The Right Way To Winterize Your Golf Cart
- Clean the Cart. Dirt and grime become harder to remove the longer they’re allowed to stay, so you’ll want to thoroughly...
- Check the Brakes and Tires. You should also check the brakes and tires of your cart. Winter is the best time to send...
- Empty the Gas Lines. This tip will only apply to you if you have a gas-powered golf cart.
- Clean the vehicle. Before storing, it is imperative that you clean your golf cart, inside and out. ...
- Drain the fuel. Drain the gas from your cart. ...
- Perform a full check up. ...
- Prepare the battery. ...
- Inflate the tires. ...
- Ensure the cart won't move. ...
- Park the vehicle in the proper position.
How to store your golf cart for the winter?
Oct 19, 2021 · The Right Way To Winterize Your Golf Cart Clean the Cart. Dirt and grime become harder to remove the longer they’re allowed to stay, so you’ll want to thoroughly... Check the Brakes and Tires. You should also check the brakes and tires of your cart. Winter is the best time to send... Empty the Gas ...
How to jumpstart a golf cart?
Aug 02, 2011 · When the season starts to come to an end are you ready to winterize your cart? Not sure where to start? Dan is back to show you how to prepare your cart for ...
How to winterize your scooter?
Jan 13, 2021 · Drain the Fuel Tank- Drain the gas and run your golf cart engine until it's empty. If your cart has a shut-off valve, switch it off. Tune Up the Engine - Replace your cart’s fuel, oil, and air filters before storing it for winter.
How to quiet a golf cart?
Gasoline powered golf cars have their own particular concerns with grease and dirt and battery corrosion. A good place to start your winterization is to …
Do you need to winterize a gas golf cart?
Can you leave a gas golf cart outside in the winter?
How do you drain a golf cart gas tank?
- Put your movement switch in the neutral and service positions. ...
- Run the cart until all of the fuel is used to remove it from the fuel lines, pump, and carburetor.
- Remove the negative cable from your battery.
- Drain fuel from the carburetor drain screw with a pan.
How do you store a gas golf cart in the summer?
- Charge Batteries Completely. a. Turn Key OFF and Remove Key. ...
- Refill Water Levels. a. Refill water levels to 1/4" above plates, using DISTILLED WATER ONLY. ...
- Disconnect Battery Charger. a. ...
- Disconnect Main Positive and Negative Connections. a. ...
- Lift Golf Cart Of The Floor. a.
How do I store my golf cart for the winter?
- Clean the vehicle.
- Park the vehicle in a covered, dry location.
- Fully charge the battery.
- Disconnect battery cables.
- Check the tire pressure.
- Turn the key switch to the OFF position and remove the key.
- Turn the power switch under the seat to the TOW position.
How do I winterize my EZ Go golf cart?
- Replacing the fuel and air filters.
- Changing the oil and filter.
- Removing the old spark plug, pouring a half-ounce of clean oil in the hole and installing a new plug.
- Draining the fuel tank and running the engine until it stops in order to remove gas from the system as old gas can gum up the fuel lines.
How do you drain a gas tank without removing it?
- Take a separate, smaller tube that is rigid and resists kinking.
- Force this tube down until it hits the blockage, then twist, push, and force the tube around the metal bulb blocking entry to the tank.
How do you get old gas out of a gas tank?
- Place a certified gas disposal container on a level surface.
- Place the input tube of the siphon pump into the gas tank. ...
- Place the output tube into the container.
- Pump the siphon until all of the gas has been removed.
How do you clean out a gas tank without removing it?
- Read the instruction manual. Before starting, find the instruction manual and see how to disconnect the fuel tank lines. ...
- Drain the fuel tank. ...
- De-grease your fuel tank. ...
- Pressure wash your fuel tank. ...
- Adding a cleaning solution. ...
- Leave the tank. ...
- Rinse the fuel tank. ...
- Dry the fuel tank.
How do you store a golf cart for 6 months?
- Step 1: Fully Charge the Battery. The typical golf cart is run by a 6-volt battery. ...
- Step 2: Disconnect the Battery. ...
- Step 3: Refill Water Level. ...
- Step 4: Secure the Cart. ...
- Step 5: Take Care of The Tires. ...
- Step 6: Make Sure it's Clean. ...
- Step 7: Store it in a Secure Place.
Can you put a trickle charger on a golf cart?
Can a golf cart be stored outside?
What happens when you drive a cart in winter?
Driving your cart in winter means you will most likelydeal with road salt, leading to corrosion on your frame and other engine parts. A quick corrosion protection spray will help prevent salt-laden moisture from sticking to metal parts.
What is a golf cart enclosure?
Golf cart enclosures provide proper doors and frame to your cart, and that’s why it’s a must have accessory for winter rides. The enclosure offers safety in case of snow, rain, or just plain cold.
Do you need to check brakes in snow?
Do not forget to check your brakes to ensure they are in good condition and clean any dust or dirt on them. It is essential to check and replace your brakes before using them in snow.
Electric Vehicles
Turn the key switch to the OFF position, remove the key and leave the Forward/Reverse switch in the NEUTRAL position during storage.
Vehicles NOT connected to chargers
If the chargers are not going to be used to maintain batteries, the Tow/Run switch should be placed in the TOW position and the batteries disconnected after a full charge to prevent any parasitic loss during storage.
Gasoline-Powered Vehicles
Turn the Key Switch to the OFF position, remove the key, and leave the Forward/Reverse switch in the NEUTRAL position during storage. Perform all required preventive maintenance procedures.
Step 1: Thoroughly Clean your Golf Cart
When it comes time to store your golf cart, be sure that it is clean. Use soap, water, degreaser, and other cleaning products as needed to wash away dried mud, sand, grime, and dirt on the golf cart.
Step 2: Winterizing your Golf Cart
If your cart is gas, drain gasoline from all plumbing and parts from the carburetor to the fuel tank. Fuel that is left to sit in the cart over the winter can cause gunk to form in small parts of the carburetor or the fuel pump. If your golf cart has a shut-off valve, make sure it is in the "off" position.
Step 3: Finishing Touches
Disconnect battery cables to prevent any unnecessary electrical problems from occurring while in storage. If the cart will be checked on periodically, leave the batteries connected and hook the cart up to a maintainer. Inflate tires to the proper pressure before storing to maintain the shape of the tires when it is not driven.