How do you check a fuse on a golf cart? Find the service panel on the rear fender on the driver side of the golf cart behind the battery. Read the inside panel to determine the level of current the fuses are set to take at a maximum voltage.
Full Answer
Why does my golf cart fuse keep blowing?
A golf cart fuse can blow for many reasons such as a faulty relay switch, loose connections or a naked wire. There are some reasons why your golf cart fuse tends to keep blowing: There is a naked wire or a grounded wire.
Where is the fuse box on a Yamaha golf cart?
Golf carts with an Alltrax controller usually feature a 400-amp fuse fitted on the controller. This fuse must be connected to the positive terminal of the main battery pack. The fuse box in a 2014 Yamaha golf cart is located on the left side of the controller. The wires are tied to the roof drain.
Why does my Yamaha golf cart controller keep dying?
The controller on a Yamaha golf cart can die when the battery voltage is too high, or because of loose wiring in the charger. The batteries’ voltage: This is one of the primary reasons for your golf cart controller’s death. There are times when the battery voltage is too low or too high.
How do I troubleshoot the 2008 Yamaha golf cart controller?
You can troubleshoot the 2008 Yamaha golf cart controller using the following steps: Press the accelerator and check whether the voltage increases up to the full voltage of the battery. If it does not increase, then there is a problem with the controller or the batteries. Examine the batteries and check if they are dead.
How can you tell if a golf cart fuse is bad?
You're getting ready for a day on the course, when you notice that the lights on your golf cart don't seem to be working. If the engine still turns over and everything else is working right, you probably have a blown fuse on your hands.
Does a Yamaha golf cart have a fuse?
The fuse box in a 2014 Yamaha golf cart is located on the left side of the controller. The wires are tied to the roof drain. In a G2 electric cart, the fuses are present on the rear inner fender. This is on the front of the driver's side of the cart.
Do gas golf carts have fuses?
Often, you can find this fuse in the power circuit rather than the charging station or the fuse box, so make sure to look to this location when replacing and repairing your fuse box. Finally, there is the 400-amp fuse, which is almost always located as near the power source or the battery as possible on your cart.
How do you tell if a fuse is blown?
Remove the fuse from its holder. In some cases you may need a small screwdriver to unscrew the fuse holder cap. Look at the fuse wire. If there is a visible gap in the wire or a dark or metallic smear inside the glass then the fuse is blown and needs to be replaced.
Do all golf carts have a reset button?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
What size fuses for a golf cart?
Replacement ATC-10, 10 amp fuse. This fuse is commonly used for 12VDC, 10Amp accessory loads in Club Car gas & electric DS & Precedent model golf carts as well as Yamaha gas & electric G9-Up model golf carts. However, this fuse can be used in many other applications for accessory loads.
Where is the reset button on Yamaha electric golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
Why are my lights not working on my golf cart?
A blown-out headlight fuse is the main reason that your EZGO RXV golf cart lights are not working. An incorrect circuit connection to the headlight fuse can also cause the lights to stop working. There are times when the circuit wires are torn or worn out.
How does a golf cart electrical system work?
The electric motor receives electric current through the electrical system to move faster or slow down. When the electric motor receives the electric current, it turns the wheel to get the golf cart to move. The more current it produces, the faster it turns!
How do I know if a fuse is working?
0:522:41How to Check a Fuse by Testing it with a Multimeter - YouTubeYouTubeStart of suggested clipEnd of suggested clipMany digital multimeters will make an audible sound during this test in this setting I can touch theMoreMany digital multimeters will make an audible sound during this test in this setting I can touch the two probes together to see if the device is in working order and then place the probes.
How do you tell if a fuse is blown without a multimeter?
Put one wire to neutral/common, and one wire on the line side of the fuse. If voltage is present the bulb will light up. Now move the wire from the line side to the load side of the fuse. If the fuse is good the light will come on.
How do you check fuses?
