The battery charger supplied with the Yamaha golf cart has LED light indicators on it. The first one is the indicator that shows that the charger is connected to the mains and is ON. Whenever there are charging errors, the other two LED indicators will start flashing.
Why is my Yamaha golf cart not charging?
The most likely reasons why a Yamaha golf cart is not charging are: The battery charger is damaged
What does the yellow light in my golf cart Charger mean?
The yellow light in your golf cart charger flashes when the batteries need to be charged. If you have not used your golf cart for some time and the battery charge level goes below the threshold, the yellow LED indicator starts flashing. Once the charging starts, the flashing of the yellow light will stop.
How do I know if my golf cart charger is charging?
New style chargers will have a blinking light showing charger status, old style golf cart chargers will have an amperage meter (Needle swing gauge style) If the charger is in fact charging you will see this needle swing to the opposite side of the gauge and the charger usually very noisy will start humming away as it charges.
What voltage do I need to charge my Yamaha golf cart?
A minimum of 25-30 volts is required to wake up the charger and for it to begin charging your Yamaha Golf Cart. A failure in the “brain” of the charger can also cause the charger to take very long to start charging or to recharge fully.
What does a blinking light on a battery charger mean?
The CHARGE light may flash for the following reasons: The environmental temperature is too cold to charge the battery pack. The battery pack has not been used for a long time. There is a poor connection between the battery and charger.
How do I know if my golf cart batteries are charging?
You'll want to completely charge your golf cart before testing. While the charger is running, test your volts every 15 minutes. Whenever you see the same voltage back to back, that's how high your batteries' voltage will go and will give you an idea how good the batteries are.
How do I make sure my golf cart is charging?
2:083:54How To Charge Your Golf Cart Batteries Manually If ... - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo make sure that you set a timer. So you're not overcharging. And hurting your batteries. So rightMoreSo make sure that you set a timer. So you're not overcharging. And hurting your batteries. So right now my charger is in the off position.
How do I know if my golf cart charger is not working?
1:103:54Golf Cart Charger Troubleshooting Guide | ASK DAVE | Golf Cart GarageYouTubeStart of suggested clipEnd of suggested clipTest good first off the most common issue when a charger doesn't engage is dead batteries golf cartMoreTest good first off the most common issue when a charger doesn't engage is dead batteries golf cart chargers start automatically by receiving voltage from your cart.
What do the lights on a golf cart charger mean?
The blinking LED lights indicate different status of charge: Short green flash = less than 80% charged. Long green flash = more than 80% charged. Solid green light = 100% charged. Red flash = fault code, charging error.
How do I know if my battery charger is working?
Running a test on your battery charger is an easy process.Plug in your charger to an electrical outlet. ... Turn on your voltmeter unit. ... Take a battery or battery pack that's compatible to your battery charger. ... Check the readout on the voltmeter and see where the pointer is indicating to.More items...
How do you charge a Yamaha golf cart battery?
1:312:05Yamaha Golf Car- Consumer - Charging Batteries - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition lift the seat and move the toe run switch to the toe. Position with the charger properlyMorePosition lift the seat and move the toe run switch to the toe. Position with the charger properly connected and grounded insert the charger plug into the golf car receptacle.
Can you leave golf cart charger plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
How long does it take to charge a 48 volt golf cart?
Charge your batteries for 8 to 10 hours with the proper style of golf cart battery charger. The best practice is to charge overnight after you are done using your cart for the day. Even if you only used the cart for 5 minutes, you'll want to give the golf cart batteries a good charge.
How do you know if your cart is fully charged?
Your vape pen will have a light indicator on the LED to let you know what the battery needs. The low battery signals with a red light or flashing white light (depending on the model), meaning you need to charge it. Once the light on your screen turns green you know it is fully charged and ready to be used.
How do you test a Yamaha 48 volt charger?
Turn on the Charger – Once you have the voltmeter attached to your battery charger, turn on the charger to read the electrical output. Typically, the needle on the voltmeter will move from left to right – with right being higher – to gauge the amps produced.
How do you reset a golf cart charger?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
How many volts does a Yamaha golf cart charger have?
Use the Yamaha charger that came with the vehicle, and not any other kind of charger. Look for a rating of 48-Volts labeled in a specification plate on the Yamaha charger. Make sure that the DC output lead on the Yamaha charger is inserted into the golf cart receptacle and that the AC plug is inserted into a wall outlet.
What is a problem with Yamaha battery chargers?
Problems with the chargers can include damaged batteries, error lights, and the charger being improperly plugged in. These kinds of problems can be corrected by following some steps.
What is the first light on a charger?
The first light on the charger is the power light . This light should be on when the charger is plugged into the AC power. Check that the charger is rated 48 volts if the batteries become damaged. If you see discoloration on the batteries over time and they don't hold their charge, the batteries may have become damaged.
