Tune Up the Engine - Replace your cart’s fuel, oil, and air filters before storing it for winter. Check your spark plug and if needed, install a new one. Disconnect your Batteries - Disconnecting your batteries can prevent any electrical problems while your cart is in storage. After disconnecting the batteries, clean terminal connections.
Full Answer
Can I use my golf cart in the winter?
If you stop using your golf cart in the winter, there are a few things you need to do before putting it away. If your cart is electric, you should charge the batteries, top off the water, and if possible, turn off the controller. On E-Z-GO electric carts, there may be a switch on the controller cover that says "Run Tow" Turn that switch to Tow.
How do I Stop my Electric golf cart from overheating?
If your cart is electric, you should charge the batteries, top off the water, and if possible, turn off the controller. On E-Z-GO electric carts, there may be a switch on the controller cover that says "Run Tow" Turn that switch to Tow. Doing that, powers down the controller completely, reducing current drain during storage.
How do you tow an electric golf cart?
If your cart is electric, you should charge the batteries, top off the water, and if possible, turn off the controller. On E-Z-GO electric carts, there may be a switch on the controller cover that says "Run Tow" Turn that switch to Tow.
How to tune up a club car golf cart?
I began to look up steps on how to tune up a Club Car golf cart. 1. Air 2. Fuel 3. Spark These are the basics for any gas-powered engine. These points can be checked BEFORE spending any cash on parts. Begin by raising the seat upon its hinges and lifting the cushion out of the hinge brackets.
Can you leave batteries in golf cart over winter?
The best place to store any golf-cart batteries is by looking for a cool and dry area. It shouldn't be cold, such as an exposed area to the elements, but cool. Cool temperatures will slow the battery's discharge rate. You want a slow discharge so that the battery maintains its charge.
How do you store an electric golf cart for the winter?
Electric Golf Cart Winter Storage TipsClean the vehicle.Park the vehicle in a covered, dry location.Fully charge the battery.Disconnect battery cables.Check the tire pressure.Turn the key switch to the OFF position and remove the key.Turn the power switch under the seat to the TOW position.
What do you do with golf cart batteries in the winter?
Preparing Your Golf Car Battery for StorageStart by moving your car wherever it is going to be stored. ... Leave the forward/reverse switch in the neutral position.Depending on your golf car, it will have either a tow/run or a maintenance/run switch. ... Fully charge the battery and water it with distilled water.More items...•
How do you store a golf cart for 3 months?
7 Tips for Long-Term Golf Cart StorageStep 1: Fully Charge the Battery. The typical golf cart is run by a 6-volt battery. ... Step 2: Disconnect the Battery. ... Step 3: Refill Water Level. ... Step 4: Secure the Cart. ... Step 5: Take Care of The Tires. ... Step 6: Make Sure it's Clean. ... Step 7: Store it in a Secure Place.
Does cold weather affect golf cart batteries?
The cold winter months can slow down the rate of charge/discharge on your vehicle, golf cart and equipment batteries. In addition to affecting rates, colder temperatures also carry the risk of freezing the electrolyte if the battery is not stored properly.
Can I leave golf cart outside in winter?
Can I Leave My Electric Golf Cart Outside In The Winter? If you do not have appropriate shelter for your electric golf cart, or you do not have enough space in your garage, you can leave it outside in the winter.
Can electric golf cart batteries freeze?
Yes, golf cart batteries can freeze. There are a few factors that are going to affect how the golf cart battery freezes, and we will help try to explain that. A battery that is not charged is going to freeze at a much higher temperature than a battery that is charged.
How often should I charge my batteries in my golf cart?
4) To keep your golf car batteries at maximum capacity, use golf cart batteries often. Always remember to do a refresh charge every 45 to 60 days, and even more frequently in hotter climates.
Do you need to winterize a golf cart?
Winterizing your golf cart is crucial if you store it and hope for a quick start up in the spring. While the procedures are a bit different for a gas vs. an electric model, you must clean it and attend to the fuel source and tires for best results.
How long can golf cart batteries sit without charging?
Still, golf cart batteries should be recharged after four hours of use.
Should I disconnect golf cart batteries for storage?
It's important to either disconnect the batter- ies from the golf cart while in storage, to re- move any parasitic loads which can discharge the batteries, or based on the type of charger you have, keep the charger plugged into the golf cart.
Can you put a trickle charger on a golf cart?
If you tend to use the golf cart during the warmer months and store it during the winter, pick a trickle charger to make the battery last longer. These chargers connect to the battery over weeks or months at a time. They provide enough power to the battery to keep it charged but without harming the internal components.
How do you store lithium batteries for the winter?
Storing them in the proper temperature: Keep your lithium batteries in a place that does not get colder than 32 degrees Fahrenheit or warmer than 80 degrees Fahrenheit.
How do you store a lithium ion battery on a golf cart?
Lithium-Ion batteries are a wonderful advancement compared to lead acid batteries in battery technology, but they need some tender love and care. Your Cart Tek user manual for golf cars suggests that you always store your golf cart batteries in a cool, dark, dry environment and avoid extreme temperatures.
How often should you charge an electric golf cart?
4) To keep your golf car batteries at maximum capacity, use golf cart batteries often. Always remember to do a refresh charge every 45 to 60 days, and even more frequently in hotter climates.
Can you put a trickle charger on a golf cart?
