Your Yamaha golf cart may have no power due to a problematic fuel filter, a cracked rubber boot, dirt/debris accumulation, or improper combustion. If you have an electric golf cart, faulty batteries or wrong battery connections may also cause the problem. Problematic fuel filter
Full Answer
Why does my Yamaha golf cart not start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
What would make a gas golf cart not start?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
Where is the reset button on a Yamaha golf cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
What does the igniter do on a Yamaha golf cart?
The Nature of Golf Cart Ignitors In essence, the ignitor works to enhance electrical signals and produce a larger flow of electricity to the coil that helps your spark plug operate. In this way, it is an essential part on gas-powered golf carts but is usually not found on electrical carts as there is no need.
Where are the fuses on a Yamaha golf cart?
Yamaha Golf Cart Fuse Box Location The fuse box in a 2014 Yamaha golf cart is located on the left side of the controller. The wires are tied to the roof drain. In a G2 electric cart, the fuses are present on the rear inner fender. This is on the front of the driver's side of the cart.
How do you test a fuel pump on a Yamaha golf cart?
A simple way to determine the fuel flow is to remove the fuel hose at the carburetor and hold over a small container. Attempt to start the engine and if all is well, the fuel should spurt out with reasonable force in pulses as the crankcase pressure varies. We hope you've enjoyed out tutorial on golf cart fuel pumps.
How do I know if my golf cart solenoid is bad?
Press on the accelerator while the key is turned on and the cart is in forward.The solenoid needs to be replaced IF the voltmeter shows a full battery voltage without a click.If your voltmeter stays at 0, the problem stems from somewhere else in your cart.
Where is the solenoid located on a Yamaha golf cart?
1:0011:27Yamaha G29 Golf Cart Solenoid Replacement - YouTubeYouTubeStart of suggested clipEnd of suggested clipComing down to here under the seat and there's two little fasteners here and you just pop them outMoreComing down to here under the seat and there's two little fasteners here and you just pop them out flat head screwdriver pull it.
How do you start a Yamaha golf cart?
1:412:58Yamaha Golf Car- Consumer - Operating Basics - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition during the key switch to the on. Position slowly press the accelerator pedal to disengageMorePosition during the key switch to the on. Position slowly press the accelerator pedal to disengage the farc brake and gently apply pressure to the accelerator pedal to increase the speed.
How do you test a golf cart ignition coil?
Take the voltmeter's black and red probe and place it on the –ve and +ve terminal of the coil. Take the readings. It should be between 3.7-5.2 ohms. If outside the range, the coil should be replaced.
Where is the igniter located on a golf cart?
0:001:15EZGO igniter location - YouTubeYouTubeStart of suggested clipEnd of suggested clipA quick video on an easy go golf cart. If you need to change the igniter. Not the ignition coilMoreA quick video on an easy go golf cart. If you need to change the igniter. Not the ignition coil which is that right here igniter it's underneath this cover right here.
What does a coil igniter do?
The igniter is the step up transformer that sits inline between the engine control computer and the ignition coil. It takes the low amperage signal from the computer, usually a 12 volt square wave, and steps it up to higher amperage trigger signal for the ignition coil.
What happens when a spark plug is taken out on a Yamaha golf cart?
You can check the oil for a possible contamination of gas.
Why won't my golf cart start?
Faulty brakes: Very often, faulty brakes are the reason why a golf cart won’t start. You should be able to adjust the breaks at home. However for more complicated repairs, it is better to pay a visit to your nearest professional mechanic.
Why does my golf cart keep turning but not starting?
Solenoid problems: A solenoid can wear out after using your golf cart regularly. A faulty solenoid can cause your golf cart to turnover but not start. Your golf cart solenoid is a coil of wire cylindrical in shape, but in reality it functions as magnet carrying electricity.
Why won't my Club Car Precedent Golf Cart start?
Club Car Precedent golf cart turns over but won’t start. A faulty spark plug, bad battery or low compression levels are the main reasons why a Club Car Precedent golf cart will turn over but not start. Lack of spark in the coil: in this case, you have to replace the coil if it doesn’t spark. Spark plug: Also look whether ...
Why is my golf cart starting with a key switch?
Key switch problems: Keyswitch issues is a common cause of golf cart starting problems as the key switch will wear out over time. You have to check the keyswitch area for any loose or broken piece of wiring. Be very careful while doing this since you might get a nasty shock.
What to do if golf cart doesn't start?
If you find any moisture, you have to replace the plug. If the golf cart doesn’t start, you will want to clean the carburetor with some cleaning fluid. You can also take a look at the fuel bowl to check if it’s empty. If not, open and drain it.
