How do you know what volt your golf cart is?
How to Determine Golf Cart Voltage (36V or 48V) Lift up your golf cart seat to locate the battery compartment. Count the number of holes on a battery. ... Multiply the number of holes by 2 to determine the golf cart battery voltage. ... Multiply the golf cart battery voltage by the total number of golf cart batteries.
What's the difference between 36V and 48V?
Battery Volts A 36V e-bike battery will allow you to draw a lesser critical current, typically around 15 amperes whereas, a 48V e-bike battery will allow more current in the range of 10 – 40 amperes. It means you can go faster with a 48V E-bike battery.
Does a 48 volt golf cart have more power than a 36 volt?
More gas (or more amperage) means you can drive further before needing to recharge. When choosing between stock 36v or 48v cart, the 36 volt golf cart will have less power (get-up-and-go). It also will not go as far on a single charge compared to the 48 volt golf cart.
What voltage is my golf cart battery?
Healthy batteries will indicate about 50 to 52 volts on the voltmeter. Most battery packs hold around 48 volts. Keep in mind that the high number doesn't mean that the batteries are instantly good. This measured value doesn't take the load or cart's power consumption into consideration.
Can I use a 36V battery with a 48V motor?
Re: 48V motor and 36V battery Can i use the 48v on that motor? you would have to change out the controller to a 48V one.
Can a 36 volt golf cart go up hills?
A golf cart powered by a 36-volt motor would either move too slow or not at all when going up on a hill. It is recommended to use a 48-volt battery for optimum performance as it creates more low-end torque and faster acceleration.
Can I run 48V on a 36V golf cart?
It all depends on your battery bank used with this 36V to 48V conversion. can only be accomplished through installing a 48V motor capable of higher torque, or installing a 48V controller with a higher current limit (amperage).
How can I make my 36V golf cart go faster?
6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.
How fast will a 48V golf cart go?
The standard 48v golf cart will travel between 12 to 14 mph. However, if you apply modifications to the vehicle you can expect top speeds of 20 to 24mph.
How many lithium batteries do I need for a 48V golf cart?
If you're using a 48V lithium battery connected in parallel you don't need to install a specific number of batteries to meet the voltage requirements – you install the number of batteries that will give you the mileage range you desire. You can use as few as 2 batteries or up to 6 batteries in a typical golf car.
How far will a 36 volt golf cart go?
A 36 volt golf cart is adequate for 2 to 4 passenger use when you are primarily using it on flat a flat surface. The average drive time or range for a 36 volt DC system is about 30 miles on a full charge. The 48 volt golf cart offers many more advantages in all 2, 4 or 6 passenger models.
How many batteries do I need for a 36 volt golf cart?
The average golf cart needs 4 to 6 batteries to operate correctly. In rare cases, you'll find 8 batteries in a golf cart. Golf carts are powered by a total of either 36 volts or 48 volt. A typical golf round requires the golf cart to run for about 40 minutes.
How far can a 36v golf cart go?
A 36 volt golf cart is adequate for 2 to 4 passenger use when you are primarily using it on flat a flat surface. The average drive time or range for a 36 volt DC system is about 30 miles on a full charge.
How fast can a 48 volt golf cart go?
The standard 48v golf cart will travel between 12 to 14 mph. However, if you apply modifications to the vehicle you can expect top speeds of 20 to 24mph.
How far can a 48V golf cart go?
The maximum range of this new battery when powering a 48V E-Z-GO RXV golf cart is approximately 20.5 miles when moving at 12 miles per hour. In golfing terms, this equates to around 3 rounds or 54 holes.
How long will a 48V 10Ah battery last?
At 30 mph you will be drawing about 1,000W from the battery on average (assuming no major hills or wind). You won't want to drain the 48V/10Ah pack fully so figuring 80% DOD you have 384Wh to work with or 0.384 hours at 1,000W. Therefore traveling 30mi/hr for 0.384 hours yields a range of 11.5 miles.
How to tell if a golf cart is 36V or 48V?
To determine whether your golf cart is 36V or 48V, follow these steps: Lift up the seat to view the battery compartment. Count the number of holes on each battery. You may need to remove the battery cap to see the holes.
How many volts does a golf cart use?
Golf carts that are powered by 48 Volts consist of either (6) 8 Volt batteries or, in the case of some Club Car Precedent golf carts, (4) 12 Volt batteries.
How to determine golf cart battery voltage?
Count the number of holes on each battery. You may need to remove the battery cap to see the holes. Multiply the number of holes by 2 to determine the golf cart battery voltage. Multiply the golf cart battery voltage by the total number of batteries.
What is voltage in golf carts?
Technically speaking, voltage is the potential difference in charge between two points in an electrical field. The greater the voltage is, the greater the current.
Is it more expensive to replace a 12 volt battery?
Batteries are more expensive to replace. If the system uses 12 Volt batteries, run time will be less due to a lower battery lead volume. Replacement motors and controllers are typically more expensive. 48 Volt cart are more expensive to purchase. Whether you decide to go with a 36 Volt or a 48 Volt, the important thing is ...
Can a 36V golf cart be used off road?
