Low power batteries or a faulty battery can cause your cart jerk when accelerating. The cart might jerk as it speeds when power or if electricity is not distributed appropriately. Fortunately, changing the battery should solve this issue quickly and easily.
Full Answer
How to fix a bouncy golf cart?
You can try driving the cart for a few miles to warm up the tires. This will cause them to get back to their original shape and help resolve the issue of the bouncy cart. You can try turning the tires one by one after jacking up your cart. Check if they work fine else the problem lies with your tires and they need to be replaced.
How to get more speed out of your golf cart?
Upgrading tires and increasing your tire size is by far one of the most economical and easiest ways to get more speed out of your golf cart. Equally applied, this is a great solution for both gas and electric golf carts.
Why is my golf cart jerking from the front end?
A Club Car golf cart jerking from the front end of the golf cart occurs due to poor quality of tires. If the tires are worn out or loose, the golf car can start jerking. The uneven height of your front tires can also cause jerking. So, make sure that all the tires are of even length and width when you buy your desired golf cart.
How to fix a golf cart that won’t start?
To fix the issue, you have to check your golf cart’s adaptor and resistor, check all its components, and repair and replace the components that need replacement. You should also check the clutch of your golf cart. If the clutch is in terrible condition, then you should replace it before it causes severe damage to your golf cart.
How do you stop a golf cart from bouncing?
You can easily take care of this problem by deflating your front tires until the sidewalls of your cart are about 1/2 the front walls. This should help get the beads seated. Now, you can inflate your tires back. The bounce should have disappeared.
Why does my electric golf cart jerk?
Jerking electric golf carts are probably more common than a jerking gas model. That's because most “jerking” concerns are caused by battery issues or a poor flow of electricity from the battery to the cart. Typically, you'll start to notice this problem when your cart needs to charge up.
Why does my golf cart surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
How can I make my golf cart go smooth?
How to Make a Golf Cart Ride SmootherCorrect Tire Pressure. ... Replace Worn Out Shocks and Struts. ... Check the Fluid and Filter. ... Replace the Clutch. ... Flat Spot in Tire. ... Tire Damaged or Out of Line. ... Worn Out Suspension Bushings. ... Check Your Lift/Tire Combo.More items...
Why does my golf cart sway?
When you lift your golf cart, the tire size also increases, which is why lots of inconveniences can occur, including over-swaying. It happens because after lifting, generally, the weight of the backside becomes higher than the front side.
Why do golf carts shake?
The common cause of golf cart vibrates when accelerating due to damaged inner CV joints, broken motor mounts, unbalanced tires or a bent driveshaft. To fix this issue, you should check the CV joints of your golf cart.
Why does my golf cart jerk when I take off?
Your Club Car golf cart jerks when taking off, because of a faulty MCOR or low battery charge. Wiper arms that are adjusted incorrectly can also cause a golf cart to jerk. Faulty MCOR.
What does the MCOR do on a golf cart?
Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for "Motor Controller Output Regulator".
Where is the speed sensor located on a Club Car golf cart?
The speed sensor in a Club Car Precedent golf cart is located on the back of the motor. To remove the sensor, unplug the cables behind the motor. You can use a 5/16-inch socket to remove the pigtail connector and pop off the plastic housing that encases the speed sensor.
Why is my golf cart bumpy?
Correct tire pressure Too high a pressure makes the cart ride bumpy while too low pressure causes the cart to drag. Rotating the tires occasionally for uniform use is a good idea.
How can I make my golf cart more stable?
Drop Spindle kits are used to replace and increase the golf cart spindle size and length. This can give your golf cart a wider stance, and increase the stability. The wider stance is perfect for those looking to fit those big off-set wheels on your cart, which in turn, can allow you to add wider and taller tires.
What PSI should my golf cart tires be at?
15 to 25 pounds per square inchThese tires typically use anywhere from 15 to 25 pounds per square inch (PSI), with the average being 20 to 22 PSI. For golf carts driven off-road or on rougher terrain, it's not uncommon to under-inflate tires to gain additional traction. However, under-inflated tires wear down prematurely.
Why does my electric golf cart jerk?
1] Water-logging in some of the components of your electric golf cart can result in jerking. Sensors and micro switches installed near the vehicle’s floor mat can malfunction due to water interference, which causes jerks when you accelerate.
Why is it important to maintain a golf cart?
Hygiene and maintenance of your golf cart are not only important for your comfort but also the regular functioning of your golf cart. The clutch is the component of your golf cart used very frequently and can be easily soiled with dirt and dust particles.
How much does a DS golf cart weigh?
The DS produces both battery and gas-powered golf carts. The electric DS weighs 498 pounds, whereas the Gas DS weighs 619 pounds. The speed ranges between 12-15 miles/hour for the gas model, whereas 12-19 miles/hour for the electric one. Jerks can occur in the DS Car for the following reasons.
How fast is a club car?
Club Car’s gasoline-powered Tempo golf cart is one of the most highly coveted golf carts by golfers worldwide. Its speed ranges from12-15 miles/hour. The Tempo golf cart comes with a 5-year warranty and a dynamic engine of 3.3 horsepower.
What tools do you need to dismantle a golf cart battery?
This battery consists of various cables and wires, which are crucial for the working of your vehicle. Cutters, crimpers, nails, and a screwdriver are all essential tools you should carry in case you want to dismantle or recharge your golf cart’s battery.
How much does a club car precedent weigh?
It costs around 11,500 USD and has a minimum horsepower of 3.7 (2.7 kW). The Precedent weighs 1176 lbs, and its speed ranges from 8-14.8 miles/hour.
Why does my DS car jerk?
Battery damage: – Jerks can occur while accelerating in a DS model if the cart’s battery and other electrical components have been damaged . Repairing or replacing these components can lessen or nullify the problem of jerking.
