
What to do if a gas cart key switch fails?
There should be a reading or continuity between any combination. If this is a gasoline cart, set the switch to “ON” and take a reading between the terminals. There should be continuity. If the key switch fails any of these tests, it’s worn out and should be replaced.
What causes a car to start when the spark plug is replaced?
If it sputters and tries to start, then the likely culprit is the fuel pump followed by the carburetor. The fuel pump on most gasoline powered carts usually has three hoses going to it.