0:572:58How to Check For Bad Fuses With A Multimeter - YouTubeYouTubeStart of suggested clipEnd of suggested clipNow we'll just touch both sides of the fuse. And check the meter and then you want it close to zero.MoreNow we'll just touch both sides of the fuse. And check the meter and then you want it close to zero. Now a fuse you're not gonna have any in between it's either gonna be good or it's bad unless.
Where is the reset button on Yamaha electric golf cart?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
Do golf cart chargers have fuses?
Golf Cart Issues If the Club Car's computer is working correctly, the relay should make a “click” sound when you plug in your charger. If it does not, then you could easily have a blown fuse. If you check the fuse and it is okay, then you could also have a damaged relay, although this is rare.
How do you reset OBC on a club car?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
Where is the solenoid located on a club car?
0:095:38Replace Solenoid in Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipCart um your solenoid could be located in a bunch of different places but almost always underneathMoreCart um your solenoid could be located in a bunch of different places but almost always underneath the seat.
Why is my Yamaha golf cart controller so hot?
The primary reason why a Yamaha golf cart controller gets too hot is because of overuse. When the golf cart is used for long periods of time, the controller can start overheating. The driving surface might also be a cause of heating. If driving on a straight and soft surface, the problem of heating should not occur.
Why is my golf cart not heating?
If driving on a straight and soft surface, the problem of heating should not occur. But, if driven on uneven or steep surfaces , there are chances of heating. Another reason could be the brakes. It is essential to check if the brakes are dragging while the golf cart controller is driven.
What to do if your golf cart controller does not increase?
If it does not increase, then there is a problem with the controller or the batteries. Examine the batteries and check if they are dead. If dead, replace them. Examine the controller, as discussed in the previous sections. Remember to always consult a mechanic to have your golf cart controller repaired.
What are the problems with a Yamaha G22?
Yamaha G22 also faces similar problems like G9 and G16. Overheating, battery faults, wiring issues, voltage issues are some problems that might occur with your Yamaha G22. To avoid these problems, test the golf cart’s major components connected to the controller regularly.
How to test Yamaha G16?
To test the Yamaha g16’s speed controller, check the voltage reading while pressing the accelerator. Test other components such as the batteries, the charger, and the solenoid for their smooth functioning. If any of these components do not work as expected, then you need to replace them.
Why is it important to troubleshoot a golf cart controller?
Troubleshooting the controller is extremely important for the golf cart’s smooth functioning. Generally, controllers face major issues only when there is a problem with wires or defects on the controller itself, such as marks or cracks.
How to troubleshoot a G9 controller?
Here are some easy steps for troubleshooting the G9 controller: Check the controller’s body to locate any major defects such as cracks, scratches, or black marks. If these are found, then replace the controller immediately. If no major defects are found, then check the wiring.
How to tell if golf cart solenoid is bad?
One of the most common and obvious signs of the bad solenoid is the golf cart's failure to start when you initiate the ignition process. Once you click the accelerator and turn on the ignition switch, it is supposed to send a signal to activate the solenoid and start the cart. If the cart does not start, there is a big possibility ...
Why is my golf cart not starting?
If the cart does not start, there is a big possibility of a damaged solenoid. Another reason for a bad solenoid is that the contacts are starting to get damaged due to overheating or high current passing through them. Note: You may not necessarily experience all of these issues to recognize bad solenoids on your golf cart.
Why won't my golf cart turn over?
For a gas golf cart, the most common symptom is the starter failing to engage, so the engine doesn't turn over. Starters have the responsibility of activating the flywheel. When the flywheel starts to work, the starter is supposed to disconnect.
What is a solenoid in golf carts?
Simply put, a solenoid is a device that can transform electrical energy into mechanical energy. It's a coil of wire which is used as an electromagnet. The solenoid has the capability of creating a magnetic field with the help of an electric current. Solenoids work as the “go switch”, which is a must for any golf cart.
