When the drive belt wears to narrow or the edges start to curl it can cause the golf cart to jerk when taking off. You could also have a problem with one of the clutches. You must log in or register to reply here.
Full Answer
How to adjust the drive belt on an EZGO golf cart?
How to Adjust the Drive Belt on an EZGO Golf Cart There is no way to adjust a drive belt, so it’s important to get the right size belt in the first place. To be sure, visit your local mechanic or call a certified technician to help you get the right drive belt for your EZGO golf cart.
Does EZGO have a problem with their clutches?
Anyways I still hav the jerky take off & poor control of slow speed I seem to remember EZGO had a problem with one of the clutches on some carts in 2004 and were replacing them free if the cart was still under warranty. I'll take a look and see if I can find the info on the clucthes...
Why is my EZGO golf cart losing top speed?
A loose drive belt can result in your EZGO Golf Cart to lose top speed and underperform. If the drive belt is the right model but it seems to be too loose then it could be because there is something stuck in the clutch or there is some damage in the clutch. In this case you’ll need to call a certified technician to inspect your golf cart.
Why does my electric golf cart jerk?
As the Precedent is an electric golf cart, the cause for jerking can be directly related to the batteries or other electronic components. Following are the steps you should take to ensure efficient functioning.
What causes a golf cart to jerk?
A Club Car golf cart jerking from the front end of the golf cart occurs due to poor quality of tires. If the tires are worn out or loose, the golf car can start jerking. The uneven height of your front tires can also cause jerking.
Why does my golf cart jerk when I accelerate?
The most common problem here is likely an issue with the batteries. If the battery is low on power or doesn't distribute power properly, then the cart may jerk as it accelerates. Thankfully, replacing the battery should be a good enough fix to manage this problem without difficulty.
How do you adjust the belt tension on a golf cart?
0:152:00How to Check the Belts in your Gas Golf Cart | Golf Cars UnlimitedYouTubeStart of suggested clipEnd of suggested clipDown below and you don't want to press the moderate pressure on that belt you're gonna want to seeMoreDown below and you don't want to press the moderate pressure on that belt you're gonna want to see about 3/16 to 1/4 inch of deflection. There no more than that that'll be your proper.
How do I know if my EZGO golf cart solenoid is bad?
First, turn on the ignition while looking for a reading on the smaller terminals. If nothing is appearing, then press on the accelerator. If the needle doesn't move, then the problem is not with the solenoid. If it jumps and displays full voltage, then the solenoid is the problem and should be replaced with a new one.
What makes a golf cart surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
How do you stop a golf cart from bouncing?
You can easily take care of this problem by deflating your front tires until the sidewalls of your cart are about 1/2 the front walls. This should help get the beads seated. Now, you can inflate your tires back. The bounce should have disappeared.
Can you adjust a clutch on a golf cart?
If you are unsure about removing the drive belt or the clutch, then you can adjust it. Just take out the belt and wound it again with the secondary clutch according to the requirements, and your problem should be fixed.
How much slack should be in a golf cart belt?
The reason for a Club Car drive belt being too tight can be because the drive belt is too small for the golf cart. The way to check if the belt is fitted correctly is to push the belt down with one finger at the center between the clutches. It should not deflect more than 1.5inches. It should not be less as well.
How do I fix my golf cart belt?
2:255:57Changing the Drive Belt and Starter Generator Belt 2008 EZGO TXTYouTubeStart of suggested clipEnd of suggested clipJust. First put the belts on and then tilt the starter generator as far as you can and tighten thatMoreJust. First put the belts on and then tilt the starter generator as far as you can and tighten that nut up. By hand first and then use the wrench to get it a little bit.
Where is the reset button on a ezgo golf cart motor?
Locate the motor Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.
How can you tell if MCOR is bad?
With the cart in neutral, slowly depress the gas pedal. You should verify that the throttle moves from 0% to 100% in a smooth manner. If you see it jump around (ie. 17% up to 30% or back to 10% erratically) you have a bad MCOR.
Can a golf cart solenoid click and still be bad?
Usually, you'll be able to hear the solenoid clicking both on and off whenever you switch your ignition. But if you don't hear anything? It's likely that the solenoid can no longer send electricity out to power the golf cart. In some cases, this happens because the coil of the battery is worn out or is too old.
Why does my electric golf cart jerk?
1] Water-logging in some of the components of your electric golf cart can result in jerking. Sensors and micro switches installed near the vehicle’s floor mat can malfunction due to water interference, which causes jerks when you accelerate.
Why does my golf cart jerk?
A Club Car golf cart jerking from the front end of the golf cart occurs due to poor quality of tires. If the tires are worn out or loose, the golf car can start jerking.
Why does my Club car golf cart jerk when accelerating?
The main reason why a Club car golf cart jerks when you accelerate it is due to a misaligned Inductive Throttle Sensor or dirty clutch.
Why does my car's clutch stick up?
