How do you fix jerky in a golf cart?
One way to fix the jerky acceleration on a Club Car golf cart is to check if the battery charge is dropping and the battery is nearly dead under load. A load test will help you determine this. If recharging the batteries doesn't help, getting a new battery or new batteries fitted should work.
Why does my electric golf cart hesitate when I accelerate?
If your cart seems to run fine for a few feet, and then it stutters, it is most likely the batteries. If it is not the battery, then check if it is the speed controller or the resistor. If it is the controller, then you will need a replacement. Otherwise, upgrading the resistor can also solve the problem.
Why does my golf cart bounces when driving?
One of the common issues associated with the golf cart bounce is the tire. If the tires are not aligned properly or the threading has worn out, it could cause the cart to bounce. Examine your tires carefully to identify the issue and if required get your tire replaced or realigned.
Why does my electric golf cart surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
How do I know if my EZGO controller is bad?
Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor. If there is no voltage, the controller is bad and must be replaced.
Why does my golf cart shake when I accelerate?
The common cause of golf cart vibrates when accelerating due to damaged inner CV joints, broken motor mounts, unbalanced tires or a bent driveshaft. To fix this issue, you should check the CV joints of your golf cart. Check the driveshaft, whether this is in good condition or not. The CV joints should be well greased.
Do golf cart tires need balancing?
All four wheels must be in balance for best performance. The balancer is simple, with a handle that allows you to spin the wheel and see whether it's appropriately balanced. It is unbalanced if the wheel wobbles in any direction or stops spinning. If you feel any vibration, balance your tires.
What PSI should golf cart tires be?
15 to 25 pounds per square inchThese tires typically use anywhere from 15 to 25 pounds per square inch (PSI), with the average being 20 to 22 PSI. For golf carts driven off-road or on rougher terrain, it's not uncommon to under-inflate tires to gain additional traction. However, under-inflated tires wear down prematurely.
How can I improve my golf cart suspension?
How To Make A Golf Cart Ride Smoother (10 Ways)Correct Tire Pressure. ... Replace Worn Out Shocks and Struts. ... Check the Fluid and Filter. ... Replace the Clutch. ... Flat Spot in Tire. ... Tire Damaged or Out of Line. ... Worn Out Suspension Bushings. ... Check Your Lift/Tire Combo.More items...
How long do electric golf cart motors last?
However, their durability is the same as that of an electric vehicle, which is nice for those who are interested in gasoline or diesel golf carts. That said, some manufacturers claim that the average golf cart will last 30-40 years if the engine is properly maintained, repaired, or even replaced.
How long should batteries last in an electric golf cart?
That all being said, properly maintained battery packs in fleet carts tend to last about 4-6 years while private owners tend to get about 6-10 years out of their battery packs. Other major factors include the type of options on the cart that may increase the draw from the battery pack.
Where is the reset button on EZGO golf cart?
Locate the motor Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.
Why does my electric golf cart go slow uphill?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.
Why is my golf cart not going full speed?
Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
How does the throttle work in an electric golf cart?
Just like the gas-powered car throttle, the throttle is an inductive sensor. It pushes the acceleration lever to send electricity to the solenoid and speed controller and drives the motor. Electric Motor. The electric motor requires the right amount of electricity to turn the cart's wheel.
Safety Notice
Before attempting any maintenance or repairs on your golf car it is imperative that you consult the owner’s manual and follow all the safety guidelines. The following are a few safety tips, but may not be all inclusive.
Check Battery Terminal connections
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
Check Battery Voltage
Once you’ve cleared all the battery terminals of corrosion, you’ll next need to check that your batteries are providing the correct amount of voltage. This can be accomplished using a simple voltmeter.
Check Resistor Coil (For Older 36V Golf Carts)
If you have an older 36V golf car that doesn’t use a speed controller, and you’ve completed all the steps above and your golf car is still jerking in set to forward, but works fine when the direction is changed to reverse you may have a bad resister coil.
Why does my Club Car golf cart jerk when taking off?
Your Club Car golf cart jerks when taking off, because of a faulty MCOR or low battery charge. Wiper arms that are adjusted incorrectly can also cause a golf cart to jerk.
How to fix a club car DS that jerks when taking off?
You can fix a Club Car DS that jerks when taking off by correcting the oil level. The following steps help to solve the jerking in 1988 lifted Club Car DS. Check the oil level of the golf cart and do a refill if needed. There is no need to overfill the oil. It’s enough if you fill it to just the required level.
Why does my Club Car DS shake when accelerating?
Your Club Car DS may shake when accelerating because of an overly tight drive belt or a clutch issue. Sometimes, this problem happens when the carburetor fails to mix the fuel properly.
How to fix club car precedent?
You can fix a Club Car Precedent that jerks when taking off by checking and fixing the MCOR and batteries. These are the two key parts that often cause the jerking action.
Why does my club car jerk in reverse?
Your Club Car golf cart jerks in forward and reverse due to a sticky drive clutch or a high gear solenoid problem. A missing cable between the resistor and the forward/reverse selector can also cause the jerking in both directions.
How to fix jerk on 1985 club car?
If you have a 1985 Club Car, the jerk can be curbed by doing a high gear solenoid replacement. The solenoid will be in ON position when the cart moves both in forward and reverse directions. This solenoid is present on the passenger side of the golf cart.
How to fix jerky acceleration on club car?
One way to fix the jerky acceleration on a Club Car golf cart is to check if the battery charge is dropping and the battery is nearly dead under load. A load test will help you determine this. If recharging the batteries doesn’t help, getting a new battery or new batteries fitted should work.
How do I push my E-Z-Go Golf Cart?
It can be frustrating when your battery is flat and your golf cart will not roll. To push it to the nearest charging or gas station, you need to release the motor brake. Follow these easy steps to do that.
Why is my E-Z-Go golf cart losing power?
E-Z-Go golf carts often lose power because of corrosion or loose cables. If the connecting wires in electrical circuits break, your battery will lose power. The same will happen if you have a short circuit in the ignition system. Here are steps you can use to ensure that the system is working correctly.
How do you test an E-Z-Go Golf Cart Controller?
Depending on the E-Z-Go Golf cart you own, there are two types of controllers, the Drive control systems and the Precision Drive System. Only E-Z-Go carts made before 1994 have a Drive Control System. If you notice that your E-Z-Go golf cart is not running at a constant speed, you should troubleshoot the controller to identify the problem. Here are the steps you should use to test your E-Z-Go golf cart controller.
Why does my E-Z-Go Golf Cart feel sluggish when accelerating?
The reason why your golf cart is sluggish during acceleration or stalls depends on whether it is a gas cart or an electric one. Here are the reasons for sluggishness in both.
Why won’t my gas golf cart charge the battery?
If you own a gas E-Z-Go golf cart, the battery may not get charged. Make sure that you have refueled your golf cart, and then check for the following issues.
Why does my golf cart stop moving?
This Golf cart is very temperamental, and even things like over-tightening a stud can make it stop moving. Check the F/R switch stud for overtightening. If it is over-tightened, the contact will not connect with the switch. Adjust this, and your golf cart will start working.
Why won't my golf cart start?
If your golf cart does not start even though the starter is rotating, there could be a problem with your battery, solenoid, or starter. Check the ignition and make sure you make the necessary repairs and replacements.