Locate the red and black wires on the back of your battery pack and connect them. Connect the black wire to the negative terminal and the red wire to the positive terminal to complete the circuit. You should leave the cart switched off while you are working on it.
Full Answer
Where can I find golf cart wiring diagrams?
Cartaholics has all gas golf cart wiring diagrams and all electric golf cart wiring diagrams in the Resource Sections of the Forum. Cartaholics also has a Golf Cart Battery Charger Wiring Diagram for all model golf cart battery chargers.
How to install a battery meter on a golf cart?
Steps to install a golf cart battery meter are: Once you have the meter of your choice, select the mounting location. Disconnect the positive terminal on the battery bank. Run the wires from the meter location to the battery terminal points. Make the connections and test. Mount the meter and arrange the wiring.
Where can I buy battery cables for my Petes golf cart?
Our team is always happy to advise you. And, should you need Battery Cables or Charger Wires, Battery Hold Down Brackets, or even Golf Cart Battery Watering Systems, these items are all available at www.PetesGolfCarts.com. Remember, all orders over $99 always ship free.
Can You charge a golf cart battery with a car charger?
Even if you are able to drive your golf cart and even if you just got brand new batteries, we'd suggest getting a 6V OR 12V CAR BATTERY CHARGER AND MANUALLY CHARGING UP THE GOLF CART BATTERIES FOR A COUPLE MINUTES EACH. This process should give the batteries enough voltage so that your golf cart battery charger can then take over.
How do you wire a golf cart charger?
3:006:17How to Install an On-Board Golf Cart Charger | ASK DAVE - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo we'll attach the red lead to the first battery positive and the black lead to the last batteryMoreSo we'll attach the red lead to the first battery positive and the black lead to the last battery negative terminal.
What is an inhibit wire?
Inhibit wire is also known as 'Lockout wire' and is used by many vehicles to prevent operation of the vehicle while charging.
How do you hook up a battery tender to a golf cart?
2:069:44Battery Tender trickle charge and maintainer installation - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe bolt that goes on or the nut that goes onto the bolt that tightens that clamp around it but youMoreThe bolt that goes on or the nut that goes onto the bolt that tightens that clamp around it but you can keep the battery hooked up and that's really important because on modern day cars.
Where is the charging port on a Club Car golf cart?
1:005:1348V Club Car Not Charging, Club Car Charger and On Board ComputerYouTubeStart of suggested clipEnd of suggested clipBut rather is located on the golf cart itself. And is called an obc or onboard computer it residesMoreBut rather is located on the golf cart itself. And is called an obc or onboard computer it resides between the plug receptacle. Where you plug your charger.
How do you wire start and stop?
0:547:43Basic Motor Control: 3 Wire Start Stop Circuit (updated) - YouTubeYouTubeStart of suggested clipEnd of suggested clipOne side of our motor starter coil okay. So power comes up to our stop stop button and now the stopMoreOne side of our motor starter coil okay. So power comes up to our stop stop button and now the stop button has a normally closed contact that means power travels through the normally closed.
How do you wire a motor start stop?
0:429:19How to Wire a Start Stop Motor Control Circuit. - YouTubeYouTubeStart of suggested clipEnd of suggested clipA button 3 then we show a wire from the other side of that stop contact go into both a normally openMoreA button 3 then we show a wire from the other side of that stop contact go into both a normally open of our start contact. And a normally open of our motor starter.
Will a trickle charger charge a golf cart battery?
If you tend to use the golf cart during the warmer months and store it during the winter, pick a trickle charger to make the battery last longer. These chargers connect to the battery over weeks or months at a time. They provide enough power to the battery to keep it charged but without harming the internal components.
How do you use a battery charger on a golf cart?
Open the golf cart to expose the batteries. This is a 36-volt golf cart with six 6-volt batteries. ... Take the battery charger and verify that the battery charger voltage is 12 volts. ... Turn the battery charger on and the charger will charge two 6-volt batteries at a time.
Can you put a battery maintainer on a golf cart?
36 Volt and 48 Volt Golf Cart Maintainers These units are designed for long term battery maintenance on golf cart or other 36 or 48 volt battery pack systems of 10 to 300 amp hours. They supply a float voltage (see tutorials), and pass whatever current is required up to 2.5 amps to maintain that voltage.
How do you wire a golf cart USB port?
1:573:15USB port installed on a EZGO Express S4 golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipGot the other supplies over here at the cart. Got the plug the backing ring the cap 10 amp fuse iMoreGot the other supplies over here at the cart. Got the plug the backing ring the cap 10 amp fuse i think that'll be plenty for this. And this uh distribution block even come with some labels.
How do you test a golf cart charging port?
Set the voltage meter to DC Volts 200V. Take voltage from the positive side of the charger port/receptacle to the negative on the battery pack loop of batteries. There should be voltage read on the battery back, this may vary based on the charge.
How do you bypass a golf cart charger?
2:544:33How to Bypass On Board Computer | Club Car Precedent Golf Cart | OBCYouTubeStart of suggested clipEnd of suggested clipWe can cut it. Real close to the OBC. And then put a ring terminal. As. I think that's a 5/16 holeMoreWe can cut it. Real close to the OBC. And then put a ring terminal. As. I think that's a 5/16 hole in it so it goes right over this tournament either way we've got to get this wire.