Frequent interaction with the clutch while driving leads to its sticking and malfunctioning. During motor ignition, the clutch can stick up, and the cart starts jerking forward and reverse.
What to do if your golf cart tires are uneven?
The beads in the tires can also discomfort while driving your golf cart. If your tires have uneven beads, start by deflating them until the air is halved.
Why does my club car jerk forward and reverse?
As Club Car produces electric golf carts, water-logging into the electrical components can cause malfunction of the vehicle and cause jerking in forward and reverse.
How much does a DS golf cart weigh?
The DS produces both battery and gas-powered golf carts. The electric DS weighs 498 pounds, whereas the Gas DS weighs 619 pounds. The speed ranges between 12-15 miles/hour for the gas model, whereas 12-19 miles/hour for the electric one. Jerks can occur in the DS Car for the following reasons.
What is an EZGO golf cart?
Your EZGO golf cart is probably a more integral part of your life than you realize. If you live in a residential neighborhood or gated community, chances are that you use your golf cart for a wide variety of purposes beyond simply golfing―to take a trip to the nearby grocery store, to drive a mile or two to the country club or tennis courts down the road, to act as a makeshift hunting vehicle during hunting season, or even to fetch your mail in rainy or snowy weather.
What does the Ezgo manual say about golf cart batteries?
The EZGO manual says that, “First, a battery that performs poorly and is outside of the manufacturer’s specification should be identified in order to replace it under the terms of the manufacturer’s warranty.” This means that every manufacturer retains its own unique requirements, specs, and timelines. The less you procrastinate on troubleshooting your golf cart, the easier it will be to get faulty items repaired or replaced.
What is the recommended tire pressure for an EZGO golf cart?
The standard recommended pressure of an EZGO cart’s tires ranges from 18 to 22 PSI.
How many cycles does a golf cart battery take?
Your golf cart’s battery needs to mature completely before it can operate at its maximum levels. This can take as many as 100 full charge cycles, so be patient if the brand new golf cart you just purchased isn’t quite living up to its battery expectations.
How to reset a golf cart motor?
This panel door is generally secured with several screws . Carefully remove them with a screwdriver. Then reset your cart’s motor; most golf cart electric motors contain a special button designed to reset the motor by behaving like a tiny circuit breaker.
Why is my golf cart foot pedal so smooth?
If you are having issues with the smoothness of your foot pedal, it may simply be due to the air quality of your surroundings and should eventually fix itself. If your golf cart is a few months or years old, the stickiness may be due to constant pressure.
What to do if your charger is not reading voltage?
You can try resetting the circuit breaker or replacing the socket or charger entirely.
Safety Notice
Before attempting any maintenance or repairs on your golf car it is imperative that you consult the owner’s manual and follow all the safety guidelines. The following are a few safety tips, but may not be all inclusive.
Check Battery Terminal connections
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
Check Battery Voltage
Once you’ve cleared all the battery terminals of corrosion, you’ll next need to check that your batteries are providing the correct amount of voltage. This can be accomplished using a simple voltmeter.
Check Resistor Coil (For Older 36V Golf Carts)
If you have an older 36V golf car that doesn’t use a speed controller, and you’ve completed all the steps above and your golf car is still jerking in set to forward, but works fine when the direction is changed to reverse you may have a bad resister coil.
Why does my Club Car golf cart jerk when taking off?
Your Club Car golf cart jerks when taking off, because of a faulty MCOR or low battery charge. Wiper arms that are adjusted incorrectly can also cause a golf cart to jerk.
Why does my cart jerk?
Low battery charge. Check the overall battery pack charge and also the charge of each battery separately. Sometimes, low charge batteries can cause the cart to jerk. Charging the pack or the concerned battery/batteries to full voltage is likely to help.
Why does my Club Car DS shake when accelerating?
Your Club Car DS may shake when accelerating because of an overly tight drive belt or a clutch issue. Sometimes, this problem happens when the carburetor fails to mix the fuel properly.
How to fix club car precedent?
You can fix a Club Car Precedent that jerks when taking off by checking and fixing the MCOR and batteries. These are the two key parts that often cause the jerking action.
Why does my club car jerk in reverse?
Your Club Car golf cart jerks in forward and reverse due to a sticky drive clutch or a high gear solenoid problem. A missing cable between the resistor and the forward/reverse selector can also cause the jerking in both directions.
How to fix jerk on 1985 club car?
If you have a 1985 Club Car, the jerk can be curbed by doing a high gear solenoid replacement. The solenoid will be in ON position when the cart moves both in forward and reverse directions. This solenoid is present on the passenger side of the golf cart.
How to fix a club car DS that jerks when taking off?
You can fix a Club Car DS that jerks when taking off by correcting the oil level. The following steps help to solve the jerking in 1988 lifted Club Car DS. Check the oil level of the golf cart and do a refill if needed. There is no need to overfill the oil. It’s enough if you fill it to just the required level.