If you tend to use the golf cart during the warmer months and store it during the winter, pick a trickle charger to make the battery last longer. These chargers connect to the battery over weeks or months at a time. They provide enough power to the battery to keep it charged but without harming the internal components.
What is a golf cart?
Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... link to Club Car DS Wiring Diagrams 1981 To 2002.
Does the G21 have a filter?
The G2, G9, G11, and the G21 model Fuel tank has a screw-in filter that is difficult to reach. It is advisable to remove the 2-4 bolts holding the tank in and pull the tank out to drain and replace the filter. Please note that on ALL models using the screw-in filter the tank will need to be drained.
What is a golf cart?
Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... link to Club Car DS Wiring Diagrams 1981 To 2002.
How to start a car when it's cold?
Start It Up. After you have all of the safety measures in place, reach in and press the accelerator with your hand and the engine will begin to turn over. If the engine is still cold, you may need to use your other hand and press the choke button until it fires off.
How to set air mix and throttle screw?
To set the air mix and Throttle screw, we need to use the Torx T15 and remove 2 screws holding the cover that hides the adjustments. After removing the screws, pick up the right edge of the cover and pivot it over and off.
What to do if your air filter is too oily?
If the filter is not too oily but just dusty, use compressed air to blow the dirt out of it. If you can’t get enough of the contaminant out of the fibers, you will need to replace it.
Where is the air filter on a 1996 DS Club Car?
On the 1992 – 1996 model DS Club Car with the FE290 Kawasaki engine, this is located on the driver’s side of the opening, and it is a black plastic box with two thumbscrews at the back. Turn each of these 90 degrees to unlatch and the back swings out.
Can you start a motor without the cart taking off?
When the microswitch is engaged in the “pressed” position, and the lever is in the “Neutral” position, you can start the engine without the cart taking off. It would be safest to chock the wheels to prevent an accidental runaway should you bump the lever while running the engine.
What is solenoid in golf cart?
The solenoid is a wire acting as a magnet when carrying an electric current and is primarily found in gas powered golf carts rather than electric. This ignition is key – literally – for starting your engine.
Is it illegal to drive a golf cart with a mirror?
The mirrors to your golf cart seem unnecessary due to such little traffic on the golf lanes, but it is illegal to operate the vehicle with non-working mirrors. Observe the side mirrors and wing mirrors on the windshield, as well as making sure the thumbscrews are tightened so no visible obstruction is present.
What is the 'Run/Tow' switch on a golf car?
If your golf car is an electric RXV, make sure the 'Run/Tow' switch is set to the 'Run/Storage' position. Remember, if it's left in the 'Tow" position, it will continue to drain the batteries over time.
Do golf cart batteries self discharge?
Before leaving your golf cart, ensure that the battery is clean, fully charged, and has been disconnected from any source of electrical drain. Batteries will continue to self-discharge, even during periods where they are not used or are being stored away. If you don't disconnect your battery's wires, you may find yourself with a golf cart battery ...
Can you put away a golf cart in winter?
If you're the type to put away your golf cart or ATV for winter storage, there are a few steps you'll need to take to ensure that your battery stays in peak condition, even if you're not heading out on the course or into the woods during the colder months. We've spoken before about winterizing your ATV, but we haven't really taken a close look ...
What to look for when using a golf cart in winter?
While you are using your golf cart for winters, keep an eye out for smaller issues like missing screws, broken bolts, or loose nuts. These little things may seem unimportant, but they can cause serious problems down the road.
What happens when you drive a cart in winter?
Driving your cart in winter means you will most likelydeal with road salt, leading to corrosion on your frame and other engine parts. A quick corrosion protection spray will help prevent salt-laden moisture from sticking to metal parts.
What is a golf cart enclosure?
Golf cart enclosures provide proper doors and frame to your cart, and that’s why it’s a must have accessory for winter rides. The enclosure offers safety in case of snow, rain, or just plain cold.
What is the most important part of a golf cart?
Even though the speed controller is probably one of the most important parts on your golf cart, not many people understand how they work or what they do. In this guide, we breakdown the speed controller so you have a complete understanding of their functions, and hopefully come out with the knowledge to make an educated decision on the type ...
How much horsepower does a golf cart need?
These vehicles will have motors with 5 to 10 horsepower, and controllers that can deliver 300 to 600 AMPS.
What does a battery controller do?
With the controller you are able to control your acceleration and deceleration, as well as the speed at which your vehicle moves.
Why is a speed controller important?
The Importance of the Speed Controller. The main objective for the speed controller is, as the name implies, to control the vehicle speed. Let’s say you try to operate that old DC motor without a controller. Any time you apply throttle, the full battery current and voltage is sent to the motor.
What is the function of a speed controller?
In addition to controlling the vehicles speed, there are a few other functions that speed controllers can offer, regardless of the motor you are using. Battery Current Limiter: This protects the battery from excessive discharge. This also pulls back the battery current as it depletes, which prevents cell damage.
Can you program a speed controller yourself?
Beyond the already mentioned functions of the speed controller, there are many other features available when programming the controller yourself. If you have a computer or a handheld programmer, then changing the settings on your speed controller is super easy.
Do AC motors require a sensor?
Device Support on SPF ( Speed of Position Feedback): AC motors can require a sensor in order for the controller to operate smoothly and efficiently.