Where is the tow switch on a golf cart?
The "Tow" switch is usually under the seat on golf carts. Monitor the lights on the charger. The second and third lights are error lights. If they are flashing red, reconnect the charger to the batteries and try the charge again. The first light on the charger is the power light.
What happens when a golf cart battery is fully charged?
When the battery bank in your golf cart is fully charged, the flashing will stop and you will notice one solid green light. You should note that the LED indicators on the battery chargers for golf carts are different for the different brands and models. Each charger may have its unique set of colored LED indicators.
What does a green light on a golf cart mean?
A green light flashing on the battery charger of your golf cart usually indicates the charge level of the battery. Short green flashes mean the charge level is below 80%, where long flashes mean the charge level is above 80%. If it is one solid green light it indicates the golf cart’s battery is fully charged to 100%.
Why does my golf cart light flash yellow?
The yellow light in your golf cart charger flashes when the batteries need to be charged. If you have not used your golf cart for some time and the battery charge level goes below the threshold, the yellow LED indicator starts flashing. Once the charging starts, the flashing of the yellow light will stop.
Why does my EZGO RXV battery light flash red?
If the red light flashes twice, it indicates that the battery voltage could be too low and the charger is not able to charge the battery bank.
Why does my battery charger flash twice?
If the voltage is beyond these limits – lower or higher , the red indicator flashes twice. The battery charger timeout with three flashes can be due to one of the three situations given below: The charge in the battery bank has gone below 50%. The batteries have gone old and cannot take more charge.
Why does my charger flash red?
There can be four red flashes as well which means that it is another form of battery charger timeout. Six red flashes indicate that the charger is faulty. The battery voltage fault could be due to either high voltage or voltage below the required level.
What is the green light on an EZGO golf cart?
You may notice two types of flashing of the green light on the EZGO golf cart charger. One is a flash of short duration while the other is a long flash.
How to maximize battery life on golf car?
To maximize the battery's lifespan and optimize its performance, charge the golf car before each use and perform battery maintenance as listed in the owner's manual.
How to charge a battery in a garage?
Place the battery charger on a solid, level surface that is fireproof, such as a concrete garage floor, and in a well-ventilated area. Plug the charger into a grounded, three-prong electrical outlet. Attach the DC outlet cord to the charger.
How many holes does a Yamaha golf car have?
for use on golf courses or for personal short-range transportation. Each battery charge should allow the car's use for 36 holes of golf, or approximately eight hours of driving time.
Where to put female plug in charger?
Insert the grounded female plug into the slot on the back of the charger, or attach the positive and negative connectors to their respective color-coded nodes on the back of the charger, depending on the charger model you have. Remove the faceplate covering the DC receptacle, if there is one.
Can you charge a battery in a well ventilated area?
Charge batteries in a well-ventilated area, as explosive hydrogen gas is produced while the battery is being charged. Do not disconnect the DC outlet cord from the battery receptacle while the charger is on. This may create a charged arc that could cause an explosion.
Why is my golf cart battery charger not working?
Bad connections will cause any battery charger to not function properly. After you've charged up your batteries and checked every connection and you are still having issues, it's probably safe to say you've got a golf cart battery charger problem and may need to service it or buy a new one.
Why is my golf cart charging red?
Occasionally a red fault light on a golf cart charger can mean that the batteries do not have enough voltage in them to allow the charger to kick on (see Charging Dead Golf Cart Batteries above).
What is an OBC on a club car?
When you plug the charger into your Club Car, the OBC will tell the battery charger when to start and stop charging based on the voltage levels in your batteries.
What voltage do you need for a 36V golf cart?
You must match volts to volts. A 36V cart requires a 36 volt golf cart charger. A 48V cart requires a 48 volt golf cart charger. You can burn up your batteries if you do not charge with the proper voltage.
How many volts does a golf cart battery need?
An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
Why is my charger making a clicking noise?
If the charger makes a loud clicking noise, this is likely a battery charger issue.
How to keep a charger from getting hot?
But here are a few general tips to keep the charger from overheating: Make sure that your battery cable connections are correct, clean and tight.
How to save a golf cart battery from overcharging?
To save your battery from overcharging, you can use an automatic golf cart charger that will shut off once the batteries are fully charged.
What affects battery life of golf cart?
One of the most important things that affect battery life is your purchasing power. Do not buy a charger simply based on lowest cost. Consider the quality of the golf cart charger before buying.
How long do golf cart batteries last?
Golf cart batteries generally last for 4 to 5 years. After 4 to 5 years, if you find your batteries not working correctly, it may be time to replace them with new batteries. For a new set of batteries, browse through our wide selection here: https://www.golfcartgarage.com/golf-cart-batteries/. #Batteries. #Troubleshooting.
