Locate the gas pedal that is fitted to the governor and remove the connection. Re-route the gas pedal to the carburetor. Remove the bolt present on the shaft of the gas pedal. Slide the shaft upwards so that the gas pedal has more play. Tighten the bolt and start the golf cart.
Full Answer
How do you lift a golf cart without damaging it?
Also, I recommend a small floor jack to lift the golf cart as the carts are lightweight and close to the ground. With the vehicle set to the floor and with no chances of slippage, use the wheel to turn the rack to one side. Find the bottom adjustment nut and loosen it with a wrench.
How do you fix a slippage on a golf cart?
Securing the wheels – I jacked up the cart and rotated the wheel on one side until the last lock noted down the slippage area. The rack was moved to one side, turning the steering. Loosening and adjusting the nuts – The adjustment nut at the bottom was loosened slightly while the middle adjustment nut was tightened.
How to fix loose steering on a golf cart?
Otherwise, inspect the steering box, bushings, or the pinion and rack arrangement. If loose steering on your golf cart is coming from the steering box, pinion or rack arrangement, there is a possibility they are worn out. In this case you should consult with a technician and have the part replaced.
How do you enlarge the front tire on a golf cart?
Drive the cart forward by approximately five feet with the tires in normal running position. Make sure the difference between the front and rear tires are less than 1/8 th of an inch. For a 2008 model, you can enlarge the hole above the strut using a 10mm bolt at the mounting point on the dash frame.
How do you adjust golf cart suspension?
2:344:39Crash Course #11 How to Adjust Toe and Camber - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd rotate it one full turn on the passenger. Side I want to rotate it one full turn on the driverMoreAnd rotate it one full turn on the passenger. Side I want to rotate it one full turn on the driver side as well that helps keep everything even. And once you've made your adjustments.
How do you fix a wobbly golf cart?
Golf Cart Wobbles When Going at High Speed Consider replacing the springs with harder ones. This could help solve the issue of the cart wobbling at high speed. You could try using a steering stabilizer to help control the wobbling at top speeds.
Why is my golf cart so bouncy?
Check if your golf cart is fitted with heavy-duty leaves. These are often known to cause bounce. Replacing them with stock leaves or removing a couple of them should solve the problem. Check the pressure of all the tires in the cart.
How can I make my golf cart more stable?
Drop Spindle kits are used to replace and increase the golf cart spindle size and length. This can give your golf cart a wider stance, and increase the stability. The wider stance is perfect for those looking to fit those big off-set wheels on your cart, which in turn, can allow you to add wider and taller tires.
What causes a golf cart to jerk while driving?
A Club Car golf cart jerking from the front end of the golf cart occurs due to poor quality of tires. If the tires are worn out or loose, the golf car can start jerking. The uneven height of your front tires can also cause jerking.
Why does my golf cart jerk when I accelerate?
Your 2015 Club Car golf cart jerks when accelerating because of a battery issue or a defective MCOR. A faulty speed sensor could also be the reason for the jerk. The steps that are given here can help you eliminate the jerk in your golf cart. Do a load test on the batteries using a battery load tester.
Does lifting a golf cart make it faster?
Some golf cart owners with a true need for speed will opt to use a lift kit or block lift so that they may install even larger tires. This may add a bit of expense, but a lot of extra speed.
Is a lifted golf cart better?
Higher Speed A lifted golf car usually means larger tires. These tires offer a higher level of speed than regular tires do. The difference in speed varies from a few miles per hour to 20 mph. Speed may not be necessarily beneficial from a safety standpoint, but it allows you to drive faster.
Can you Unlift a golf cart?
Lift kits for golf carts give your cart higher ground clearance, which is great for driving through rougher terrain. It also gives you a more stable riding stance, and you can fit larger tires and offset wheels on your cart. Even a lift of as little as two inches can make all the difference in your ride.