Why does my golf cart jerk?
The most common reason why are golf cart jerks could be that the water has entered some of the components . There are a sensor and a micro-switch under the driver’s side floor mat. If water enters these components, especially the switch, it could cause the cart to jerk while starting.
What happens if your golf cart clutch is bad?
If the clutch is bad, you could experience some jerking movement during the start or stopping stage of the golf cart. Consider getting the clutch checked and possibly replaced if any issues are there. This should help resolve the problem of the cart jerking when accelerating or taking off.
Why is my cart bouncing?
If the cart is still bouncing, you will know that the problem is not with the tire. Instead, the issue could be due to a bent wheel. In this case, you will just have to get the wheel replaced. If both these cases do not seem to be the cause, then it could be due to the axle or the wheel bearing.
Why does my clutch jerk?
Well, the issue could be related to the clutch. The primary clutch weights could be broken, which might be causing the jerks. It would be a good idea to get your clutch checked to help resolve the problem. Another cause of this issue could be the accumulation of dirt or dust particles in the clutch.
Can you use an ohmmeter to calibrate a cart?
In such cases, you will have to use an ohmmeter to calibrate the readings and make the necessary adjustments. Any technical manual of your cart model will have details about the various parts. You can either use them to recalibrate it or take your cart to a service center. They can easily fix it for you.
How to get more speed out of golf cart?
Upgrading tires and increasing your tire size is by far one of the most economical and easiest ways to get more speed out of your golf cart. Equally applied, this is a great solution for both gas and electric golf carts. If you install a tire with a larger diameter on your golf cart, the end result is a higher top speed.
How fast can a golf cart go?
Most new and used golf carts are made to go a top speed of around 15 miles per hour . Although that is the perfect speed for most folks, there is an equal amount (if not more) of folks out there who are looking to increase their golf cart top speed and go faster than 20 MPH let's say.
How does a new battery work on a golf cart?
Simply put, most types of golf carts are designed to work with a range of different batteries. A new battery will increase a golf cart’s motor output. The result of the motor output increase is higher speed. Purchasing new batteries with a higher voltage maximum will increase your golf cart’s speed dramatically.
Is there a catch all solution to increasing golf cart speed?
A golf-cart weighed down by unnecessary clutter and debris is not a happy golf-cart! In closing, something to keep in mind is: There is no "catch-all" solution to increasing golf cart speed / golf cart power. There are many factors to consider such as, how the parts, pieces and changes interact with your golf cart.
Can you install a torque motor in an electric golf cart?
Essentially, installing a torque motor or speed motor may not be the end solution. With that said, something that you will want to keep in mind as you are upgrading, are the two main/major electrical components within your electric golf cart, that play a huge role in your golf carts system:
Do you need a lift kit for a golf cart?
Note: Depending on the size of the tire and the make/model of your golf cart, some golf carts will require a lift kit to accommodate the size of the new tires. If you are unsure whether you need a lift kit for your golf cart before replacing them, we have an excellent Resource that discusses this topic in more depth.
What to do if your golf cart is spitting gas?
Lastly, if your golf cart is spitting gas, you may need to replace your air box. A relatively common problem is getting replacements that aren’t the stock air box for your cart. Something that most people don’t know or forget about is that if you’re using aftermarket filters, you absolutely must reset your carburetor.
Why does my golf cart spit?
Golf carts can spit and sputter for several reasons, but mainly due to worn out spark plugs or dirty filters inside the fuel system. There might be something wrong with the fuel system of your cart. You could be having a spit and sputter problem because the filter, pump and injectors in your golf cart are very dirty.
Why does my carburetor spit gas?
Problems with the timing chain in your cart might also be making your carburetor spit gas. If you have a timing belt that jumps, it’s probably causing your gas spitting problems. Jumping belts are more common when you have plastic camshaft timing gears rather than metal timing gears. Lastly, bad reeds can lead to gas spitting.
How to fix gas spitting from valve cover?
Here’s what you can do to fix gas spitting from the valve cover. Replace the needle in the carburetor or replace the whole carburetor. The other thing that’s likely to cause gas to spit from the valve cover of your cart is your carburetor float being stuck open. This is simple enough to fix.
How to tell if your carburetor is dirty?
Lastly, it might be that your carburetor is too dirty. If your carburetor is dirty, your cart engine will sputter.
Why does my golf cart blow out?
How to Fix Golf Cart Blowing Out (White Smoke) White smoke usually means your engine is running hotter than normal. If there’s a bit of smoke when you’re just starting the cart, it might just be the cart warming up. Excessive amounts of white smoke might mean there’s a problem with your cooling system.
Why is my cart blue?
It might be a leaking valve which could lead to fires in your engine. Blue smoke might be caused by damaged rings in your engine. Check if the rings in your cart engine are busted and if they are, do a ring job and replace them.
1. Speed Sensor Issues
The speed sensor is an essential and critical part of golf cart operation that helps to ensure that cart runs smoothly and efficiently. It operates by measuring how fast you are driving and how much electricity is needed to maintain that speed. When the speed sensor ends up running into trouble, chances are your cart may end up running slowly.
2. Low Battery
Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
4. Bearing Encoder Issues
The bearing encoder is an essential part of your golf cart that provides you with careful electrical charge distribution throughout your cart. It works by encoding various elements of your cart's operation and translating them to different impulses to keep the power running smoothly.
5 Ampacity Controller Fault
The Ampacity controller is a part of your cart that helps to manage the amperage that produces and uses as your cart drives. When this particular part malfunctions, you're going to run into some issues with your cart operation.
How to Increase your golf cart speed?
Are you looking to increase your golf cart speed? Learn more about how to make your golf cart go faster.