Why is water important for batteries?
Add water when the batteries are completely charged. It's important to add water at the right time and in the right amount for optimal performance.
Can you leave a golf cart inactive?
Leaving the golf cart inactive for an extended period reduces battery life. Using the batteries in a partial state of charge or storing the discharged batteries may damage them badly.
Can changing batteries affect the battery?
However, improperly changing the batteries can surely affect the batteries. The wrong charger can break down the internal battery cells, so make sure to use the charger designed for your batteries.
Can you drive a golf cart on a steep hill?
Driving your golf cart forcefully on the steep hill could leave you stuck and damage your batteries.
What happens if my golf cart is not charging?
If you do not have any voltage in the batteries you will need to get some back into the battery bank before the golf cart charger will charge again .
What voltage do golf cart batteries work on?
All golf cart battery chargers usually operate on 110VAC but some have the ability to operate on multiple voltages for other power grids like in Europe vs US. 110/230VAC would reflect this feature on charger. Good DC side connection. This is the wire or cord with a connector that you would plug into the golf cart.
What is the third pin on a golf cart?
Then the third pin is usually a low voltage signal for a lock-out feature on these newer style golf carts. This is so the user cannot drive off with a golf cart “If the charger is still plugged in”.
Where to find battery in golf cart?
You will usually find the batteries to your golf cart under the front seat which opens or folds out towards the golf cart steering wheel on most Club Cars, Ezgo and Yamaha golf carts. Look for the two terminals with the most wires going to them. Usually this is the positive and negative most terminals in the battery bank.
Do golf cart batteries work the same?
Wiring batteries in a series style circuit is quite simple and always the same. No mater how many golf cart batteries you have it will always work the same.
How to troubleshoot a golf cart battery charger?
If your batteries get too low, you could be stranded. To avoid this, you have to ensure that your battery charger is working correctly. If your battery charger ever fails, ...
Why is my golf cart not charging?
If your batteries are carrying a minimal load, and your charger will still not charge them, it may be because your golf cart’s onboard computer is confused about how much charge they are currently carrying.
Why does my charger fail?
If your batteries aren’t hooked up correctly, or the connections between them are weak or frayed, this can quickly lead to a loss of power and cause your charger to fail. Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems.
How many volts does a battery charger need to charge?
When your charger can’t tell that your batteries are hooked up, it often won’t even turn on. A base charge of 25-30 volts is usually sufficient to wake up your charger and begin charging. To get around this problem, specific chargers offer modes that keep your batteries charged even when you’re not using them.
What to do if battery charger fails?
You can’t address every problem with a simple DIY repair, but a sound diagnosis can save hours of frustration. In many cases, the solution is simple, and you’ll be able to handle it with minimal expense.
Why won't my battery turn on?
Make Sure the Batteries have Some Charge. In the scenario that it doesn’t turn on, it might mean you waited too long to recharge them, and now the charge that they currently carry is too low for the charger to detect them. When your charger can’t tell that your batteries are hooked up, it often won’t even turn on.
What to do if battery is stuck at no charge?
However, if you’re stuck at no charge, a small, manual charger should provide each battery with enough juice to activate your regular charger.
How often should you charge golf cart batteries?
Golf cart batteries should be kept fully charged at all times – this means hooking them up to a charger as soon as you are finished using the cart. Regular charging will prevent damage to the battery and give it longer-lasting life.
Should golf cart batteries be charged after every use?
Yes. Charging your golf cart batteries after every use – even if you’ve only spent five minutes driving – is crucial for maximising their lifespan. Leaving batteries in a prolonged state of low charge can decrease their capacity over time and wear them out quicker.
Should you charge new golf cart batteries?
Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.
Should your golf cart be turned on when charging?
No. You should turn your golf cart off when charging its batteries. Trying to charge a golf cart while it is running is a pointless exercise, as the battery will be draining while you’re trying to charge it. A golf cart should only be turned on once its batteries are fully charged.
Should golf carts be plugged in all the time?
No, you should not leave your golf cart plugged in all the time. While automatic battery chargers are designed to shut-off once at full capacity, leaving a battery connected to power for long periods leaves it susceptible to damage should the electrical circuit be overloaded.
Should golf cart batteries make noise when charging?
If your golf cart uses a standard 12 volt flooded lead acid battery, then it is quite normal to hear a bubbling sound when it’s charging. However, if your cart uses a sealed battery (such as a gel or AGM battery), then a hissing or bubbling sound may indicate damage.
How long should golf cart batteries last?
If you play golf twice a week – and use your golf cart for each round – you can expect a standard, brand-new battery to last just under 10 years before needing to be replaced. If you charge your battery correctly after use, you can maximise its shelf life.