They produce less power than 48 Volt systems. They are less efficient and therefore, yield fewer hours on a charge. It is not recommended that a 36V golf cart be used offroad, since it has less power.
What is a 36V golf cart?
A 36V system is great for flat, smooth, dry surfaces such as driving around your paved golf cart community , golf course, or general leisure cruising. Cost - 36V golf carts and their repair parts can be slightly cheaper than 48V golf cart parts.
How fast can a 36V golf cart go?
Standard 36V and 48V golf carts are capable of the same top-end speed (12MPH). You can, however, make your golf cart go faster by doing a couple of things: Larger Tires - You can purchase larger tires. The larger the diameter of the wheels, the faster your golf cart will go.
How many tires can a golf cart have?
Standard carts will allow for a maximum of 20” tires without the need for a lift kit or block lift. Standard golf cart tires are 18” so an upgrade to 20” tires will give you an added 2 MPH. Torque/Controller Upgrade Kit - You can upgrade the torque on your golf cart with a torque upgrade kit or controller upgrade kit.
What is the difference between a 48V and a 36V?
Here are some things to consider: Power/Torque - A 48V system has higher low-end torque which you’ll feel when you accelerate. Basically, a 48V system gives you more “pep in your step” and picks up/speeds up a bit faster than a 36V system.
When did 36V golf carts start?
Here are the manufacturing years that some of the most popular golf cart manufacturers starting making 36V golf carts: Club Car - Club Car first introduced their 36V golf cart in 1950. EZGO - EZ-GO first introduced their 36V golf cart in 1960. Yamaha - Yamaha first introduced their 36V golf cart in 1979.
When did golf carts start making 48V?
Here are are the manufacturing years that some of the most popular golf carts starting manufacturing 48V carts: Club Car - Club introduced their 48V system in 1995. EZGO - EZ-GO introduced their 48V system in 2008. Yamaha - Yamaha introduced their 48V system in 1995.
Can you convert a 36V to 48V motor?
Yes! Here are the main parts that will need to be installed/swapped out to do a 36V to 48V conversion: Upgraded batteries. Upgraded solenoid. Upgraded solenoid diode and resistor. Upgraded controller. Upgraded motor.
How many volts does a golf cart have?
If you have six 6 volt batteries your golf cart is a 36 volt cart, if you have six 8 volt batteries or four 12 volt batteries your golf cart is a 48 volt cart. Electric golf car motors have a life span of anywhere from 5000 to 8000 hours and then can be rebuilt for 25% of the cost of a gas golf car engine.
How long do golf cart batteries last?
Batteries Each battery has a stamp which indicates the month and year it was manufactured. Batteries last from 3 to 8 years under normal circumstances.
Where is the battery bank?
You will find the battery bank for your golf cart directly under the drivers seat. In some cases the battery system is quite large and will most likely be continued under the front nose cone area of popular carts like Gem cars or other 4 or more passenger golf carts.
What do you see there?
Ok, so you pull the seat back and what do you see? Here is an example of a popular golf cart. This picture is of a older style club car with a 36 volt battery system. Which is easily determined because you will count (6) six batteries.
Another example
Here is another example to make sure you got it. How many volts are found in this battery system found in a late model motor coach waiting for new batteries to be installed? Again 1,2,3 = 6 volts (2 volts x 3) 1,2,3,4,5,6 = 6 volts batteries = 36 volts total (6 volts x 6 batteries) Hey, You are getting good at this! Here is one more for you.
Our shop cart test
Our shop cart has 4 batteries under the seat but each battery has (6) six filler holes or cells on each battery. Would this be a 48 volt system? Yes, It is a 48 volt system because you have 6 cells per battery and you have 4 batteries. (6 cells x 2 volts = 12 volts) (4 x 12 volt batteries = 48 volts).
What is the difference between a 48 volt golf cart and a 72 volt golf cart?
Therefore higher voltage vehicles can run for longer, which means that the 48-volt golf carts will provide less runtime than the 72-volt.
What is 72 volt golf cart?
72-volt golf carts offer you the most power and speed out of the other models on the market. The cart’s increased voltage enhances the flow of electrons. Providing you with amplified acceleration over lower voltage vehicles.
How many batteries are needed for a 72 volt golf cart?
Most 72-volt golf carts will have the capacity to carry six 12-volt battery packs to power them. Since you will require more batteries than the 48-volt, it means that you will need to budget for a higher upfront cost in that regard.
Why do golf carts have higher voltages?
Golf carts with a higher voltage can deliver more acceleration and speed. This is a result of the increased force generated by an enhanced flow of electrons. As a result, the 72-volt golf cart provides you with more speed and power.
What is the best battery for a golf cart?
Battery Options. To meet the required 48-volts, you can equip your cart with three different battery options. These are 6-volts, 8-volts, and 12-volts. The 6-volt option is the most expensive, but it is also the most efficient overall.
Why do carts have lower current?
Since carts with higher voltages provide a more efficient transfer of energy, they can use a lower current. A lower current leads to lower resistance losses, which translates to reduced energy loss. This enables the cart to run for longer at an efficient speed.
What voltage is used for golf?
The golf market today boasts a wide range of 48 and 72-volt options. 48-volts are a popular option as they are more affordable to maintain, and they deliver a moderate level of power.