Should I leave my golf cart plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
How do you store an electric golf cart in the summer?
How To Store Your Golf Cart During The SummerCharge Batteries Completely. a. Turn Key OFF and Remove Key. ... Refill Water Levels. a. Refill water levels to 1/4" above plates, using DISTILLED WATER ONLY. ... Disconnect Battery Charger. a. ... Disconnect Main Positive and Negative Connections. a. ... Lift Golf Cart Of The Floor. a.
Can you charge a golf cart while driving?
No. You should turn your golf cart off when charging its batteries. Trying to charge a golf cart while it is running is a pointless exercise, as the battery will be draining while you're trying to charge it. A golf cart should only be turned on once its batteries are fully charged.
How do you charge a 48 volt battery bank?
0:402:35Ask PYS - How Do I Charge a 48V Battery Bank With a 12V Alternator?YouTubeStart of suggested clipEnd of suggested clipBasically converter to charge from a 12 volt alternator to 48 volt alternator.MoreBasically converter to charge from a 12 volt alternator to 48 volt alternator.
What is a golf cart?
Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf...
When did golf carts evolve?
Club Car Golf carts have evolved many times since 1975, and although the basic electrical design has stayed close to the same, there are small differences. These differences are important when troubleshooting your cart.
What is a speed controller?
The speed controller measures out current and battery voltage to the electric vehicles' motor to raise and lower speed on the golf cart. It monitors the state of the motor and generates signals to...
Where is my User’s Manual for my golf cart battery charger?
Our manufacturer does not provide owner’s manuals. Here are the links to the Lester charger manuals (they are also linked to on our product pages):
How long does it take to charge a golf cart?
It depends on three factors, 1) the quality of your batteries, 2) how discharged your batteries are and 3) the quality of your charger. If you have 5 year old batteries that are very discharged and you have a lightweight 2-5 amp charger, it may take a very long time (10 hours or more). If you have brand new batteries, they are 20-30% discharged and you've got a heavy-duty charger, it can be pretty quick (1-3 hours). Again, it depends on all of the above factors, so it really could vary quite a bit.
How Do I Troubleshoot My Golf Cart Battery Charger if It Isn't Working?
Just so you know, this situation happens EVERYDAY. The first question we always ask is, how long has it been since you've charged your batteries? We ask this because often times if it has been a while (a couple weeks or more), or if you just got brand new batteries, or if your batteries have been really run down recently, it is possible that the batteries may not have enough voltage in them for the charger to start working. An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
What are some symptoms of a bad golf cart battery charger vs. bad batteries?
Bad Batteries: IN GENERAL, if the charger doesn't kick on or show any signs of life when you plug it into your cart, this is most likely a battery/connection issue. Learn more about the signs of a bad golf cart battery.
Will the golf cart charger automatically stop charging once the batteries are fully charged?
Yes. All automatic chargers are designed to charge your batteries until they are fully charged and then stop charging. So you do not need to manually shut off the charger or worry about overcharging your batteries. All Lester chargers are made with a number of internal safety mechanisms that ensure that they will never overcharge batteries.
What if I charge my batteries until my battery charger stops charging, but my golf cart won’t drive very far?
You probably need to test your batteries and likely will need to get new golf cart batteries.
Should I charge the golf cart after each use?
Yes. It is healthy for the batteries to be fully charged at all times. So, you should charge your golf cart every night. Automatic golf cart chargers will shut off once the batteries are fully charged, so there isn't a concern that they will be over charged.
How to install a golf cart battery meter?
Steps to install a golf cart battery meter are: Select and obtain your battery gauge meter. Once you have the meter of your choice, select the mounting location. Disconnect the positive terminal on the battery bank. Prepare the opening if you are mounting in the dash. Run the wires from the meter location to the battery terminal points.
What is a golf cart?
Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... link to Club Car DS Wiring Diagrams 1981 To 2002.
What is the C terminal on a battery meter?
Typical battery meters come with either two or three contacts on the back. One of these is a common or a “C” signal terminal and the other two are the positive terminal and the negative terminal (See illustration below). the “C” provides power to the meter to operate and doesn’t involve measurement input voltage at all. It is best to wire this terminal to the Power contact on the ignition switch. This will allow the key to switch the meter on and off when the cart is in use.
How many wires are needed for a battery meter?
LED and digital style battery meters only come with about 6 to 12 in of wire pigtails, so you will need to add extra wire to reach the terminals necessary to power the meter.
How does a battery meter work?
Battery meters indicate the voltage level of your battery bank and inform you when it is time to recharge. They act as a battery charge indicator as well and give a visual confirmation that the batteries are charging. The input voltage comes directly from the battery bank through the signal wires, and in the case of analog meters, move the needle from empty on the far left too full on the far right. The digital meters will give you a number or a moving bar display a partial charge to a full charge.
Where do the positive and negative wires go on a switch?
Watch closely to make sure the positive wires go to positive terminals, and negative wires go to the negative terminal or ground. A lug connector crimped on the terminating end of the wire makes a professional connection on the switch and battery connection terminals.
Can you skip wires on a golf cart?
Check your manual to see if you can skip running wire to the battery bank of the cart .