Can a Yamaha G2 golf cart start?
Yamaha G2 golf cart turning over but not starting. A good spark, air and gas is usually sufficient to get a Yamaha G2 golf cart started. But if it’s not, then check out for a crack in the spacer of the carburetor. Next check if the ignition coils are connected to the two wires that are there. Then check for spark.
Why does my Yamaha golf cart have no power?
A Yamaha electric golf cart usually has no power on its solenoid due to a faulty controller, cut wires, or blown-out fuses. Remove the small black wire connected to the solenoid and check if the voltage of its small red wire connection rises to the battery pack voltage. If yes, you have to do a controller replacement.
Why won't my Yamaha golf cart go uphill?
Your Yamaha golf cart will not have power while going uphill if it has a fuel related problem, a worn-out, cracked, or loose drive belt or tension cable, malfunctioning clutches, or low battery voltage.
Why is my Yamaha G16 losing power?
Your Yamaha G16 could be losing power because of a malfunctioning secondary clutch, a broken secondary spring, a worn-out drive belt, or bad fuel. Sometimes, loose wire connections or cable ends, dirty air and fuel filters, a faulty spark plug, or an improper valve adjustment may trigger the problem.
How to check if golf cart is running out of power?
Do a compression test on the golf cart using a compression tester. Low compression can also cause the golf cart to run out of power. Also, check the fuel pressure and ensure that it’s as desired. Check the clutch to see if it’s functioning properly. It should shift out when the cart is on jacks.
Why is my Yamaha G1 golf cart not turning on?
Your Yamaha G1 golf cart may have no power because of cracked seals, a plugged muffler, a fouled spark plug, or low compression. A malfunctioning clutch, an improperly adjusted carburetor, or a worn-out drive belt can also cause this problem.
What to do if a cylinder is not working?
Check the cylinder to see if compression is taking place as desired and note the timing. If it is not working as desired, you may have to change the cylinder.
Where is the fuel filter on a golf cart?
Check if the fuel filter of your golf cart is damaged and do a replacement if necessary. This filter is usually located in the fuel tank of the cart. If it’s not damaged, this is a good chance to get it cleaned.
Why won't my electric golf cart start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won’t start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
How to reduce golf cart issues?
However, the best way to reduce your chances of golf cart issues, later on, is by performing regular preventative maintenance. With preventative maintenance, you can extend the life of your golf cart and potentially save money in the long run.
What is the best way to check if a golf cart battery is charging?
A Battery Hydrometer: A battery hydrometer measures the specific gravity of the electrolyte solution and can indicate whether or not your batteries are charging correctly. This method is inexpensive and reliable, making it a popular choice for golf cart owners.
Why does my golf cart make a clicking noise?
The solenoid is a critical component of your golf cart because it is the main switch that connects the current from the battery to the traction motor. That clicking noise that you hear when you press the gas pedal is the solenoid.
How to test golf cart batteries?
Another method to test your batteries is by using a load tester. Battery load testers can come in a variety of different price ranges. They give golf cart owners the ability to monitor their battery’s voltage to see how much the volt drops during testing, which indicates the health of the batteries.
How to check if a battery is charged?
Make sure your batteries are fully charged, first, and then check for the following: 1 Any cracks or dirt in the batteries. 2 The water-electrolyte levels (on a weekly basis). If the water runs too low, it can shorten the life of your batteries. Overfilling can also result in a loss of electrolytes. 3 Look for signs of corrosion on your connectors and ensure that they are tight. 4 Dirt and other debris can affect the performance of your batteries. Clean them regularly with a bristle brush, water, and baking soda, but take care not to get any of the electrical components wet.
Can you prevent problems with a golf cart?
While some problems are simply bad luck, many issues with your golf cart can be avoided through simple preventative maintenance. By keeping your golf cart in good condition, you can extend its life and save yourself tons of money in the process.
How many volts does a Yamaha golf cart need to charge?
A minimum of 25-30 volts is required to wake up the charger and for it to begin charging your Yamaha Golf Cart. A failure in the “brain” of the charger can also cause the charger to take very long to start charging or to recharge fully. This can be solved by an easy replacement and doesn’t even require many bucks.
Why is my Yamaha G1 not charging?
Yamaha g1 Golf Cart not charging. Often, the G1 golf cart doesn’t charge because of a bad receptacle. Make sure that the receptacles fit tightly and are clean. If not, then you can get the receptacles cleaned and tightened. Check the plastic coverings on the prongs. A broken cover can also build problems.
What does the red light on my charger mean?
The error lights are the second and third light indicators. If the error light is flashing red, try reconnecting the charger and then charging the battery again. The first light indicates power. It will turn on when the charger gets plugged into the AC power. Check the voltage of your batteries.
Why does my battery not charge after turning on?
At times, even after turning on the charger, nothing happens. This happens if the battery is not recharged for a long time. That’s because the charge that is currently present in the battery is too low for the charger to detect. A minimum of 25 volts must be provided to the charger to start charging.
Why won't my golf cart charge?
Another reason your golf cart won’t charge could be because nothing would happen even after you plug in the charger. The most likely cause behind this problem is the connection problem with batteries. You can confirm and test this problem using a voltmeter.
Can you fix a golf cart on your own?
Under NO circumstances should you attempt to fix your golf cart on your own. Doing so is dangerous and could result in serious bodily harm. The information on this website has not been verified for accuracy and should only be used for general information purposes only. Use this information at your own risk.
Is the Ping G25 adjustable?
Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...
Why is my Yamaha golf cart not moving?
The main cause of a Yamaha golf cart clicking but not moving, is a faulty controller or solenoid. The battery has to be checked first to see if it’s delivering the right voltage while in the idle state as well as when the pedal is pressed. There can be other reasons for the Yamaha golf cart not moving though you hear the click.
What to do if your G9 golf cart is not clicking?
If you find your G9 Yamaha golf cart not starting nor clicking, check the key components for damage. If you find the parts to in good condition, check the brushes in the starter/generator.
What is a faulty controller?
The controller is one major component that may have to be replaced. A faulty controller can stall the cart and the click you hear must be from the solenoid. Test the solenoid to see if it is functioning properly. You will require a multimeter, preferably a digital one, or a DVM for this.
How to check solenoid on G9 Yamaha?
The solenoid can be checked using an old screwdriver to jump the terminals. Your G9 Yamaha golf cart’s key must be in the start position. If the starter turns when you do this, your solenoid needs to be replaced. You must be careful while doing this crude test; there could be sparks when the two terminals touch.
Why is my solenoid not clicking?
The reason why the solenoid is not clicking could be that it is faulty or has no grounding. Experts recommend checking all wiring and cable connections to rule out this possibility. Batteries on your G16 Yamaha golf carts should raise sufficient power to reach the solenoid and the starter/generator.
What happens if your carburetor is wet?
If it is wet, then the carburetor is actually supplying air/mix of some kind to the combustion chamber. If it is dry as a bone, at least you'll know which way to head (into the carburetor).
How to tell if spark plug is compressed?
You really need to use a compression gauge to know for sure. The finger over the spark plug hole will tell you if there's compression or not but it may not have enough compression to start. The only way to rule it out is use a compression gauge.
What happens if compression goes up?
If the compression is low you can shoot a little oil in the cylinder. If the compression goes up it's a ring issue if it doesn't it's a valve or timing issue. Have you tried a new spark plug?
Do spark plugs fire under compression?
Some spark plugs will fire fine when checked outside of the hole but will not fire under compression, as Rod said a compression test will answer a few questions#N#Most auto parts stores rent compression testers if you don't have one, always test with the throttle held all the way open with your hand.
Why is my golf cart not working?
There could be many reasons why your golf cart spark plug is not working. Some of them are given below. The insulator in the spark plug is broken causing an internal grounding.
Why is my golf cart's igniter failing?
Alternatively, the connections may be dirty. There is a faulty RPM limiter in the golf cart. The igniter has failed because of a bad voltage regulator.
What size spark plug does a Yamaha G9 have?
Yamaha G9 golf carts have NGK BR4ES spark plug with a long reach of 14mm x ¾ inch. However, some of them utilize anNGK BPR2ES spark plug. The following are some points worth looking into if you have an issue with the spark plug in your cart.
What size spark plugs are in a 1993 Ezgo golf cart?
The plug gap also varies accordingly. Most EZGO golf carts have a 15/16 inches socket while a 1993 model has a socket size of 1-1/8 inches.
What to do if there is no spark in a car?
If there is no spark, unplug the white plug with blue and black wires that are at the bottom of the engine under the valve cover. Check for spark once again. If there is a spark, the coil is in good condition and the ignition kill relay or its wiring is at fault.
Why is my golf cart switch corroded?
Sometimes the switch may have corroded because of extensive contact with water or dirt and this may have caused a bad connection. Check the continuity of the switch wires using a meter. Check if the compression valve used is appropriate for the golf cart.
Is the Ping G25 adjustable?
Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...